2009 FORD F-150 Complaints

POWER STEERING HYDRAULIC HOSE LEAKING, CAUSING POWER STEERING PUMP TO WHINE & CAVITATE,& WILL EVENTUALLY RUIN THE POWER STEERING PUMP, DEALER SAYS THE HOSE IS ON NATIONAL BACK ORDER, 3700 CUSTOMERS ARE WAITING FOR THIS PART. DRIVE AT YOUR OWN RISK, WHEN THE PUMP FAILS YOU GO TO MANUAL STEERING INSTANTLY AND COULD LOSE CONTROL OF THE VEHICLE. *TR

WHILE MERGING ONTO THE INTERSTATE I ACCELERATED TO 65-70 MPH. ONCE ON THE INTERSTATE I LET OFF OF THE ACCELERATOR BUT THE TRUCK CONTINUTED ACCELERATION UP TO 90MPH WHILE HOLDING AT 4000 RPMS. BRAKES WERE APPLIED TO HELP CONTROL THE VEHICLE SPEED WHILE I SHIFTED TO NEUTRAL AND PULLED INTO THE EMERGNCY LANE. ONCE STOPPED AND IN PARK VEHICLE CONTINUED TO HOLD 4000 RPMS. I SHUT THE VEHICLE OFF THEN RESTARTED AND THE RPMS JUMPED TO 4000 IMMEDIATELY. I SHUT OFF AGAIN LEFT OFF FOR 15 MINUTES, PRESSED THE ACCELERATOR A FEW TIMES TO MAKE SURE IT WASN'T STICKING TO ANYTHING (IT WAS NOT) AND RESTARTED. AT THIS TIME THE VEHICLE APPEARED TO WORK NORMALLY, DROVE ON HOME. TOOK THE TRUCK TO THE DEALER THE FOLLOWING MONDAY, LEFT IT FOR THEM ON TUESDAY. THEY SAID THERE WERE NO CODES AND COULD NOT REPLICATE THE ISSUE AND THEREFORE NOTHING THEY COULD DO. THIS IS THE NINTH PROBLEM I HAVE HAD TO TAKE THE TRUCK IN TO HAVE FIXED UNDER THE WARRANTY. *TR

TRUCK PARKED IN GARAGE FROM SAT EVENING 4/21/2012 FROM SHORT 9 MILE TRIP. TRUCK STARTED AROUND 10:30 A.M. SUN 4/22/2012. REMOVED FROM GARAGE FOR 3 MINUTES THEN RETURNED TO GARAGE. SHUT OFF. LEFT RESIDENCE IN ANOTHER VEHICLE. RETURNED AROUND 7:30 P.M. OPENED THE GARAGE TO FIND A SMOKY HAZE COMING FROM IT. THE ENTIRE GARAGE WAS HOT. I NOTICED DRIPS OF SOME SUBSTANCE UNDER THE TRUCK AND ON THE RUNNING BOARDS. I IMMEDIATELY REALIZED IT WAS THE UNDERCOATING THAT WAS WARM ENOUGH TO MELT AND DRIP. I GOT INTO THE TRUCK TO START IT UP BUT THE BATTERY WAS DEAD. IT WAS WARM ENOUGH IN THE CAB OF THE TRUCK TO LIQUEFY TOOTSY ROLLS THAT WERE IN THERE. I COULD NOT GET THE TRUCK IN NEUTRAL TO PUSH IT OUT OF THE GARAGE. AFTER A SHORT PERIOD WITH THE GARAGE DOORS OPEN AND EVERYTHING SEEMING TO COOL DOWN. I USED A BATTERY CHARGER TO TRY START THE TRUCK. IT WOULD JUST CLICK AND NOT ROLL OVER. WITH THE CHARGER THERE WAS ENOUGH POWER TO PUT IT IN NEUTRAL AND PUSH THE TRUCK OUT OF THE GARAGE. THERE WE USED A COMMERCIAL BATTERY STARTER AND THE TRUCK STARTED UP. THERE WAS A CHECK ENGINE LIGHT ON ALL THE TIME BUT IT SEEMED TO RUN FINE. ALL GAUGES READ WHERE THEY WERE SUPPOSED TO. THE WATER TEMPERATURE GAUGE WAS IMMEDIATELY AT THE WARMED UP LINE UPON STARTING. LEFT IT OUTSIDE OVERNIGHT. FOLLOWING MORNING DROVE IT 10 MILES TO LOCAL FORD DEALERSHIP. THEY TESTED EVERYTHING AND COULD NOT FIND ANYTHING WRONG WITH IT. THE DEALERSHIP CALLED THEIR HOTLINE AND THEY HAD NEVER HEARD OF ANYTHING LIKE THAT HAPPENING BEFORE.. THERE WAS NOTHING ELSE IN THE GARAGE THAT WAS AFFECTED. *TR

POWER STEERING HOSE LEAKING FLUID. MECHANIC TRIED ORDERING REPLACEMENT AND WAS TOLD BY FORD THERE IS A NATIONAL BACK-ORDER OF 4500 UNITS. *JS

TL* THE CONTACT OWNS A 2009 FORD F-150. WHILE PARKED, THE CONTACT NOTICED WATER LEAKING IN THE MIDDLE OF THE REAR SEAT. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THE TECHNICIAN STATED THAT THE GASKET IN THE TAIL LIGHT WAS LOOSE, CAUSING WATER TO ENTER THE VEHICLE. THE CARPET AND THE MIDDLE ARM REST IN THE REAR OF THE VEHICLE CONTAINED MILDEW. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.

TL* THE CONTACT OWNS A 2009 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT ATTEMPTED TO SHIFT INTO PARK BUT THE SHIFTER WOULD NOT HOLD IN PARK. THE VEHICLE WAS LATER TOWED TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT SHE NEEDED A NEW TRANSMISSION. THE VEHICLE WAS REPAIRED FOR THE TRANSMISSION. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 71,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2009 FORD F-150. THE CONTACT STATED THAT THE HIGH PRESSURE HOSE FOR THE POWER STEERING HAD A BAD FITTING ON HIS VEHICLE. THE DEALER WAS NOTIFIED AND STATED THAT THE PART WAS ON BACK ORDER. THE VEHICLE HAD NOT YET EXPERIENCED A FAILURE, BUT THE CONTACT WAS VERY CONCERNED ABOUT THE SAFETY OF THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 85,000. THE VIN WAS NOT AVAILABLE.

WHEN I WENT TO APPLY BRAKES, PEDAL FELT AWKWARD AND HARD, AS IF NO POWER ASSIST. I WAS CAUGHT BY SURPRISE AND HAD TO SLAM ON BRAKES WITH EXCESSIVE FORCE. I HIT A WALL AT SLOW SPEED AND DAMAGED MY FRONT BUMPER. THIS ISSUE HAS HAPPENED SEVERAL TIMES OF NO POWER ASSIST IN MORNINGS WHEN FIRST STARTED. FORD HAS BEEN UNABLE TO REPLICATE IT. I AM TAKING TO FORD TODAY AFTER HAVING A COLLISION. I AM SCARED TO DRIVE IT. *TR

DURING AN INSPECTION THE POWER STEERING HOSE WAS FOUND TO BE LEAKING. ADVISED BY SERVICE AGENT TO TAKE TO DEALER AS A WARRANTY ISSUE. TOOK IT TO THE DEALER, THEY SAID NEW POWER STEERING HOSE IS REQUIRED AND SENT ON MY WAY AFTER BEING TOLD HOSE IS ORDERED. MORE THAN A WEEK LATER I FIND OUT, AFTER SEARCHING ONLINE THAT PEOPLE HAVE BEEN WAITING 10 WEEKS FOR THE SAME REPLACEMENT PART FROM FORD, THE ONLY SUPPLIER OF THIS PARTICULAR HOSE! I CONTACTED FORD BECAUSE THE DEALERSHIP DOES NOT RESPOND TO PHONE CALLS AND WAS TOLD THAT THE DEALER SAYS THAT IT IS SAFE TO DRIVE. WELL I FEEL THAT ANY LEAKING POWER STEERING HOSE IS A SAFETY ISSUE. THE RESPONSE FROM FORD WAS TO PURCHASE A LARGE CONTAINER OF POWER STEERING FLUID AND CONTINUALLY TOP UP THE FLUID. THEY SAID THIS ADVICE WAS FROM THE DEALER. THIS ISSUE NEEDS TO BE REPORTED SIMPLY BECAUSE THE MORE YOU DRIVE THE HIGHER THE RISK OF A CATASTROPHIC FAILURE OF THE STEERING AND THE RISK OF DEATH OR INJURY TO THE DRIVER AND OCCUPANTS. IT ALSO NEEDS TO BE HIGHLIGHTED THE BLASE ATTITUDE OF FORD AND THEIR DEALERS TO THIS MATTER. IT WAS CERTAINLY OF BIG ENOUGH CONCERN INITIALLY FOR THE DEALERSHIP TO TRY AND FIND A RENTAL VEHICLE THAT THEY WOULD PAY FOR IN LIEU OF LOSS OF TRANSPORT AS WAS CONCERNED THAT THE VEHICLE WAS NOT SAFE TO DRIVE FOR LONG DISTANCES. *TR

TRUCK PURCHASED 3-30-2011. 9-2011 NEEDED TO HAVE BATTERY JUMPED. CLEANED BATTERY POSTS. SEEMED FINE. 12-19-2011 BATTERY WENT DEAD. AAA REPLACED BATTERY. 01-31-2012 BATTERY WENT DEAD AGAIN. AAA CAME AND SAID THE BATTERY WAS FINE. HAD IT JUMPED AND TOOK IT TO HOLMAN IN MAPLE SHADE, NJ. THEY KEPT THE TRUCK FOR FIVE DAYS AND COULD NOT FIND ANYTHING WRONG WITH IT. WHEN AAA CAME THEY SAID IT SEEMED AS IF SOMETHING WAS PULLING FROM THE BATTERY HOLMAN SAID IF IT HAPPENS AGAIN NOT TO HAVE IT JUMPED JUST HAVE IT TOWED. SEEMS IT MAY BE ELECTRICAL. NOT REALLY SURE.