2021 FORD F-150 Complaints

The contact owns a 2021 Ford F-150. The contact stated that while the vehicle was parked, the contact attempted to start the vehicle, and the electric steering fault message was displayed. A dealer was contacted. The vehicle was towed to the dealer where is was diagnosed that the steering gear assembly needed to be replaced. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 21V407000 (STEERING). The manufacturer was not notified of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 38,008.

Transmission suddenly downshifted from 7th to 1st gear when driving along a highway. This significantly slowed the vehicle down and almost caused a following vehicle to collide with me. The vehicle will also shift from 4th to 3rd violently, revving the engine then slammining into gear. This throws the heads of all occupants a d causes significant early wear and tear on power train components.

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the door opened independently. The contact stated upon inspecting the vehicle, he noticed that the door latches was frozen, and the contact was unable to enter or exit the vehicle. The dealer was contacted. The vehicle was taken to a dealer where it was diagnosed that the door latch needed to be replaced. The contact was provided an estimate for the repair. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The contact related the failure to NHTSA Campaign Number: 17V652000 (LATCHES/LOCKS/LINKAGES); however, the VIN was not included in the recall. The approximate failure mileage was 98,000.

Unable to rotate tires or change a flat tire because per dealer Ford lug nuts are swollen and they can not come off with standard tool (lug wrench). Dealer informed me this has been an issue for years but there are no recalls. I was shocked to find out a simple issue like a flat tire can not be fixed due to the simplest designed piece of equipment on the vehicle (lug nut). Dealer stated i can buy replacement lug nuts from Ford for about $200.00 but they will do the same thing over time. I just found many write ups about this ongoing problem and wonder why NHTSA allows this to not be a recall ... this is a safety issue. Get Ford to redesign the Lug Nut, make it a simple one piece design and relace at no charge. If I or one of my family members get a flat tire and is stranded that would not be good!

In the cold winter of Bismarck, ND, all of my truck's door handles are frozen, so I am unable to get in or out of my truck (NHTSA SSM XXXXX). I have been climbing in and out of my window to get into my truck. This is already a safety concern recognized by your organization, so why doesn’t my truck qualify for a recall? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Passenger side headlights assembly has a daytime running light that stopped working properly. There is no longer a fully functioning running light that decreases visibility to other vehicles. The manufacturer will not replace and the it cannot be repaired without a full headlight assembly replacement that is not affordable.

The ford is a ford F150 2021 with only 47,000 miles on it. It is a well taken care of truck with all routine maintenance done. The power control steering module has completely gone out in my truck. Unfortunately this problem began to occur with my children in the car when a warning light came on and then the power steering completely went out making it extremely difficult to turn and steer the car. Thankfully this occurred on a backroad and not the highway. Needless to say, it is not safe to drive my car and is now sitting in the shop. Ford has confirmed the problem but is unable to get a new PSCM because it is back ordered meaning many people are facing the same issue. We are told they are unsure if the part will become available in a month or 6 months which means we are out a car for that long. With the part being on such a back order, I would hope this would be a red flag to not only ford but to the NHTSA that this is a common problem and error on a faulty part which is extremely dangerous.

Both drl leds around the housing failed. Twice now. This is a know issues with 21+ f150s

Both Front headlight DRL failed at 40K miles. This poses a safety risk for other vehicles on the road

Front DRL on the headlights no longer work making it difficult for other vehicles to have a clear sight of vehicle.