2021 FORD F-150 Complaints

At a stop light vehicle will turn off and nothing electrical will work. It will have to be restarted, While turning at low speeds the electronic steering completely stops working and almost hit another car. All electrical power failure until modules reset then will start. This all happens randomly so it could happen at any point and cause serious injury. Ford can't seem to find a repair for the intermittent issue.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Both daytime running lights are defective. One is all the way out and the other one is partially out. This started early 2024. I'm concerned over visibility.

The contact owns a 2021 Ford F-150. The contact stated while driving at various speeds, the vehicle made an abnormal clunking sound. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. The contact stated that the failure progressively worsened. The contact stated that the vehicle made an abnormal grinding sound and jolted erratically while driving, and upon coming to a stop. The dealer diagnosed that the transmission had failed and needed to be replaced. The dealer replaced the transmission; however, the failure recurred. The vehicle was taken back to the dealer, where it was diagnosed that the transmission, the catalytic converter, and other unknown parts had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 150.

Vehicle: 2021 Ford F-150 Component: Exterior Lighting – Daytime Running Lights (DRLs) / Headlights (High Beams) Safety Concern: Vehicle visibility and forward illumination Both daytime running lights (DRLs) on my 2021 Ford F-150 have failed completely. After the DRLs stopped working, the high beams also became inoperative, leaving only the low beams working. The Ford dealer attempted a repair by replacing the control modules, but that did not fix the issue. They advised that the entire headlight assemblies need to be replaced. However, these assemblies are very expensive, so I have not replaced them yet. I am currently limited to using only the low beams. Without DRLs, the truck is less visible during daytime driving, increasing the risk of a collision. Without high beams, nighttime visibility is reduced, especially on rural or dark roads. This failure affects federally required lighting functions, compromising safety in both day and night driving. The problem is not normal wear: these are sealed LED assemblies that should last the life of the vehicle. The fact that both assemblies failed strongly indicates a manufacturing or design defect. Owners face high out-of-pocket costs because the only fix offered is full assembly replacement. Other 2021 F-150 owners have reported similar failures of DRLs and headlights online, showing this is not an isolated incident. I request that NHTSA investigate this issue as a safety defect and require Ford to issue a recall to replace the defective headlight assemblies at no cost to owners.

Low pressure fuel pump failure Yes check engine light is on. Manufacture says there isn't a fix available yet and they have no idea when it will be available. My truck is missing and loosing fuel pressure. This is a 2021 truck and its now 2025. This needs to be fixed or another vehicle if they can't fix , but they have offered no solution.

My Ford truck was part of Recall 22S26 / NHTSA Recall 22V250, which required the replacement of faulty windshield wiper arms. On 12/12/2023, I took my vehicle to Karl Flammer Ford for the recall service. The receipt I was given states that both wiper arms were replaced as part of the recall. In 2025, I noticed the driver-side wiper arm was loose and could potentially detach while in use. Upon closer inspection, I found the stamped date code on the wiper arm showed “2021,” the year of my truck. This indicates the part is one of the original faulty components included in the recall and was never replaced, despite the dealer’s claim that it was. A failing wiper arm poses a significant safety hazard because loss of windshield visibility during rain could easily result in a crash. I presented this evidence to Karl Flammer Ford, but they continue to insist the wiper arms were replaced. Ford Motor Company has been unresponsive and unhelpful, repeatedly transferring me between departments and promising call-backs that never come. No progress has been made toward fixing the issue. At this time, the vehicle remains equipped with the recalled part, which is available for inspection upon request. The vehicle has only been reviewed by the dealer; Ford has not conducted any proper inspection or resolution. No police or insurance inspection has taken place. There were no warning lamps or dashboard messages prior to this discovery. The only symptom was the driver-side wiper arm becoming loose, which I observed in 2025. Given Ford’s failure to properly address this recall and the ongoing safety risk, I am requesting that NHTSA investigate this matter and ensure Ford fulfills its obligation to replace the defective parts.

Gear shift selector gets stuck in park, drive & reverse. Unable to move vehicle & blocking traffic for a period of time.

The contact owns a 2021 Ford F-150. The contact stated that the trailer brakes became inoperable. The trailer brake system failure message was displayed. The local dealer was contacted, where it was diagnosed with a TRM failure, an unknown TSB, and an unknown software update were completed. The vehicle was repaired, but the failure existed. The vehicle was taken to the local dealer for NHTSA Campaign Number: 25V132000 (Electrical System) prior to the failure. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 70,000.

Ford has released multiple TSBs related to a known design flaw with their 10r80 transmission that causes the transmission to experience hard shifts while moving and often occurs in traffic. The hard shifts can cause the vehicle to stall which creates a very unsafe situation, especially on highways and interstates. The transmission defect has been redesigned in newer vehicles, however, there are thousands if not hundred of thousands of these vehicles on roadways that can break down suddenly causing a major accident. The ford owners forums have been riddle with concerns about this issue related to the CDF drum in the 10r80 transmission.