1997 FORD F SUPER DUTY Complaints

TL*- THE CONTACT OWNS A1997 FORD F SUPER DUTY. HE RECEIVED A RECALL NOTICE ON THE CAMSHAFT POSITION SENSOR, WHICH CAN CAUSE ENGINE STALLING. HE HAD BEEN EXPERIENCING THAT PROBLEM WHENEVER HE APPROACHED LOWER SPEEDS IN HIS VEHICLE. HE TOOK THE VEHICLE TO THE DEALERSHIP THEY REPLACED THE SENSOR WITH A NEWER AND NON-DEFECTED SENSOR. AFTER THEY REPLACED THE SENSOR THE VEHICLE WOULD NOT START. THEY TRIED SEVERAL SENSORS AND NONE OF THEM WOULD START THE ENGINE. THE MECHANIC THEN PLACED THE OLD SENSOR BACK INTO THE VEHICLE AND THE ENGINE WAS ABLE TO TURN ON. THE MECHANIC TOLD HIM TO BRING THE VEHICLE BACK IN THE FOLLOWING DAY. WHEN HE TOOK THE VEHICLE BACK IN THE NEXT DAY, THEY REPLACED THE SENSOR ONCE AGAIN AND THE VEHICLE WOULD NOT START. THEY PLACED THE OLDER SENSOR BACK INTO THE VEHICLE AND HE WAS ABLE TO DRIVE AWAY. MINUTES AFTER DRIVING AWAY THE CHECK ENGINE LIGHT STARTED TO COME ON AND OFF RANDOMLY IN THE VEHICLE, WHICH IS A PROBLEM NOT PREVIOUSLY EXPERIENCED. HE TOOK THE VEHICLE BACK INTO THE DEALERSHIP AND THEY WERE NOT ABLE TO REPAIR THE PROBLEM. THE CURRENT AND FAILURE MILEAGE WAS 287,000. UPDATED 04/23/08 *BF

1997 FORD F-SUPER DUTY WITH SPEED CONTROL RECALL. CONSUMER STATES THAT DEALER PUT HIM ON A WAITING LIST FOR THE REPLACEMENT PARTS. HE STATES THAT THE DEALER KEEPS TELLING HIM THE PARTS ARE NOT IN AND THEY DO NOT KNOW WHEN THEY WILL BE IN. *KB

TL*THE CONTACT OWNS A 1997 FORD F-530 SUPER DUTY. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL). THE DEALER STATED THAT THE PARTS WERE UNAVAILABLE AND COULD NOT PROVIDE AN ESTIMATED DATE OF ARRIVAL. THE CONTACT FELT THAT THE WAIT TIME FOR THE RECALLED PART WAS UNACCEPTABLE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 40,000. UPDATED 01-10-08. *KB UPDATED 12/31/07 *TR

1997 FORD F-SUPER DUTY WITH A SPEED SENSOR ISSUE. CUSTOMER STATED THAT HE RECEIVED A RECALL FOR THE SPEED SENSOR FAILURE. CUSTOMER SAW THAT HIS VEHICLE COULD CATCH FIRE. CUSTOMER WAS TOLD THE PARTS WOULD NOT BE READY UNTIL THE END OF THE YEAR. *KB THE CONSUMER STATED HIS PRIVATE MECHANIC TOOK CARE OF THE PROBLEM. *JB

TL*THE CONTACT OWNS A 1997 FORD F SUPER DUTY. THE VEHICLE HAS FIRESTONE STEELTEX RADIAL TIRES. WHILE DRIVING 50 MPH, THE CONTACT HEARD A LOUD POUNDING NOISE COMING FROM THE REAR OF THE VEHICLE. HE NOTICED THE TREAD HAD SEPARATED ON THE REAR PASSENGER SIDE TIRE. A TIRE SHOP INSPECTED THE TIRE AND STATED THAT THEY WERE UNABLE TO DETERMINE THE REASON FOR THE FAILURE. APPROXIMATELY ONE WEEK LATER, WHILE DRIVING 60 MPH, THE VEHICLE BEGAN VIBRATING. THE CONTACT NOTICED THE TREAD ON THE REAR DRIVER SIDE TIRE HAD SEPARATED. THE TIRE HAS NOT BEEN INSPECTED. THE CURRENT MILEAGE IS 38,000 AND FAILURE MILEAGE WAS 37,000.

DT: 1997 FORD SUPER DUTY CHASSE CLASS C MOTOR HOME. ALL FOUR BACK TIRES HAVE BLOWN OUT. THE FIRST HAPPENED 2 YEARS, AND IN THE PAST TWO YEARS ALL FOUR BLEW OUT. SPOKE TO THE MANUFACTURER AND THERE WERENO RECALLS. NO ONE KNOWS WHY THESE TIRES HAVE BLOWN OUT. THE CONSUMER WAS DRIVING UNDER NORMAL DRIVING CONDITIONS ON THE INTERSTATE AT 65 MPH. THERE WERE NO CRASHES OR INJURIES BECAUSE OF THE BLOW OUTS. HOWEVER , HAD TO REPLACE THE BACK BRAKES, ROTORS AND THE REAR SEALS ON THE AXLES. *AK

THE BRAKES FAILED WHILE DRIVING. THE CONSUMER FOUND THE BRAKES RESERVOIR EMPTY, THEN INSPECTED THE BRAKE LINES AND SAW A HOLE IN THE REAR BRAKE LINE. *NM CONSUMER LOST CONTROL OF VEHICLE WHEN BRAKES WENT OUT AND WENT OVER A CURB, OVER PARKING LOTS, INTO A PARKING LOT, AND CAUSED FUEL TANK AND STRAP DAMAGE, FRONT END AND REAR TAD AXLE OUT OF THE ALIGNMENT. CONSUMER FOUND WEAR HOLE IN REAR BRAKE LINE, EGR TUBE CORRODED, BURNT ENGINE COVER, AND CARPET. *SB *NM

THE RV VIBRATED AT SPEED OFF 55 MPH AND HIGHER. IT WAS LATER DETERMINED THAT THE DRIVELINE WAS UNDER COATED AND OUT OF ROUND. THE CONSUMER REQUESTED REIMBURSEMENT FOR THE PARTS REPLACED/REPAIRS THAT DID NOT SOLVE THE VIBRATION PROBLEM. *PH *NLM

HAD TREAD SEPARATION OCCUR AT 60 MPH ON RIGHT REAR INBOARD DULEY. AIR TEMPERATURE WAS 90 F.*AK

WHILE DECELLERATING, BRAKE PEDAL WENT SOFT, BRAKE WARNING LIGHT ACTIVATED, AND VEHICLE WAS STOPPED WITH FRONT BRAKES ONLY, NEARLY CAUSING AN ACCIDENT. INSPECTION REVEALED LEFT REAR BRAKE HOSE (FLEXIBLE) HAD BEEN ABRADED BY AFTERMARKET MODIFICATION BY THE MOTORHOME MANUFACTURER, FLEETWOOD ENTERPRISES. TAG AXLE LINKAGE ADDED BY FLEETWOOD ADJACENT TO BRAKE HOSE CAUSED HOSE TO BE ABRADED IN TWO LOCATIONS, ONE OF WHICH WORE THROUGH CAUSING BRAKE FLUID LOSS AND FAILURE.