2009 FORD F-150 Complaints

RECENTLY, WHILE DRIVING DOWN THE HIGHWAY, BOTH THE ABS LIGHT AND BRAKE LIGHT CAME ILLUMINATED ON THE INSTRUMENT PANEL OF MY TRUCK. THE MESSAGE CENTER DISPLAYED A READING OF CHECK BRAKE SYSTEM. THE BRAKES BEGAN TO HAVE A PULSATION TO THEM AND THE TRUCK JUST DID NOT WANT TO COME TO A COMPLETE STOP. I TOOK MY TRUCK TO A MECHANICAL SHOP WHERE THEY CHARGED ME TO DIAGNOSE THE PROBLEM CAUSING THESE SYMPTOMS. THEIR FINDINGS WITH THE DIAGNOSTIC CHECKS REVEALED A FAILED ABS MODULE. NO REPAIRS HAVE BEEN MADE. THE TRUCK HAS BEEN PARKED IN OUR DRIVEWAY.

ACCELERATOR PEDAL SENSOR STICKS UNDER ACCELERATION. VERY DANGEROUS. IT'S HAPPEN 5 TIMES TO ME. 21,196 MILES ON THE TRUCK. I HOPE THIS TRUCK DOESN'T KILL NO ONE SOME DAY. I HAVE COPYED THIS PAGE FOR MY RECORDS AND SENDING COPIES TO THE PEOPLES LAWMAKERS STATE AND FED. THANK YOU FOR YOUR TIME. HAVE A GREAT DAY.

ABS MODULE DEFECTIVE IN THE TRUCK, POWER STEERING GOING OUT. RPM MODOLE NOT WORKING.

THE REAR DRIVE SHAFT BETWEEN TRANSFER CASE AND REAR DIFFERENTIAL IS HELD BY A DRIVE SHAFT BRACKET/BEARING WHERE THE TOP OF IT IS WELDED TO THE FRAME CROSS MEMBER. DURING STOP AND GO TRAFFIC THE POORLY WELDED BRACKET CAME LOOSE. AS YOU CAN SEE FROM THE PICTURE THE WELD WAS POORLY DONE AND HAD NO PENETRATION INTO THE METAL. THE METAL WAS NOT TORN AT ALL AND BROKE COMPLETELY CLEAN OFF WHICH DICTATE A VERY POOR JOB ON THE WELD ITSELF. TO MAKE MATTERS WORSE THIS PART IS BASICALLY A DUAL SHARP BLADES AT THE WELD BREAK, CONNECTED TO THE DRIVE SHAFT AT FAST RPMS WOULD TAKE LITTLE TO NO TIME TO PUNCTURE AND IGNITE THE NEAR BY FUEL TANK. AS I WAS TRAVELING AT SLOW SPEEDS I WAS ABLE TO STOP THE VEHICLE RIGHT AWAY. IF THIS BREAK OCCURRED AT HIGHWAY SPEEDS I FEEL THAT IT WOULD HAVE EASILY PUNCTURED THE FUEL TANK AND IGNITED THE FUEL CAUSING CATASTROPHIC FIRE AND PROBABLE EXPLOSION THAT COULD CAUSE INJURY OR DEATH.

DRIVING ON A CITY STREET WHEN THE ENGINE SUDDENLY SHUT DOWN AND QUIT RUNNING. I WAS ALMOST REAR ENDED BY A SEMI TRUCK AND ONLY AVOIDED A MAJOR ACCIDENT BECAUSE I HAD ROOM TO GO TO THE RIGHT AND THE SEMI HAD ROOM TO SWERVE AROUND ME ON THE LEFT. WHEN I HAD IT TOWED TO THE FORD DEALER THEY INFORMED ME THAT IT WAS A MELTED FUSE BUT THAT THEY WERE ALREADY AWARE OF THE PROBLEM AND HAD A "FIX" KIT IN STOCK AND THE REPAIR PROCESS ALREADY DOCUMENTED TO REROUTE THAT FUSE. THIS MEANS THAT FORD IS AWARE OF THIS PROBLEM AND I PRESUME WAS JUST WAITING FOR SOMEONE TO DIE BEFORE ISSUING A RECALL.I HAVE THE REPAIR ORDER AVAILABLE IF NEEDED. WHEN I CONTACTED FORD DIRECTLY THEY INFORMED ME THERE WAS NO RECALL AND THEREFORE I WAS RESPONSIBLE FOR THE ENTIRE $650.00 COST AND DID NOT SEEM TO CARE ABOUT THE POSSIBILITY OF A MAJOR ACCIDENT WHEN THE ENGINE SUDDENLY STOPS RUNNING.

THE TRUCK IS SHUTTING OFF WHILE DRIVING AND AT ALL SPEEDS. MY HUSBAND HAS TO PULL AND RESET FUSE 27 TO ALLOW THE FUEL PUMP TO RECIEVE POWER. THIS HAS PUT MY HUSBAND IN DANGEROUS SITUATIONS AS IT HAS HAPPENED IN HEAVY TRAFFIC ON TWO LANE HIGHWAYS. WE ARE REQUESTING A SERVICE VOUCHER BE SENT TO OUR LOCAL DEALER TO FIX THE PROBLEM WE UNDERSTAND HAS ALREADY HAD A BULLETIN SENT OUT FOR. IT IS A FORD ISSUE AND WE WOULD APPRECIATE THIS BEING REMEDIED. WE WERE QUOTED A PRICE OF AROUND $300 TO CHANGE OUT THE RELAY THAT IS CAUSING THE ISSUE.

THE TRUCK IS SHUTTING OFF AT ANY POINT IN TIME AND PUTTING MY HUSBAND AND OTHERS IN DANGER AS IT HAS HAPPENEND WHILE GOING DOWN BUSY ROADS AND THE HWY. HE HAS TO GET OUT AND REINSERT THE FUSE.IT HAS ALSO FAILED TO START UNTIL THE FUSE IS REINSERTED. IT HAS BLOWN FUSES. THIS IS UNDER RECALL IN OTHER VEHICLES FUSE 27. FUSE 8 WAS ALSO CAUSING PROBLEMS AND IT HAS BEEN REPLACED. WE HAVE SINCE LEARNED OF THE SERVICE BULLETIN. IT IS A PROBLEM WE FEEL SHOULD BE COVERED BY FORD WHICH HAS BEEN QUOTED AS BETWEEN 250$ AND 300$. WE ARE REQUESTING A VOUCHER FOR REPAIR BE SENT TO OUR LOCAL DEALER FOR THE REPAIR. THANK YOU FOR YOUR ATTENTION TO THIS MATTER.

GAS GAUGE SUDDENLY DOESN'T REGISTER CORRECTLY. ONLY SHOWS APPROXIMATE THREE QUARTERS TANK WHEN TANK IS FULLY FILLED. WHEN REGISTERING ONE QUARTER TANK ONLY TAKES $15- TO $16 TO REFUEL. REPAIR SHOPS HAVE NOT BEEN ABLE TO DETERMINE CAUSE. WHAT CAN BE THE CAUSE.

BOTH FRONT SPRINGS ARE BROKE. FRONT END TO LOW TO THE GROUNG AND HITS WHEN NOT ON PAVED ROADS.ONLY 35000 MILES AND MOSTLY IN TOWN DRIVING

AT APPROXIMATELY 86000 MILES MY ABS AND BRAKE WARNING LIGHT ILLUMINATED. I TOOK IT TO MY CERTIFIED MECHANIC WHO RAN A DIAGNOSTIC WHICH REVEALED A FAILED ABS MODULE. REPLACEMENT COST IS OVER $800.00 AND WITH OVER 233 COMPLAINTS THAT WE KNOW OF, WHEN IS YOUR ORGANIZATION GOING TO MAKE FORD ACCOUNTABLE?