1994 FORD F-150 Complaints

ON MONDAY I NOTICED A STRONG GASOLINE SMELL COMING FROM THE REAR TANK (DUAL TANK SYSTEM) OF MY TRUCK. TUESDAY AFTER SWITCHING GAS USE FROM THE FRONT TO REAR WHEN I STOPPED AT A LOCAL STORE, GAS WAS DRIBBLING AT A HIGH RATE OF SPEED OUT OF THE GAS CAP AREA FROM MY REAR TANK. BY THE TIME I GOT HOME PRESSURE CAUSED THE GAS TO PRACTICALLY EXPLODE OUT OF THE GAS CAP BY THE GALLONS. THE FIRE DEPARTMENT HAD TO BE CALLED TO ENSURE THAT MOVING THE TRUCK DID NOT START A FIRE AND TO CLEAN THE SPILL. AFTER RESEARCHING THE ISSUE, IT APPEARS THAT THERE WAS A RECALL THROUGH FORD FOR EARLIER DUAL TANK MODELS FOR THE SAME ISSUE (NHTSA CAMPAIGN ID NUMBER :93V125000). MANY OTHER 1994 F-150 OWNERS ARE HAVING THIS SAME ISSUE BUT A RECALL HAS NOT YET BEEN ISSUED (EXAMPLE: NHTSA COMPLAINT # 10533605). I ASSURE YOU THAT THIS WAS INDEED A HUGE FIRE HAZARD! ACCORDING TO YOUR FILES, IN 1993, FORD IS WELL AWARE OF THIS ISSUE THROUGH RECALL 93V-125. WHY HAVEN'T OTHER OWNERS WITH DUAL TANKS BEEN NOTIFIED? IN ADDITION, WHY HASN'T THERE BEEN ANOTHER RECALL FOR LATER FORD MODELS? *TR

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED HIS VEHICLE HAD DUEL FUEL TANKS AND WHILE IT WAS PARKED HE NOTICED FUEL LEAKING. THE CONTACT STATED WHEN THE BOTH FUEL TANKS WERE FULL THE FRONT TANK WOULD PUMP FUEL INTO THE BACK TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,000. THE CURRENT APPROXIMATE MILEAGE IS 163,000. UPDATED 9/17/13*CN THE CONSUMER STATED WHEN BOTH TANKS WERE OVER HALF FULL, WHILE DRIVING, THE FRONT TANK WOULD RUN THE TRUCK AND AT THE SAME TIME, PUMP EXTRA FUEL INTO THE REAR TANK, CAUSING GAS TO OVER FLOW FROM THE GAS GAP, AND ONTO THE GROUND. UPDATED. 11/6/13

WHILE DRIVING MY SEAT RECLINER BOLTS BROKE FROM THE SEAT FRAME CAUSING THE SEAT TO RECLINE ALL THE WAY TO THE BACK SEAT IN MY EXTENDED CAB. I WAS ABLE TO NOT LOSE CONTROL OF MY TRUCK THANKFULLY HOWEVER I HAVE IT TEMPORARILY FIXED WITH A BOLT STUCK THROUGH IT TO KEEP IT FROM RECLINING. UPON CALLING FORD THEY TOLD ME THAT EVEN THOUGH I FOUND A RECALL FOR THIS ISSUE; IT HOWEVER DID NOT AFFECT MY VIN #. I BELIEVE THIS IS A SAFETY ISSUE AND SHOULD BE ADDRESSED. UPON SPEAKING WITH FORD DIRECTLY FOR REPLACEMENT PARTS TO FIX IT, I WAS TOLD THE PARTS/BOLTS ONLY COME IN A BIG QUANTITY PACK AND WOULD BE ALMOST $200 BUT I WOULD ONLY NEED ONE OR TWO BOLTS TO FIX IT. THIS IS RIDICULOUS AND SHOULD BE HANDLED BY THE DEALER FREE OF CHARGE AND INCLUDED AS A RECALL DUE TO THE SAFETY HAZARD THIS COULD HAVE POSED TO MYSELF AND OTHER CITIZENS DRIVING! *TR

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT REPLACED THE COIL PACK AND THE VEHICLE RESUMED NORMAL OPERATION TEMPORARILY. THE FAILURE RECURRED TWO MONTHS LATER. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 200,000 AND THE CURRENT MILEAGE WAS 226,000.

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CONTACTED AND NO INJURIES WERE REPORTED. THE FIRE DEPARTMENT ADVISED THE CONTACT THAT THE FLAMES BEGAN NEAR THE FIRE WALL. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT FUEL SPILLED OUT FROM THE FILLER NECK WHILE REFUELING. THE CONTACT ALSO STATED THAT THE VEHICLE WAS EQUIPPED WITH DUEL FUEL TANKS AND FUEL OVERFLOWING FROM THE REAR FUEL TANK INTO THE FRONT FUEL TANK WAS THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

THE STRAPS HOLDING THE FRONT FUEL TANK ONTO MY 1994 FORD F150 ARE CORRODING AWAY, CAUSING A SMALL GAS LEAK AND AN UNSTABLE TANK. THERE IS A CURRENT RECALL FOR THIS SAME PROBLEM ON THE FORD 1997-2004 F150 PICK-UP TRUCKS, BUT IT DOES NOT EXTEND BEYOND THOSE YEARS THOUGH IT SHOULD. *TR

VEHICLE CAUGHT ON FIRE AFTER TURNING THE IGNITION OFF. I WAS IN HARRYS ARMY AND NAVY STORE, 691 ROUTE 130 ROBBINSVILLE, NJ 08691 (609) 585-5450, WHEN I HEARD OVER THE INTERCOM THAT THERE WAS A GREEN F150 ON FIRE IN THE PARKING LOT. I IMMEDIATELY WENT OUTSIDE AND SOMEONE FROM THE PLAZA WAS TRYING TO PUT OUT. SHORTLY THEREAFTER THE FIRE DEPARTMENT SHOWED UP ALONG WITH THE POLICE AND EXTENGUISHED THE MOTOR UNDER THE HOOD COMPLETELY. I HAD THE TRUCK TOWED TO PINE HILL, NJ WHICH COST 200.00 ON TOP OF LOSING MY TRUCK WITH IS MY FINANCIAL STABILITY DUE TO BEING A SELF CONTRACTOR. ALL OF THE HOSED, BELTS AND WIRING IS MELTED, HOWEVER, THE FIRE WAS CONTAINED TO UNDER THE HOOD. I IMMEDIATELY HAD TO PURCHASE ANOTHER VEHICILE DUE TO THE HEAVY DAMAGE AND MY LIVELY HOOD. SOMEONE ADVISED ME THAT THERE ARE RECALLS REGARDING THE WIRING IN THE TRUCK WHICH CAUSES FIRE DAMAGE UNDER THE HOOD. THE FOLLOWING ARE RECALLS IN REGARDS TO THIS MATTER: 05S28, EA5005, 05V017, 06V206, 05V388, 06V286. *TR

TL* THE CONTACT OWNS A 1994 FORD F-150 WITH TBC VANDERBILT TURBO TECH GT TIRES, SIZE 265/70R15. THE CONTACT STATED THAT THREE OF THE FOUR TIRES FAILED WITHIN 70 MILES. THE CONTACT STATED THAT THE BEADING FAILED AROUND THE SIDEWALL. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS TOLD THAT THE FAILURE WAS CAUSED WHEN THE TIRES WERE INSTALLED ON THE VEHICLE. THE FAILURE MILEAGE WAS 158,000 UPDATED 10/18/11*LJ UPDATED 11/04/11

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE FUEL FILLER OVERFLOWED BECAUSE ONE OF THE DUAL FUEL TANKS WAS SENDING TOO MUCH FUEL TO THE OTHER TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE MECHANIC WAS UNABLE TO ORDER THE PROPER PARTS NEEDED FOR REPAIR. THE VEHICLE WAS EQUIPPED WITH THE FUEL TANK FOR THE 1993 MODEL YEAR EVEN THOUGH THE VEHICLE WAS A 1994 MODEL. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 108,000.