2002 FORD F-150 Complaints

02' FORD F150 TRITON V8 5.4 1. LOUD TAPPING NOISE FROM MOTOR. 2. & 3. SPARK PLUG BLOWN OUT OF THE HEAD. SO FAR THIS HAS HAPPENED TWICE. NEW SPARK PLUG, NEW COIL PACK, HEALY-COIL PACK, 4 HRS OF MY TIME WORKING ON THIS P.O.F.S... THERE SHOULD BE A RECALL ON THIS BECAUSE IT SEEMS TO BE HAPPENING ON ALL THE FORD TRUCKS OUT THERE. ONLY FORD. *TR

MID SEPTEMBER 2009 THE CRUISE CONTROL ON MY FORD F-150 TRUCK FAILED TO COME ON. NOVEMBER 6, 2009 I WENT TO WINCHESTER FORD, WINCHESTER, VA TO SEE IF THE SWITCH WAS UNDER RECALL AND TOLD NO. I WAS SHOWN WHERE THE CRUISE CONTROL SWITCH IS LOCATED AND TOLD THE BEST THING TO DO WAS UNPLUG IT IF I WASN'T GOING TO PAY TO REPLACE IT. I PURCHASED A NEW SWITCH FROM THE PARTS ROOM WHEN LEAVING THE FORD GARAGE. ON SUNDAY, 11/8/2009 I UNPLUGGED THE SWITCH AND FOUND EVERYTHING COVERED IN BRAKE FLUID. I PLUGGED THE SWITCH BACK IN TO STOP ANY FLUID FROM SPRAYING OUT ONTO THE ENGINE. I WILL HAVE TO FIND SOMEONE TO REPLACE THE SWITCH BECAUSE I AM PHYSICALLY UNABLE TO DO THE WORK. *TR

I HAVE A 2002 FORD F150 SUPERCREW HARLEY DAVIDSON EDITION WITH A TRITON 5.4 L ENGINE. I PLACED THE TRUCK IN DRIVE AND HEARD A POP AND THEN A CONTINUED RHYTHMIC POPPING. I OPENED THE HOOD AND COULD TELL AIR WAS COMING FROM THE #4 CYLINDER. I TURNED OFF THE ENGINE AND INVESTIGATED FURTHER. THE SPARK PLUG HAD BLOWN COMPLETELY OUT OF THE HEAD AND BROKE THE IGNITION COIL ATTACHED TO THE SPARK PLUG WIRE. SO FAR THIS IS THE ONLY INCIDENT FOR ME BUT AFTER RESEARCHING ONLINE, FOR POSSIBLE REPAIRS SOLUTIONS, I FOUND THAT THIS IS WAY TOO COMMON OF A PROBLEM WITH THESE FORD ENGINES. I AM ONLY GLAD IT HAPPENED WHILE I WAS PULLING OUT OF MY GARAGE. IF THAT HAD HAPPENED AT SPEED ON THE HIGHWAY WITH THE ENGINE TEMPERATURE UP THERE COULD HAVE BEEN A SERIOUS SITUATION. AFTER READING ALL THE PROBLEMS SO MANY OTHERS HAVE HAD, I AM AFRAID OF WHEN THIS COULD HAPPEN AGAIN! *TR

2002 FORD F150 5.4L,SPARK PLUG BLEW OUT OF ENGINE WHILE DRIVING, GAS SMELL AND SPARKS IN ENGINE COMPARTMENT. THIS HAS HAPPENED TWICE TO ME, 11-25-08 AT 70K MI WITH ORIGINAL FACTORY PLUGS CLY #3 PASSENGER SIDE AND 11-03-09 AT 82K MI WITH THE REPLACEMENT NGK PLUGS CLY #4 DRIVERS SIDE. THIS SHOULD BE A RECALL VERY HIGH RISK OF UNDER HOOD FIRE. *TR

TL* THE CONTACT OWNS A 2002 FORD F150. HIS VEHICLE WAS PARKED FOR OVER TWENTY-FOUR HOURS IN THE DRIVE-WAY WHEN THE ENGINE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS COMPLETELY DESTROYED. THE FAILURE MILEAGE WAS 167,000. UPDATED 12/08/09. *LJ THE CONSUMER DID STATE THAT HE HAD PROBLEMS WITH THE CRUISE CONTROL, DUE TO A SHORT AND HAD NOT USED IT SINCE. THE FIRE DEPARTMENT STATED THE CAUSE OF THE FIRE WAS THE CRUISE CONTROL. UPDATED 12/10/09.*JB

TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE THE CONTACT WAS DRIVING 75 MPH SHE SUDDENLY HEARD A LOUD POPPING SOUND IN THE ENGINE AND IMMEDIATELY THE VEHICLE SHUT OFF. A LOCAL MECHANIC STATED THAT THE ENGINE SEIZED AND NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS AND THE CURRENT AND FAILURE MILEAGES WERE 100000. UPDATED 11/13/09. *LJ UPDATED 11/16/09.*JB

I HAVE A 2002 FORD F-150 LIGHTNING, I WAS DRIVING ONE DAY AND THE SPARK PLUG SHOT OUT OF THE ENGINE DUE TO LACK OF THREADS TO HOLD THE SPARK PLUG IN. THE VEHICLE WAS REPAIRED USING A TIME-SERT KIT. *TR

TL*THE CONTACT OWNS A 2002 FORD F-150. THE SEAT BELTS WILL NOT REMAIN LATCHED INTO THE BUCKLE. THE DRIVER-SIDE SEAT BELT AND BUCKLE WERE REPLACED AT AN EXPENSE OF $53.00. AFTER THE SEAT BELT AND BUCKLE WERE REPLACED, THE FRONT SEAT BELT FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED; HOWEVER, SINCE THE WARRANTY EXPIRED, NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 63,000 AND THE CURRENT MILEAGE WAS 65,000.

APPARENTLY THE NHTSA MUST NEED MORE COMPLAINTS OR A DEATH TO INVESTIGATE THIS ISSUE. SECOND PENDING FIX 9-23-2009 95,000. AFTER HAVING READ ALL THESE COMPLAINTS AND RELIVING THE SAME PROBLEMS AGAIN THROUGH THIS WEBSITE, AND I'M SURE MANY MORE UNDOCUMENTED COMPLAINTS. I AM NOW ON MY SECOND FIX. FIRST TIME 3 SPARK PLUGS THROUGH THE ENGINE. HAD EXTENDED WARRANTY SO FORD DID A BAND AID FIX ( SURPRISE ) NOW HERE WE ARE A YEAR LATER AND WE NEED SURGERY $4900 JUST TO PUT A NEW HEAD ON ONE SIDE. WHAT IS BEING DONE TO HOLD FORD ACCOUNTABLE FOR A KNOWN DEFECT. THE OPPORTUNITY FOR FIRE AND/OR DEATH IS VERY HIGH AND YET THIS PROBLEM IS NOT IMPORTANT TO ANYONE EXCEPT FOR LETTING FORD GET RICH ON THEIR KNOWN DEFECT. SAD GOV SITE THIS IS JUST A VENT PAGE NEVER TO HANDLED. *TR

I HAVE A 2002 FORD F-150. IT STARTED TO LEAK WHEN IT RAINS. THE PROBLEM IS THE BEZEL COVERING THE PLACES WHERE THE GLASS IS ATTACHED TO THE TRUCK - THE BRACKETS WHERE THE SCREWS GO HAVE CRACKED AND THE GROMMETS AROUND THE BOLTS HAVE FAILED. I WANT TO FIX THE ITEM, BUT I HAVE LEARNED THAT THE NECESSARY PART (THE PLASTIC BEZEL FOR THE BACK WINDOW) IS ON NATIONAL BACKORDER, BECAUSE SO MANY OF THEM HAVE FAILED THERE ARE NO MORE AVAILABLE. IT SEEMS TO ME THAT IF SOMETHING IS BREAKING SO MUCH THAT NO ONE HAS THE REPAIR PARTS, THEN THIS SHOULD BE AN ITEM FOR RECALL. *TR