2001 FORD EXPLORER SPORT TRAC Complaints

01 FORD EXP SPORT TRAC 4X4 WITH REAR RADIO/AC CONTROLS AIR BAG WARNING LIGHT DOES NOT GO OUT AND KEEPS POPPING FUSE (LOCATION FOR FAN BLOWER) AND BLOWER INOP EVEN WITH HIGHER AMP FUSES. HAPPENS CHANGE WEATHER COLD/HOT AND ROUGH ROADS. JIGGLE WIRE HARNESS UNDER DASH/CENTER CONSOLE AREA CORRECTS (TEMP). CAN NOT TROUBLE SHOOT AIRBAG MOD WHEN FUSE BLOWN. AC INOP WHEN FUSE BLOWN. *TR

TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE OVERDRIVE LIGHT KEPT ILLUMINATING ON THE INSTRUMENT PANEL AND THE TRANSMISSION WAS SLIPPING. THE SHIFT SOLENOID WAS REPLACED, BUT BEGAN TO FAIL 4,000 MILES LATER. THE FORD MANUFACTURER WAS AWARE OF THE FAILURE, BUT COULD NOT ASSIST BECAUSE IT WAS NOT A SAFETY ISSUE. THE FAILURE MILEAGE WAS 58,000.

FRONT BRAKE ROTORS WARP AND BRAKES ARE BAD WITHIN 13,000 MILES. PROBLEM HAS RECURRED SEVERAL TIMES. APPARENTLY THE BRAKES FOR THE HEAVIER FORD SPORT TRAC MODEL ARE FROM THE LIGHTER FORD RANGER AND UNDERSIZED. BRAKES FAILING ON THIS SHORT INTERVAL COULD LEAD TO DRIVERS ON THE ROAD WITH TOTALLY INADEQUATE BRAKING CAPACITY. *TR

NO REAL EVENT LEADS TO THIS FAILURE. PROBLEM IS THE "DOOR AJAR" LIGHT ON THE DASH. IT DETECTS WHETHER A DOOR IS PARTIALLY OPEN. THE SWITCH IN ONE OF THE DOORS FAILS FOR NO REASON. WHEN IT SENSES THIS FALSELY, THE DASH WARNING LIGHT COMES ON & BEEPS A TONE & QUITE OFTEN THE INTERIOR DOME LIGHTS TURN ON. THE DEALER SAYS TO LUBRICATE THE DOOR LATCHES & WORK THEM SEVERAL TIMES. I'VE DONE THAT MANY TIMES & IT DOES NOT HELP. WHEN THE SWITCH FAILS & THE LIGHT COMES ON, IT MAY BE BRIEF BUT OTHER TIMES, I'LL PARK THE TRUCK & WALK AWAY & THE LIGHT REMAINS ON FOR QUITE A LONG TIME. I'M SURE I'LL COME OUT TO A DEAD BATTERY ONE DAY. PLEASE CHECK THIS OUT. I HAVE SEEN HUNDREDS OF OTHER REPORTS LIKE THIS ON THE INTERNET - FOR VARIOUS FORD MODEL CARS & TRUCKS. THE LIGHT COMING ON IS VERY DISTRACTING AND COULD BE DANGEROUS. *TR

2001 FORD SPORT TRAC 49,000 MILES HAVE HAD LOWER BALL JOINTS REPLACED TWO YRS AGO AND YESTERDAY 12-17-2008 HAD THE UPPERS REPLACED. ALL FOUR WERE PERM SEALED TYPE. I AM 64YRS OLD AND HAVE NEVER BEFORE HAD BALL JOINT PROBLEMS. PLEASE FORCE CAR COMPANIES TO GO BACK TO GREASE FITTINGS ON SUCH AN IMPORTANT PART OF A VEHICLE. *TR

THE RIGHT REAR SIDE OF MY FORD THE CAB MOUNT HAS RIPPED APART THE STEEL MOUNT HAS FAILED. THE CAB IS IN DANGER OF LEAVING THE FRAME. THE BODY SHOP TOLD ME THAT THIS IS A FACTORY DEFECT AND IS VERY DANGEROUS. THE TRUCK HAS ONLY 74534 MIL. 2001. I'M THE ONLY OWNER, THE TRUCK IS GARAGE KEPT AND VERY WELL MAINTAINED. THIS TRUCK WAS BUILT IN OCT. 2000 AND I BOUGHT THE TRUCK IN NOV. 2000. *TR

CHECK ENGINE LIGHT CAME ON, WITHIN HOURS THE TRANSMISSION STARTED NOT CATCHING...WOULD REV BETWEEN 2-3K RPM OR AROUND 30 MPH BUT NOT ACCELERATE. THEN O/D LIGHT STARTED BLINKING. ALL OUT OF THE BLUE.

TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT HIS CHECK ENGINE LIGHT ILLUMINATED. A DIAGNOSTIC WAS PERFORMED AND THE DEALER STATED THAT THE EGR SENSOR FAILED. THE DEALER AND MANUFACTURER STATED THAT THERE WERE NO OPEN RECALLS AVAILABLE PERTAINING TO HIS VIN; THEREFORE, IT WAS EXCLUDED FROM RECALL NUMBER 02M01S6. THE CONTACT IS RESPONSIBLE FOR THE REPAIR COSTS. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 70,000.

IN NOVEMBER 2007 I RECEIVED A RECALL NOTICE. I PROMPTLY CONTACTED MY LOCAL DEALER AND PLACED MY NAME ON THE "WAIT" LIST. I HAVE CALLED THREE TIME SINCE AUGUST AND HAVE BEEN ASSURED EACH TIME THAT I AM STILL ON THE LIST; HOWEVER, MANUFACTURER HAS NOT SHIPPED THE PART FOR MY 2001 FORD SPORT TRAC. *TR

FORD SENT ME A NOTICE IN THE JULY/AUGUST 2007 TIME FRAME ADVISING ME OF A RECALL ON MY FORD SPORT TRAC FOR A CRUISE CONTROL CABLE THAT COULD LEAD TO AN ENGINE FIRE. SEVEN (7) MONTHS LATER MY DEALER IN SPRINGFIELD, VA STILL DOES NOT HAVE THE REPLACEMENT PARTS. THIS IS TOTALLY UN-ACCEPTABLE. *TR