2003 FORD F-150 Complaints

The contact owns a 2003 Ford F-150. The contact stated that while the vehicle was parked and turned off for approximately an hour, they were suddenly informed that their vehicle had caught fire. When the contact arrived at the vehicle the fire department had already arrived and extinguished the fire. There was a police report was filed that stated that the fire was caused by wiring in the engine compartment. There were no injuries or medical assistance. There was damage to a nearby vehicle, fence, tree, and surrounding grounds. The vehicle had been towed and deemed totaled. The contact had later learned of NHTSA Campaign Number: 05V017000 (Vehicle Speed Control) however the vehicle had never been repaired for the recall. The manufacturer was not made aware of the failure. The approximate failure mileage was 250,000.

Ford placed a decal on the rear differential that wraps all the way around the axle. This decal holds water and has caused any area touching the decal to rust excessively. Ford has told me that this will cause they rear differential fail. When this happens it will likely be when I'm driving with my wife and two young kids. The only way to know that this issue exists is to either get under the truck and remove the decal which causes and also covers the damage, or to have the axle give out while driving. This was recently discovered while working on the vehicle. I don't currently have pictures as the vehicle is in for other repairs, but I can get pictures once I get the vehicle back.

On the day of Monday February 20 2023 I was in my front driveway preforming some maintenance on my 2003 Ford F-150 Xlt SuperCrew truck a gear shift cable and a heater core replacement. Once I finished the repairs I ran my truck for a few minutes then shut it off and was headed inside when I noticed a flickering light coming from the passenger side of the vehicle I walked to the truck and opened the door and I saw small flames dripping down coming from the ( glove box area ) I then grabbed the water hose and put it out . Once the small fire was out I proceeded to go in the house when I noticed black smoke coming ( from the engine bay from the vents in front of the windshield) the smoke got thicker as I sprayed it with water I then called to my spouse to call the local Fire Department. The vehicle was a total loss nothing was left interior wise no ( steering wheel,no console,no dashboard or anything.

On 11/27/2022 at or around 4:30 P.M. my 2003 Ford F-150 burned almost completely, without any mechanical failures or warnings, thirty full minutes after being parked and then after only having been run for three to four miles. The fire department ended up putting it out before it was fully consumed.

The contact owns a 2003 Ford F-150. The contact received notification of NHTSA Campaign Number: 11V385000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

FRONT DRIVER SEAT MOVES ON ITS OWN WHILE DRIVING WITH NO WARNING OR TOUCHING CONTROLS AND NO PROBLEM WITH FUSES ETC. WHEN TRYING TO USE CONTROLS THEY DO NOT ALWAYS WORK UNTIL YOUR DRIVING OR IN DRIVE WITH FOOT ON BRAKES.

TL* THE CONTACT'S BOYFRIEND OWNS A 2003 FORD F-150. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE IGNITION COILS AND ALL SPARK PLUGS WOULD BLOW OUT INSIDE OF THE ENGINE WHICH WOULD CAUSE THE VEHICLE TO STALL AS THE CHECK ENGINE LIGHT WOULD APPEAR ON THE DASHBOARD. THE CONTACT STATED THAT SHE HAS HAD THE IGNITION COILS AND SPARKS PLUGS REPLACED ON FOUR SEPARATE OCCASIONS ALL BY INDEPENDENT MECHANICS HOWEVER, THE FAILURE PERSISTED. THE CONTACT ALSO CALLED THREE SEPARATE DEALERS BUT WAS UNABLE TO REACH A SERVICE REPRESENTATIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. SHE WAS REFERRED TO NHTSA FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

FUEL TANK SEPARATED FROM VEHICLE WHILE DRIVING ON HIGHWAY, RESULTING IN FUEL SPILL.

ON NOVEMBER 01,2020 I WAS INVOLVED IN A VEHICLE ROLLOVER IN MY FORD F150 2003 WHICH THE AIRBAGS DID NOT DEPLOY. AIRBAG LIGHT WAS ON AND SEATBELT LOCKED I WAS ENTERTAINING INTERSECTION AND ALMOST THROUGH IT WHEN ANOTHER VEHICLE RAN THE STOP LIGHT CAUSING ME TO ROLLOVER ONE IN HALF TIMES. AIRBAG DID NOT DEPLOY AND SEAT ALMOST DETACHED FROM CAB.

TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT STATED THAT WHILE THE KEY WAS IN THE IGNITION SWITCH, THE VEHICLE FAILED TO SHIFT GEAR AS DESIGNED. THE CONTACT HAD TO SHIFT THE GEAR FROM PARK TO NEUTRAL AND BACK INTO PARK THEN NEUTRAL AGAIN FOR THE VEHICLE TO RESUME NORMAL OPERATION AND TURN ON. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,341.