2020 FORD F-150 Complaints

The rear differential exploded while driving without warning. immediate lose of power while traveling 70mph, the explosion blew some hot parts of the differential off the road and started a brush fire.

The contact owns a 2020 Ford F-150. The contact stated that while her husband was driving approximately 20 MPH, the check engine warning light illuminated. There was an abnormal burning odor coming from the vehicle. The driver drove to the residence. The vehicle was turned off and restarted and there was smoke coming from the engine with a loud screeching sound. The vehicle was taken to the local dealer, where it was determined that the cam sensor was defective and caused the engine to overheat. Additionally, the engine was low on oil. The contact stated that an oil change was previously performed. The vehicle was not repaired. The manufacturer was contacted, and a complaint was filed. The manufacturer confirmed that the VIN was not under recall and that there was no financial assistance available. The failure mileage was approximately 102,000.

Check engine light turn on with the code P0087. The truck don't turn on quickly. Lose power at high demand or RPM.

I was driving at normal highway speeds for probably around 45 minutes. When I tried to accelerate around a slower car, I lost all power to the gas pedal and then it slammed into 5th gear as I slowed down, I sped back up and it was sluggish and slow to accelerate and then violently shifted from 5th to 9th as if those were the only two gears I had. I was able to make it home, but it was a very dangerous situation.

The contact owns a 2020 Ford F-150. The contact stated that while operating the vehicle, rainwater leaked into the cabin of the vehicle from the sunroof assembly because the sunroof failed to properly close. The vehicle to taken to the local dealer who removed debris from the sunroof tracks. After retrieving the vehicle, the contact discovered that rainwater was still leaking into the vehicle from the sunroof. The vehicle was taken back to the local dealer who advised that the sunroof assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the vehicle was not covered under the Manufacturer's Extended Warranty coverage related to the failure. The failure mileage was 20,000.

The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the message “Pre-Collision Assist Not Available” was displayed and “Front Camera Malfunction - Service Required" was displayed. The vehicle was not diagnosed or repaired. The contact stated that the messages were continuously displayed. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

Catalytic converter has failed prior to 80,000 miles. Ford has done updates, via wifi, to the system, but it has not helped. Parts are now on back order due to the demand for replacing bank 2 (driver side) converters.

The contact owns a 2020 Ford F-150. The contact stated that on several occasions while driving at various speeds, the transmission shifted hard and shifted into neutral unintendedly. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The vehicle was repaired; however, the failure reoccurred two weeks later. The vehicle was taken to the same dealer where it was it was determined that the TCM needed a second software update. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 10,000.

Experience HARSH Engagement with transmission both upshift and downshift. Some downshifts at so HARSH, feels like rear wheels are trying to “lock up”. Ford dealer performed recall which did not correct the issues. Ford dealer recommended full transmission replacement. Seems this is a known issue and Ford has admitted fault by issuing a recall in an effort to “fix” the problems with the 10 speed transmission.

The contact owns a 2020 Ford F-150. The contact stated while driving at various speeds, there was a rattling sound coming from the front-end of the vehicle. Upon inspection, it was discovered that the front driver’s and passenger’s side shock absorber springs were cracked and fractured, causing damages to several suspension components on the vehicle. The vehicle was taken to the local dealer who informed the contact that the shock absorbers and springs needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 34,000.