1994 FORD F-150 Complaints

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE

VEHICLE WAS PARKED INSIDE GARAGE AND TWO HOUR LATER THE VEHICLE CAUGHT ON FIRE. DRIVER CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE. VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. *AK

FORD F150 TRANSMISSION. *BF AT IDLE WHEN THE GEAR WAS PLACED IN REVERSE, THE VEHICLE WOULD JERK HARD, THE IGNITION SWITCH WOULD GET REALLY HOT, THE HORN WENT OUT, THE AIR BAG LIGHT ILLUMINATED, THE ENGINE IDLER PULLEY HAD TO BE REPLACED, THE ORIGINAL NYLON BUSHING HAD WORN OUT, THE WIPER SWITCH ONLY DISPLAYED TWO SPEEDS, THE WIPER WASHER STOPPED WORKING, THE ANTI LOCK BRAKES STOPPED WORKING, THE DOME LIGHT HAD A SHORT AND THE ALTERNATOR HAD GONE BAD. *SC

PARKED VEHICLE AT AROUND 6:30 ABOUT 20 MINUTES LATER IT WAS ON FIRE IN THE ENGINE COMPARTMENT ON THE DRIVER'S SIDE. HAD USED THE CRUISE CONTROL THAT DAY AND IT WAS WORKING. PRIOR TO THE FIRE NO OTHER PROBLEMS REPORTED. NO AFTERMARKET EQUIPMENT ON VEHICLE. THE FIRE DID NOT SPREAD TO THE HOUSE. THE CAUSE OF THE FIRE ACCORDING TO CHARLIE MILLER WAS THE SPEED CONTROL SWITCH. CHARLIE MILLER HAS PHOTOS AND VIDEO. 662-748-2328. *AK THE CONSUMER STATED THAT THE VEHICLE HAD BEEN PARKED AN HOUR BEFORE THE FIRE STARTED. *TC

BOTH FUEL HOLDING TANKS LEAKING AT THE SEEMS; I REPLACED ONE AND DON'T USE THE OTHER. I NOTICED IT'S A CONSISTENT PROBLEM WITH THIS MAKE AND MODEL AND WOULD LIKE TO KNOW IF THERE IS ANY MANUFACTURE LIABILITY SO AS TO COMPENSATE. *NM

THERE WAS AN ELECTRICAL SHORT IN THE CRUISE CONTROL SWITCH CAUSED THE CABLES AND HOOD TO BURN ON THE VEHICLE. MANUFACTURER WAS CONTACTED BY CONSUMER.*AK

WHILE VEHICLE WAS PARKED THE TIRE BLEW OUT. CONSUMER STATED THAT WAS WHEN HE KNEW THAT VEHICLE WAS ON FIRE. *AK

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.*AK

SPARKS AND SMOKE IGNITED FROM UNDER THE HOOD AFTER THE TRUCK HAD BEEN PARKED FOR SEVERAL HOURS IN THE DRIVEWAY. THE FAILURE WAS DUE TO A DEFECTIVE CRUISE CONTROL PART #9F924 WHICH WAS REPLACED WITH THE UPGRADED PART BY THE DEALERSHIP. *AK

REAR GAS TANK TRANSFERS FUEL TO FRONT TANK CAUSING FRONT TANK TO OVERFILL AND CAUSES FUEL SPILLAGE. THIS HAS BEEN AN ON GOING PROBLEM SINCE 1998. I HAVE TO REMEMBER TO USE UP FRONT TANK FIRST OR GAS WILL COME OUT OF THE CHARCOAL CANISTER. THIS HAPPENED FOUR TIMES UNTIL I FIGURED OUT WHAT WAS HAPPENING AND OF COURSE TRUCK WAS OUT OF WARRANTY. *JB