2019 FORD F-150 Complaints

The transmission is falling out of gear at random times including when going up hills or when merging onto the interstate. Other times it revs up and won’t switch at all only to slam into gear. Most problems with shifting occur around the 3rd and 4th gear.

Transmission. 3rd to 4th or 4th to 5th upshift shuddering and occasionally abrupt downshift from 4th to 1st then back to 4th.

The contact owns a 2019 Ford F-150. The contact stated that while the transmission was downshifting, there was a loud bang coming from the transmission, with a popping sound coming from the rear suspension. The contact stated that the sound was most apparent when the brake pedal was depressed. The contact stated that the message that the driver’s side rear door was open, causing the light to remain illuminated even though the door was securely closed. During the failure, the lights inside and outside the vehicle remained illuminated, causing the battery to become drained. The contact stated that the infotainment center failed and needed to be rebooted whenever the vehicle was turned off and restarted. The failure disabled the back over prevention camera intermittently. The contact stated that occasionally back over prevention camera became activated while driving and remained operational until the system failed. The contact stated that the back over prevention failure and infotainment system failure started after Ford had completed a routine software update. The vehicle was taken to the dealer, but the cause of the failure was not determined. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 86,500.

The contact owns a 2019 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V252000 (BACK OVER PREVENTION); and the vehicle was taken to a local dealer for the recall repair. The contact stated that shortly after the vehicle was repaired the vehicle experience electrical failures. The contact stated that while driving at undisclosed speeds, the navigation system and radio became inoperable. Additionally, the contact stated that at whatever volume level the radio was set to, the level remained until the vehicle was turned off and restarted. There was no warning light illuminated. The vehicle was taken back to the dealer to be diagnosed, and the contact was informed that the APIM Controller was faulty and needed to be replaced. The vehicle was repaired twice; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 22,000.

Rear window ford part number 1542006 - Back window glass has 1" cracks in glass where the glass connects to the body on the left passenger side of the crew cab. Cracks have caused leaks into the cab interior and has caused the modem, mounted behind the rear passenger set on the back wall to stop working as water has infiltrated the electronics. Vehicle was inspected at dealership and their 3rd party glass leak specialists discovered the cracks in the glass connection. I have no idea as to how long this has been going on, estimate a few months as I recently discovered I could not communicate with the vehicle through the Ford Connect App and called Ford Connect, they identified an issue with the modem and when I pulled back the upholstery to see, there was water dripping inside the vehicle. Unknown if cracks will propagate, however they are leaking when it rains. I will be replacing the glass to prevent further leaks from occurring. I have extended warranty through Ford and "glass" is not covered. Reached out to Ford Care and they would not cover. Suggested that I put in a report here so that if later recall or other action, I might be able to get refund for the repair that I am now going to have to pay for to replace the glass and possibly the modem. No other symptoms other than the filaure of the modem that alerted to the issue.

I was driving my vehicle at approximately 70mph and the vehicle suddenly downshifted into a low gear (i believe 1st) causing tires to lockup. I was able to maintain control of the vehicle. Within 5 miles of driving it, the transmission was acting erractic. Was brought to local mechanic and it was determined the transmission is now shot this incident.

Rough idling result in Cam phaser and timing belt replacement. While driving the vehicle would accelerate and decelerate on its own making it unsafe to drive. Dealer quoted me $6,095 to replace camp phasers (part #HL2Z-6C590-A)

Vehicle is Shifting hard and has down shifted to 1st gear on highway. Along with skipping gears.

The contact owns a 2019 Ford F-150. The contact stated that while attempting to start the vehicle, there was an abnormal rattling sound coming from the engine. The contact stated that after several attempts, the vehicle started. There was no warning light illuminated. The vehicle was not diagnosed or repaired. The contact related to the failure to Ford Campaign Number: 21N03. The contact investigated the issue and related the failure to the cam phasers. The manufacturer was contacted and opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 59,000.

My 2019 F150 started having a loud rattling noise coming from the motor. I took my truck to the Sam Galloway Ford dealership and it was determined that the cam phasers needed to be replaced however they would not cover this cost since my VIN was not listed on the recall sheet. My vehicle was manufactured in Kansas during the time period and has the 3.5 liter motor and according to the recall letter my vehicle should be included in this recall. Please see below recall summary TO: All U.S. Ford and Lincoln Dealers SUBJECT: Customer Satisfaction Program 21N03 – Supplement #1 Certain 2017-2020 Model Year F-150, 2018-2020 Expedition, and 2018-2020 Navigator Vehicles Equipped with a 3.5L GTDI Engine Cam Phaser Replacement REF: Customer Satisfaction Program 21N03