2003 FORD F-150 Complaints

I WAS AT A COMPLETE STOP IN A CONSTRUCTION ZONE, WHEN MY BRAKE PEDAL WENT COMPLETELY TO THE FLOOR (GAVE OUT) THIS CAUSING ME NOT TO BE ABLE TO FIGURE OUT WHAT HAPPENED FAST ENOUGH BEFORE I ENDED UP REARENDING THE CAR IN FRONT OF ME AND THAT WAS PUSHED INTO ANOTHER CAR. THE VEHICLE WAS TOWED, STILL UNDER WARRANTY NEW MASTER BRAKE CYLINDER WAS INSTALLED. *CN

STEERING GEAR FAILURE. THE VEHICLE HAD A LARGE AMOUNT OF PLAY IN THE STEERING WHEEL. AT TIMES LOSS OF STEERING WOULD OCCUR AND YOU COULD END UP IN THE NEXT LANE. *TR

TL*THE CONTACT OWNS A 2003 FORD F-150. WHILE DRIVING 50 MPH IN SNOWY CONDITIONS, THE ELECTRONIC 4-WHEEL DRIVE DISENGAGED AND SHIFTED INTO 2-WHEEL DRIVE WITHOUT WARNING. AS A RESULT, THE REAR END OF THE VEHICLE FISHTAILED. THE INSTRUMENT PANEL INDICATED THAT THE 4-WHEEL DRIVE WAS ACTIVATED. THE DEALER STATED THAT THEY WOULD INSTALL A NEW SHIFT FORK KIT MADE WITH DIFFERENT MATERIAL. AS OF DECEMBER 13, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 53,000.

WHEN DRIVING STEERING WHEEL WAS VERY LOOSE. STEERING GEAR WAS SEPARATING AND WAS REPLACED AT THE DEALER. TRYING TO FIND OUT WHY MY VEHICLE WAS NOT COVERED UNDER RECALL NHTSA CAMPAIGN #03V349000. *TR

TL*THE CONTACT OWNS A 2003 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT CRASHED INTO THE FRONT PASSENGER SIDE OF ANOTHER VEHICLE. THE VEHICLE WAS COMPLETELY DESTROYED AND NONE OF THE AIR BAGS DEPLOYED. TWO PEOPLE WERE INJURED AND A POLICE REPORT WAS FILED. PRIOR TO THE CRASH, HE NEVER NOTICED ANY AIR BAG WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. A COMPLAINT WAS FILED WITH THE MANUFACTURER AND THE CONTACT IS ALSO FILING A LAWSUIT AGAINST FORD. HE IS NO LONGER IN POSSESSION OF THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 90,000. UPDATED 03-05-08 *BF

TL*THE CONTACT OWNS A 2003 FORD F150. THE CONTACT STATED THAT THE REAR RIGHT PASSENGER SIDE SEAT BELT BUCKLE HAS FAILED. THE DEALER WOULD NOT REPAIR THE DEFECT UNDER WARRANTY OR WITHOUT A CHARGE OF $150. THE MANUFACTURER STATED THAT THE FAILURE WAS NOT RECORDED AND THEY WOULD NOT BE ABLE TO ASSIST. THE CURRENT MILEAGE WAS 95,000 AND FAILURE MILEAGE WAS APPROXIMATELY 15,000. UPDATED 01-14-08. *KB UPDATED 12/12/07.*JB

RECENTLY, THE HEADLIGHTS, FOG LIGHTS, DASH LIGHTS, AUTO LIGHT FUNCTIONS, DOOR LOCKS, EXC., ALL BEGAN PERFORM ERRATICALLY; INCLUDING THE DASH LIGHTS GOING OUT WHILE DRIVING AT NIGHT! THE NEXT DAY I WENT GREAT LAKES FORD IN LUDINGTON, MI. AS SOON AS I MENTIONED ONE OF THE SYMPTOMS, THE TECH IMMEDIATELY KNEW THE PROBLEM: HE TOLD ME THAT THE OEM ADHESIVE ON THE WINDSHIELD HAD FAILED CAUSING WATER TO LEAK DOWN BEHIND THE DASH AND DIRECTLY ONTO THE GEM MODULE AND FUSE PANEL. HE SAID HE HAS SEEN THIS PROBLEM OVER AND OVER WITH THIS YEAR F150 AND HAD PROBABLY FIXED MORE THAN 100 OVER THE LAST YEAR OR TWO. THE LOCAL WINDSHIELD SHOP, DUNESIDE AUTO GLASS; THE OWNER TOLD ME THAT THEY HAVE DONE MORE THAN 25 WINDSHIELDS THIS YEAR AT GREAT LAKES FORD FOR THIS EXACT SAME PROBLEM. I CHECK THE FORD WEBSITES AND ALSO FOUND THAT THERE IS A TSB LISTED FOR THIS PROBLEM. THE COST OF THE REPAIR WAS $1200 WHICH INCLUDED $500 IN PARTS FOR THE BOX ASY, MODULE AND NEW LIGHT SWITCH,$351 IN LABOR AND $325 FOR A NEW WINDSHIELD PLUS TAXES. HOW CAN THERE NOT BE A RECALL FOR THIS? IF THE PROBLEM IS THAT PREVALENT AT A NORTHWESTERN MICHIGAN FORD DEALER, IT HAS TO BE EVERYWHERE ELSE IN THE COUNTRY. *TR

I RECEIVED A NOTICE IN THE MAIL THAT MY VEHICLE HAS A RECALL ON PART OF THE CRUISE CONTROL MECHANISM. THIS CAN CAUSE AN UNDER THE HOOD FIRE AND NEEDS A REPLACEMENT PART/FUSE INSTALLED. THE PART WILL NOT BE IN UNTIL MARCH 2008! *TR

SPARK PLUG BLEW OUT OF THE ENGINE, STRIPPING ALL THE THREADS IN THE CYLINDER HEAD. *TR

TL*THE CONTACT OWNS A 2003 FORD F150. THE INTERIOR TURN SIGNAL SWITCH AND THE EXTERIOR TURN SIGNALS FAILED INTERMITTENTLY. THE DEALER STATED THAT THERE WAS A SHORTAGE IN THE WIRES. UPDATED 11/14/07