2003 FORD F-150 Complaints

NORMAL DRIVING WHEN THE SPARK PLUG BLEW OUT OF THE MOTOR LEAVING ME AND MY KIDS STRANDED STILL TRYING TO CORRECT PROBLEM THIS IS THE SECOND TIME REPAIR BILL APPROXIMATELY $3000. *DT

2003 FORD F150 KING RANCH 4X4 PICKUP ALL FOUR DOORS ARE ROTTING OUT ON THE BOTTOM. *DT 2/20/10 THE CONSUMER WAS INFORMED THE DRAIN HOLES OR WEEP HOLES WERE PLUGGED PROBABLY FROM RUST AND ROAD MATERIAL THUS TRAPPING WATER INSIDE THE DOORS CAUSING THEM TO RUST OUT. WHEN THE CONSUMER LOOKED AT THE WEEP HOLES, THEY WERE NOT CLOGGED UP, BUT PLUGGED WITH FACTORY INSTALLED PLUGS THE CONSUMER STATED THE PLUGS SHOULD HAVE BEEN REMOVED BEFORE THE SALE OF THE VEHICLE. . *JB UPDATED 04/06/10.*JB

I OWN A FORD F150 WITH A TRITON V8 ENGINE. ONE OF THE SPARK PLUGS BLEW OUT OF THE ENGINE ON 2/25/10 WHILE I WAS DRIVING ON A HIGHWAY. I HAD THE TRUCK TOWED TO A LOCAL REPAIR SHOP. AFTER LOOKING AT THE PROBLEM THEY SENT ME TO A FORD DEALER. THE DEALER HAS TOLD ME IT IS A $1000 FIX AND THAT IT WAS POSSIBLY DUE TO THE PERSON WHO REPLACED THE PLUGS FOR ME. *TR

TL*THE CONTACT OWNS A 2003 FORD F150. WHILE DRIVING APPROXIMATELY 30 MPH WHEN THE ROAD WAS SLIPPERY AND ATTEMPTING TO SHIFT INTO FOUR WHEEL DRIVE, IT FAILED TO ENGAGE. THE DEALER LOCATED THE FAILURE AND STATED THAT THE FRONT SHIFT FORK AND THE SUB SHIFT FORK NEEDED TO BE REPLACED. THE CONTACT WAS RESPONSIBLE FOR PAYING $ 1,009 TO HAVE THE FRONT AND SUB SHIFT FORKS REPLACED. HE CONTACTED THE MANUFACTURER; HOWEVER, THE MANUFACTURER DIDN"T TAKE A REPORT OR OFFER ANY ASSISTANCE WITH THE REPAIR. THE FAILURE MILEAGE WAS 66,879 AND THE CURRENT MILEAGE WAS 66,921.

2003 FORD F150 5.4L #3 SPARK PLUG BLEW OUT OF ENGINE'S HEAD AND STRIPPED OUT ALL THREADS. INSERT WAS PUT IN TO REPLACE DAMAGED THREADS AT A COST OF $500 FROM FORD DEALERSHIP. *TR

WHILE I WAS ACCELERATING AND ENTERING ONTO INTERSTATE 80 AT A SPEED OF 50MPH I HEARD A LOUD POP AND LOST POWER. THE ENGINE CONTINUED TO RUN BUT WITH A GREAT LOSS OF POWER. I CONTINUED TO DRIVE AT A MODERATE SPEED UNTIL I COULD GET TO A MONROE SERVICE CENTER APPROX. 20 MILES. THE #7 PLUG FOR THE SECOND TIME BLEW OUT OF THE HEAD. THE REPAIR COST THIS TIME WAS $294.38 AND THE ENGINE LIGHT IS STILL ON. IT'S BEEN EIGHT MONTHS SINCE I HAD IT REPAIRED THE FIRST TIME. THE #7 CYLINDER IS NOW MISFIRING EVEN THOUGH THE PLUG HAS BEEN REPLACED. MILEAGE TO DATE IS 200,892. *TR

I HAD BEEN DRIVING MY TRUCK FOR ABOUT TEN MINUTES AND AS I WAS DRIVING ON THE FREEWAY THE ENGINE SPARK PLUG BLEW. I GOT MY TRUCK TO START UP AND DROVE A SHORT DISTANCE BEFORE THIS OCCURRED AGAIN. THIS REPEATED UNTIL I MANAGED TO GET TO MY HOME WHICH WAS ABOUT TWO MILES AWAY WHEN THE PROBLEM FIRST OCCURRED. THEN I CALLED VENUS, A TOWING AND REPAIR SHOP, TO HAVE MY TRUCK TOWED FROM MY HOUSE TO THEIR SHOP. THE TOWING SERVICE COST $80.00. WHEN THE PROBLEM WAS DIAGNOSED THEY CALLED ME AND TOLD ME WHAT HAPPENED. THEY FIXED MY TRUCK AND CHARGED $250.00. *TR

ON APRIL 20, 2009, SPARK PLUG #7 BLOWOUT WHILE ACCELERATING FROM A TRAFFIC LIGHT. APPROX. SPEED 25 TO 35 MPH. ENGINE LOST COMPRESSION, DAMAGED THE IGNITION COIL, BUT I WAS ABLE TO MAKE IT TO A FIRESTONE REPAIR GARAGE WITHIN 10 MILES. THE SPARK PLUG #7 WAS REPLACED WITH THE HELI COIL AND THE IGNITION COIL DAMAGE WAS ALSO REPLACED. TOTAL COST OF LABOR AND PARTS WAS $352.81. *TR

WINDSHIELD LEAKS AND IS FRYING MY ELECTRICAL SYSTEM. 2003 F150. I HAVE READ NUMEROUS ARTICLES ON FORD NEEDING TO FIX THESE ISSUES. *TR

1. NORMAL OPERATION, NO INDICATION OF PROBLEM 2. SPARK PLUG BLEW OUT OF THE ENGINE AS MY WIFE PARKED THE VEHICLE IN OUR DRIVEWAY; 1ST OF 2 OCCURRENCES; REPAIRED WITH HELICOILED PLUG. APPROX $400 REPAIR EXPENSE. I'M NOW TOLD THAT A BULLETIN WAS ISSUED ADVISING NOT TO USE THIS REPAIR METHOD. HAVING TROUBLE VERIFYING IF THAT IS FACT OR FICTION. *TR