2020 FORD F-150 Complaints

The contact owns a 2020 Ford F-150. The contact stated that after starting the vehicle, there was a clunking sound present when shifting out of park. The vehicle had also experienced hard shifting when shifting from third through fifth gear, and seventh to eighth gear. The vehicle also experienced a loss of torque while driving at slower speeds. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was not yet contacted. The failure mileage was 30,000.

The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed that the engine consumed an excessive amount of oil; however, no repair was recommended. The contact stated that they had to add engine oil to the engine every 1,000 miles. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The manufacturer advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 50,000.

The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost all motive power, after which the contact became aware that the gear selector was stuck in the drive position. No warning lights were illuminated. The vehicle was towed to the dealer, who was unable to diagnose the failure but informed the contact that the transmission control module had been reprogrammed. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer an additional five times, with the dealer not being able to diagnose the failure. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 17,000.

1 year ago I started getting the “Charge System Fault” alert on my truck, took to the shop and they advised the battery needed to be replaced. After replacing, a few weeks later it started happening again, so they did further testing and advised the alternator was bad. Replaced the alternator and 6 months later the alert started intermittently again. It has been sporadically ever since when at an idle and doesn’t stay on long enough to have on a reader to reflect what is really wrong. I’ve attached the error from my FordPass app that comes thru once in a while but it’s frequent on the truck dash while it’s running, at idle whether in park or at a stop light. It’s not every time the truck is running, but becoming more frequent again.

While driving in the rain, my vehicle had a complete electrical failure. I could not accelerate or even turn the vehicle off. Because of this I could not move my vehicle off the highway. Fortunately I was not hit by the vehicle behind me, and was not in a turn. he Several warning lights came on. After being towed to a dealership, it was found that the factory windshield was leaking into the passenger side area where the Body Control Module (BCM) is housed. This flooded the unit and completely killed the truck. It was surprising to me that rain had the ability to completely render my truck useless. The manufacturer would not cover any repairs as they claimed windshield leaks were a maintenance issue.

My 2020 ford truck driver side door locks freeze when temperatures get below freezing. When this happens the door does not open and when I open it from the inside the door doesn’t latch. I have to use a bungee cord to hold the door closed if I’m going to use the vehicle. Also the rest of the doors don’t lock when driving the vehicle. I believe other year ford trucks have had this issue and they also were recalled for a fix. I have had the truck to the dealer several times with no luck. The last time when the truck was under warranty they replaced the door lock actuator which didn’t help. I believe this is very much a safety issue and I shouldn’t even be driving this truck but I need it.

The windshield wiper did not shut off anymore Ever 20 seconds it went back and forth once. After searching the internet I found 100s of links related to the same issue with Ford vehicles and the Multifunction switch mounted on the steering wheel. I consider this a safety issue because people try to fix the wiping issue while driving. Also being on the road it could cause damage to the windshield wiping in a dry environment. Dust and debris can scratch the screen over time and inhibit a clear vision while driving. Looking at several videos it seams that the multifunction switch contacts are prone to corrosion inside the driver cabinet of the vehicle. Going from Hot in the sun 130 degree F + to 65 Degree F. The switch connection and contacts are not sealed and open to condensation,creating a corrosive environment.

1. The start/stop function will not restart at some long stop lights. I have to restart the vehicle. 2. The wiper will come on without being turned on. 3. The brake have started to grind like, the brake pads are bad. The brake will grind sometimes when coming to a stop. They have been checked and a recent service also. The brakes do this even during the day. The dealership found the brakes to be working in perfect order. 4. Transmission issues have been resolved to a point. 5. Service department great, however; the can duplicate issues with vehicle.

The contact owns a 2020 Ford F-150. The contact stated that after starting the vehicle, the transmission shifted into gear, and the vehicle made an abnormal sound. Additionally, the transmission was slipping while driving. The transmission later failed to shift into gear, and the engine revved loudly. No warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the transmission needed to be rebuilt. The vehicle was then taken to BZ Ford (309 US-6, Ligonier, IN 46767), where the PCM was reprogrammed and the drive cycle was completed; however, the failure recurred. The vehicle was taken back to BZ Ford, and it was determined that the transmission needed to be rebuilt. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 30,000.

Since new it has used 3qts of oil every 5000 miles. It has been to two different Ford shops and they say there is nothing wrong with it and refuse to do anything with it. A new engine should not be using oil. I've been a mechanic for over 50 years. No engine that I ever built used oil. This is unacceptable