2021 FORD F-150 Complaints

The truck rapidly accelerated while I was slowly rolling into a parking spot with my foot on the brake. The harder I pushed the brake the more it seemed to accelerate. I luckily avoided hitting anything. I forced the gear shifter out of Drive into park. No warning lights or messages. I contacted 3 Ford dealerships and all said they haven’t heard of this nor do they think they could identify this problem if I brought it in.

Truck fails to accelerate when transmission is in second gear, travelling at low speed (typically under 10 MPH) and at low RPMs (typically ~1,500). Regardless of amount of pressure applied to accelerator, the truck will remain at low RPM and speed for up to 10 seconds. This problem occurs frequently and has been reproduced by a Ford dealer. Ford TSB 25-2302 describes this problem, but in my case a DTC is not present. Because a DTC is not present, the Ford dealer refuses to proceed with corrective actions as outlined in TSB without charging me for diagnostics and labor, although the truck is still under warranty. Failure to accelerate puts me and others at risk when attempting to merge, when accelerating in slow traffic conditions, etc.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000(POWER TRAIN); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure. Wheel replacing the tires the mechanic discovered that the rear driver side wheel bolt had failed and the rear wheel shaft assemblies and axles were replaced. The failure mileage was 36,495.

The contact owns a 2021 Ford F-150. The contact stated that while driving at various would not properly accelerate, the transmission experienced random downshifting and shifting into neutral and lurching forward and the wrench warning light had displayed. The vehicle was taken to the local o rally who diagnosed that the transmission was faulty and needed to be replaced. The failure mileage was 105,000.

My 2021 Ford F-150 Lariat has a repeated failure of the front LED daytime running/perimeter lighting (Driver's Side). The light was intermittently dim before failing completely. This occurred around 94,000 miles. Because this lighting is part of the truck’s front visibility system, the failure creates a safety concern, especially in daylight, rain, fog, and low-light conditions. Based on owner reports, this may be a widespread defect affecting other 2021+ F-150 trucks. I request NHTSA evaluate this issue for a possible defect investigation and recall.

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, a loud rattling noise was heard coming from the vehicle, with no warning lights illuminated. The contact received notification of NHTSA Campaign Number 23V896000 (Power Train); however, the parts required to perform the recall repair were not yet available. The vehicle was taken to multiple dealers, where it was diagnosed that the left and right rear axle shaft assemblies had failed and needed to be replaced. The contact also stated that the dealer found an axle bolt inside the rim of the vehicle. The vehicle was not repaired, and the dealers confirmed that the remedy parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The contact also stated that the failure recurred, and the right-side axle is beginning to detach. The manufacturer was made aware of the failure. The approximate failure mileage was 90,000.

Daytime Running Lamps, vertical beam on driver side does not function after 4 years. Research shows it's likely melting the headlight assembly components during overheating and burnout.

NHTSA Recall Number23V896. The bolt on my shaft has been broken for 9 MONTHS. Ford and Dealer giving me the run around. PARTS ARE NOT AVAILABLE!!!.

The rear window basically has 3 parts. Driver side, center sliding section, and passenger side. Only the driver side section defrost. According to online forums specifically for Ford trucks, this is a common issue. Ford’s Special Service Message (SSM) 48490 does reference this as a known issue.

Brought F150 in for scheduled service - oil change. Also asked for inspection of a problem with the fuel door hatch that was causing "Refuel Error" messages on the instrument panel and several grinding noises every time the fuel release button was pressed. Note that I have an active extended Ford Premiumcare warranty. Dealership diagnosis was that the fuel door solenoid was bad, verified that the gears could be heard grinding with this part. However, there is no separate motor part, therefore the entire fuel door assembly must be replaced. Ford warranty system does not cover this part because it is considered "Body and Structural". I called Ford Protect to discuss this, and explained the motor defect and problem, that this has nothing at all to do with wear & tear or body damage. They explained that in this case, the dealership should call and get the part pre-authorized with the justification. Seelye Ford called and tried to do this on 28 April 2026, but ultimately was still denied by Ford. The attached service report from Seelye describes the technician findings and confirms the bad solenoid and audible gear grinding sound coming from the fuel door assembly - and that the entire assembly must be replaced. As this is related to the fuel system and has a defective motor, this is an example a safety defect that should not only be repaired on this vehicle, but for other vehicles with similar problems. Note that the dealership also pointed out that Ford appears to have created this part layout with the intent of having the motor be a separate part, but ultimately did not offer that option, only a full housing replacement, which is excluded because it is mostly made of plastic and metal, which is considered to be structural in nature, despite being a part of the fuel system that has active motor buttons and instrumentation sensors for driver interaction.