2009 FORD F-150 Complaints

WATER HAS BEEN FOUND BUILDING UP UNDER THE PLASTIC KICKPLATE IN THE RIGHT REAR PASSENGER DOOR OF MY 2009 F150 SUPERCREW MODEL. I HAVE TAKEN IT TWICE TO THE DEALER AND BOTH TIMES THEY HAVE ORDERED A NEW THIRD BRAKE LIGHT AS CONDENSATION WAS FORMING. THEY STATED THE SEAL WASN'T STRONG ENOUGH AND WASN'T SEALING PROPERLY. ALSO SAID THIS IS COMMON WITH F150S. THEY SAID THEY HAVE REPLACED THIS NUMEROUS TIMES ON DIFFERENT F150S, AND SOONER OR LATER FORD WOULD ISSUE A RECALL. DID NOT NOTICE THE PROBLEM UNTIL I STARTED SMELLING MOLD AND MILDEW AND LIFTED THE KICKPLATE TO NOTICE THE CARPET WAS SOAKED AND WATER FORMING IN THE WELL. *TR

VEHICLE CAUGHT FIRE WHILE PARKED. WIRES LEADING INTO THE FUEL TANK SHORTED CAUGHT BED ON FIRE, BUT WAS EXTINGUISHED IN TIME TO STOP FURTHER DAMAGE. *TR

NO INCIDENT, AN INQUIRY: HEADREST ON FORD 2009 F150 SUPERCAB TRUCK IS ANGLED 54 DEGREES FORWARD RELATIVE TO THE SEAT BACK. DRIVING WITH BACK AGAINST SEAT, HEAD IS PUSHED FORWARD AND DOWN LIMITING HEAD MOBILITY AND VISION. WITH HEAD ON REST AND BACK FORWARD OF THE SEAT, CONCERN IS THAT AIRBAG DEPLOYMENT WOULD RESULT IN A SEVERE SNAP OF THE HEAD FORWARD AND DOWN AS BACK IS PUSHED TO THE SEAT - IS THIS A VALID CONCERN? *TR

TL* THE CONTACT OWNS A 2009 FORD F-150. WHILE DRIVING AT SPEEDS OF 65 MPH, THE AIR BAG SERVICE LIGHT ILLUMINATED ON THE DASHBOARD. THE FAILURE WAS IGNORED BUT THE VEHICLE WAS EVENTUALLY TAKEN TO AN AUTHORIZED FORD DEALER. THE CONTACT WAS INFORMED THAT THERE WERE NO FAILURE CODES OBTAINED FROM A DIAGNOSTIC TEST. THE CONTACT STATED THE FAILURE WOULD RECUR INTERMITTENTLY WHENEVER THE PASSENGER SEAT WAS OCCUPIED. THE FAILURE MILEAGE WAS 200 AND THE CURRENT MILEAGE WAS 11,600.

TL* THE CONTACT OWNS A 2009 FORD F-150. WHILE READING THE OWNERS MANUAL, THE CONTACT REALIZED THAT THE VEHICLES ELECTRONIC TRAILER SWAY CONTROL SYSTEM WAS DISABLED. THE SYSTEM WAS ENABLED WHEN THE VEHICLE WAS TURNED ON BUT WHEN IT WAS TURNED OFF, THE SYSTEM DISABLED AND COULD POTENTIALLY CAUSE A CRASH ACCORDING TO THE OWNERS MANUAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THERE WAS NO FIX FOR THE PROBLEM. THE FAILURE CONTINUED TO OCCUR. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 3,000. THE CURRENT MILEAGE WAS APPROXIMATELY 13,500 UPDATED 11/19/10 *CN UPDATED 11/23/10

2009 FORD F-150, 4.6L SUPER CREW. PULLED INTO DRIVEWAY AND STOPPED TO ALLOW PASSENGERS TO DISEMBARK JUST OUTSIDE OF OPENED GARAGE DOOR. ONCE PASSENGERS ENTERED HOUSE THROUGH DOOR AT FRONT OF GARAGE, I REMOVED MY FOOT FROM THE BRAKE AND PRESSED ON ACCELERATOR TO PULL IN. VEHICLE SUDDENLY SURGED FORWARD AND ENGINE BEGAN TO REV VERY HIGH. IMMEDIATELY PULLED FOOT OFF ACCELERATOR PEDAL AND PRESSED HARD ON BRAKES. VEHICLE CONTINUED TO SURGE FORWARD AND INCREASE RPMS. UNABLE TO STOP, VEHICLE SLAMMED INTO FRONT OF GARAGE WALL. AIRBAGS DID NOT DEPLOY, ENGINE ONLY STOPPED HIGH REVS AND SLOWLY RETURNED TO IDLE SHORTLY AFTER IMPACT. *TR

TL* THE CONTACT OWNS A 2009 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH. WHEN PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL THERE WAS NO POWER RESPONSE. THE GEAR WAS SHIFTED INTO NEUTRAL CAUSING THE ENGINE TO REVV HIGH. THE CONTACT WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD AND TURNED THE ENGINE OFF. THE VEHICLE RESTARTED TO NORMAL OPERATION. THE FAILURE OCCURRED ON FIVE SEPARATE OCCASIONS WHILE TRAVELING AT ANY SPEED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 5,100. THE CURRENT MILEAGE WAS 5,200. UPDATED 11/16/10. *LJ

WHILE DRIVING DOWN THE ROAD, MY RIGHT REAR WINDOW JUST DROPPED. THE WINDOW DID NOT BRAKE, THE WINDOW JUST DROPPED INTO THE DOOR. I WAS ABLE TO TAKE THE MOLDING OFF AND TAPE THE WINDOW UP. THIS IS THE SECOND TIME THIS HAS OCCURRED SINCE OWNING THE VEHICLE. THE FIRST TIME IT WAS THE DRIVER'S WINDOW. I HAVE NOT FIXED THE PROBLEM YET, BUT HAVE DONE SOME RESEARCH AND FOUND OUT IT IS ACTUALLY THE REGULATOR THAT WENT BAD. *TR

FROM A MOVING LEFT TURN, THE ENGINE CUT OUT/SHUTOFF. NO SPUTTER, NO WARNING SIGNALS. THIS IS THE ONLY OCCURRENCE AT THIS TIME. DEALERSHIP CONTACTED. *TR

ON JANUARY 2, 2010, IN AUSTIN, TEXAS, I WAS ACCELERATING IN A 2009 FORD F-150 SUPERCREW TO ENTER A RESTRICTED ACCESS HIGHWAY AND THE ACCELERATOR PEDAL BECAME LODGED ON AN AFTERMARKET WEATHERTECH BRAND FLOOR MAT AT FAIRLY CLOSE TO FULL THROTTLE. FORTUNATELY, THERE WAS NO ONE IN MY LANE DIRECTLY IN FRONT OF ME. I WAS ABLE TO SWITCH THE VEHICLE OFF, SHIFT TO NEUTRAL AND HOLD MY LANE POSITION AS I BROUGHT THE TRUCK TO A STOP. I DISLODGED THE ACCELERATOR FROM THE MAT AND THEN REMOVED THE MAT. AT THAT POINT, I RESTARTED THE VEHICLE AND WAS ABLE TO CONTINUE MY TRIP. I PURCHASED THE MATS DIRECTLY FROM WEATHERTECH ON DEC 27,2008. SHORTLY AFTER I RECEIVED THE MATS, WEATHERTECH THEN SENT ME REPLACEMENT MATS FOR THE DRIVER AND FRONT PASSENGER. THERE WAS NO EXPLANATION FOR THE REPLACEMENT MATS. CURIOUS AS TO THE REASON AND CONCERNED THAT I WAS BEING CHARGED AGAIN FOR MATS, MY WIFE CALLED WEATHERTECH'S SERVICE LINE. SHE WAS TOLD THAT WEATHERTECH WAS NOT "SATISFIED WITH THE FIT" OF THE FIRST SET OF MATS THAT WE RECEIVED. THERE WAS CERTAINLY NO INDICATION THAT THERE WAS ANY SAFETY ISSUE WITH THE ORIGINAL MATS. I COMPARED THE NEW MATS TO THE ORIGINAL ONES AND COULD SEE NO SUBSTANTIAL DIFFERENCE, SO I DID NOT REPLACE THEM, AND SIMPLY PUT THE NEW MATS IN MY GARAGE, UNUSED. AFTER THE JAN 2, 2010 EVENT, I REALIZED THAT THERE WAS INDEED A CHANGE. A CHANGE THAT I NOW KNOW TO BE VERY SIGNIFICANT. THE REPLACEMENT MAT HAS A ?CUT OUT? FOR THE ACCELERATOR PEDAL TO PREVENT THE LOWER END OF THE PEDAL FROM HANGING UP ON THE MAT. OBVIOUSLY, I HAVE NOW SWITCHED OUT THE OLD MAT FOR THE NEW ONE. I CERTAINLY APPLAUD THE REDESIGN. MY CONCERN IS THAT I RECEIVED NO WARNING OR INDICATION FROM WEATHERTECH THAT REPLACING THE DRIVER?S MAT WAS AN URGENT SAFETY MATTER THAT COULD RESULT IN DEATH OR INJURY IF NOT PERFORMED PROMPTLY. I NOTIFIED WEATHERTECH OF MY CONCERN IN JANUARY 2010 AND HAVE RECEIVED NO RESPONSE. *TR