2003 FORD F-150 Complaints

COMING HOME TO VA FROM OHIO WE WERE GOING THROUGH THE MOUNTAINS AND HAD TO KEEP FLOORING THE TRUCK. THE SPARK PLUGS ACTED LIKE THEY WERE FOULING AND THE TRUCK SPUTTERED HOME. WE CAME HOME AND OUR MECHANIC SAID WE BLEW OUT OR EJECTED TWO SPARK PLUGS ON OUR TRITON 4.6L 2003 PICK UP TRUCK. HE SAID IT WOULD HAVE TO BE REPAIRED BY FORD AND IT WOULD PROBABLY COST ABOUT $900. WE FOUND OUT THIS IS A RECURRING PROBLEM ON THE NEW NON-PLUG WIRES TRUCKS USING A SERIES OF COIL, OVER PLUG COIL CONNECTORS SPECIFICALLY ON THE TRITON FORD TRUCK MOTORS. WHY HASN'T NHTSA CONTACTED FORD. WE SMELLED GAS THE WHOLE WAY HOME; ABOUT 500 MILES AFTER IT HAPPENED. IF THE GAS FUMES IGNITED IT WOULD HAVE BURNED MY TRUCK UP BUT COULD HAVE HURT MY WIFE AND THREE GRANDCHILDREN RIDING WITH US. [XXX] I BOUGHT THE MECHANIC EIGHT SPARKPLUGS *$6.99 EACH, THEN EIGHT COILED/SLEEVES $52 EACH AND A NEW COIL UNIT $163, HE IS HAVING A COMPANY HELIARC-COILS TO REPAIR THE SPARKPLUG SEATS. THIS IS A VERY POOR DESIGN, AND HAD I KNOWN THIS WHEN WE BOUGHT THE TRUCK, WE WOULDN'T HAVE. I SENT FORD MOTOR A CUSTOMER SERVICE COMPLAINT AS WELL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THERE WERE NO EVENTS LEADING UP TO THE INCIDENT. DRIVING 10-20 MPH THE FIRST TIMES AND 25-35 THE SECOND. 2 SPARK PLUGS EJECTED OUT OF THE ENGINE TWICE IN 4 DAYS 1ST TIME WE TOOK IT TO THE MECHANIC AND IT WAS REPLACED 2ND TIME TOOK IT TO THE MECHANIC AND IT WAS REPLACED. *TR

FORD F150 2003, 5.4 ENGINE. THE SPARK PLUG ISSUE HAS JUST BITTEN ME, NOW I HAVE A 10,000 DOLLAR PEICE OF STEEL IN MY DRIVEWAY BECAUSE I AM NOT PAYING 5400 AND SOME CHANGE TO FIX A PROBLEM THAT SHOULD BE RECALLED, THE PLUG GETTTING HIT BY THE PISTON OR SHOOTING OUT OF THE HOLE CAN BE VERY DANGEROUS BY ALLOWING FUEL TO COME IN CONTACT WITH HOT ENGINE OR ELECTRICAL SPARK THEREFORE STARTING A FIRE, THIS PROBLEM HAS BEEN AN ONGOING ISSUE AND YET NOTHING IS DONE I THINK A RECALL SHOULD BE PLACED FOR THE ISSUE. BEFORE SOMEONE GETS KILLED. *TR

FUEL TANK FELL OFF VEHICLE AS A RESULT OF RUSTED MOUNTING IS A ONE OWNER WELL MAINTAINED FORD F150 PURCHASED NEW IN 2003 AND MILEAGE IS ONLY 100,222. NEW STRAPS WERE LOCATED AND INSTALLED 6/29/2010 AND OLD STRAPS WERE LABELED AND KEPT. *TR

PASSENGER WINDOW REGULATOR FAILURE ON 2003(2004 BODY STYLE) F150 LARIAT. REGULATOR FAILED ON ROAD TRIP IN 95 PLUS DEGREE WEATHER IN EASTERN NC ON JUNE 26, 2010. THIS IS THE SECOND ONE. *TR

I HAD MY 2003 FORD F-150 SHOOT SPARK PLUGS OUT OF THE HEADERS I DON"T KNOW WHY BUT THIS IDS THE 3RD TIME IT HAS HAPPENED AND IF IT WOULD BE POSSIBLE TO START A RECALL ON THE HEADERS TO CHANGE THEM TO A 8 THREAD INSTEAD OF 4. *TR

2003 FORD F-150 CREW CAB , 4.6 TRITON ENGINE. SPARK PLUG BLEW WHILE ON HIGHWAY. NORMAL DRIVING WITH NO LOAD IN TRUCK. NO WARNING BEFORE FAILURE. THE TRUCK HAS JUST OVER 100,000 MILES. *TR

I HAVE A 2003 FORD F150, WITH A 5.4L ENGINE. I FOUND OUT THAT MY WINDSHIELD IS LEAKING AND SEEPING WATER ONTO MY GEM/CJB AND MAKING IT SO IN RAIN MY WINDSHIELD WIPERS SHUT OFF, MY HEATER BLOWER TO STAY ON OR GO ON WHEN THE KEY IS NOT IN THE IGNITION, AND HAS DRAINED MY BATTERY. HERE IS A COPY OF THE NOTICE FORD SENT TO THERE DEALERSHIPS IN 2004, *FORD SPECIAL MESSAGE #15773 VARIOUS ELECTRICAL CONDITIONS RESULTING FROM WATER INTRUSION INTO THE GEM/CJB SOME 1997-2002 EXPEDITION AND 1998-2002 NAVIGATOR VEHICLES MAY EXHIBIT VARIOUS UNUSUAL ELECTRICAL CONDITIONS, INCLUDING BUT NOT LIMITED TO: FRONT OR REAR BLOWER OR EATC STAYING ON WITH KEY OUT OF THE IGNITION, RADIO STAYING ON AFTER DOORS OPENED AND KEY OUT OF IGNITION, WIPER CIRCUIT FAILURE CODES, AND MULTIPLE SYSTEM WARNING LIGHTS WITH 'SHORT TO POWER' OR 'LOW BATTERY VOLTAGE' DTCS. THESE SYMPTOMS MOST OFTEN OCCUR AFTER A RAIN OR SNOW. THIS MAY BE DUE TO GEM/CJB WATER INTRUSION RESULTING FROM A WINDSHIELD WATER LEAK. TO SERVICE, REMOVE THE GEM AND CJB FROM THE VEHICLE, SEPARATE THEM AND INSPECT FOR WATER CONTAMINATION OR CORROSION. IF FOUND IN EITHER COMPONENT, REPLACE BOTH COMPONENTS AND COMPLETELY RESEAL THE WINDSHIELD. EFFECTIVE DATE: 04/05/2002 SO THIS IS A KNOWN ISSUE AND THEY ARE CHARGING BETWEEN $900 - $1500+ FOR REPAIRS AND THEN ON TOP OF THAT CHARGING FOR THE WINDSHIELD TO BE REPLACED. THE HAZARDS OF THIS POTENTIALLY SHORTING OUT AND HAVING A FIRE IS A RISK THAT I THINK SHOULD BE ADDRESSED FOR THE SAFETY OF THE CONSUMERS. HAVING MY WINDSHIELD WIPERS STOP ON ME IN HEAVY RAIN ON THE HIGHWAY ALMOST CAUSED ME TO GET INTO A POTENTIAL ACCIDENT. *TR

MY SON WAS DRIVING HOME AND THE THROTTLE STUCK, THE BRAKES DID NOTHING. HE HAD TO THROW THE VEHICLE IN PARK. *TR

THE BRAKE LINE FROM CAB AREA TO REAR WHEEL ON MY 2003 FORD F150 CORRODED AND EMPTIED THE MASTER CYCLINDER OF BRAKE FLUID. IT IS SIGNIFICANT TO NOTE THAT NO OTHER BRAKELINES OR CONNECTIONS SHOWED SIMIILAR CORROSION- MORE LIKE YOU WOULD EXPECT ON A 7 YEAR OLD VEHICLE. IT IS MY OPINION THAT THE CORROSION IS A MATERIALS PROBLEM AND MAY BE A REOCCURRING PROBLEM IN OTHER VEHICLE OF THIS TYPE. I ALSO NOTED EXCESSIVE SCALING OF THE FRONT WHEEL HUBS AND STEARING ARMS OF THE SAME VEHICLE. THIS I BELIEVE IS THE RESULT OF INFERIOR PARTS- I HAVE NEVER SEEN THIS LEVEL OF DETERIOATION OF VEHICLE COMPONENTS LIKE THIS. WHETHER THIS IS A SAFETY PROBLEM OR NOT I DON'T KNOW. PLEASE ACCEPT THIS INFORMATION AS A COUPLE OF DATA POINTS ON THIS VEHICLE. I JUST FELT IT WAS NECESSARY TO ADVISE NHTSA OF THE SITUATION.