2002 FORD F-150 Complaints

THE TRUCK WAS DRIVEN BACK FROM THE STORE, A DISTANCE OF A FEW MILES, THEN PARKED IN MY DRIVEWAY. APPRXIMATELY 30 MINUTES LATER I HEAD WHAT SOUNDED LIKE A COMPRESSOR RUNNING OUT IN THE STREET. WENT OUT INTO THE DRIVEWAY AND FOUND THE STARTER WAS TURNING OVER THE ENGINE. THE TRUCK HAD BEEN TURNED OFF WHEN PARKED AND THE KEY WAS REMOVED. WENT BACK INSIDE GOT THE KEY, AND TURNED THE IGNITION SWITCH TO THE "RUN" POSITION. TRUCK STARTED AND RAN. TURNED OFF IGNITION AND REMOVED KEY, BUT THE STARTER CONTINUED TO TURN ENGINE. DID THIS SEVERAL TIMES BEFORE LETTING THE ENGINE RUN FOR APPROXIMATELY 5 MINUTES, THEN FINALLY WAS ABLE TO TURN OFF IGNITION AND STARTER DID NOT CRANK THE ENGINE. NEXT MORNING TRUCK WOULD NOT START. TRUCK WAS TOWED AND HAD TO HAVE STARTER REPLACED BECAUSE IT HAD BURNED OUT. THE TRUCK HAS ONLY 15,000 MILES. CALLED LOCAL FORD SERVICE DEPARTMENT WHERE TRUCK WAS PURCHASED AND THEY SAID THEY WERE UNAWARE OF ANY PROBLEMS WITH STARTERS. OBVIOUSLY THERE IS A PROBLEM WITH STARTER ENGAGING BY ITSELF.

MANUAL CLUTCH MALFUNCTIONED INCLUDING REMAINING DISENGAGED (IN GEAR) WHILE PEDAL WAS DEPRESSED TO THE FLOOR. SLAVE CYLINDER FAILED AND LEAKED FLUID NECESSITATING REPLACEMENT. OCCURRED AT <45000 MILES AND IS IDENTICAL TO THE FAIL MECHANISM EXHIBITED ON NEIGHBORS 2001 F150 4.6 AT 39000 MILES. *JB

DT*: THE CONTACT STATED WHILE DRIVING 10 MPH, A BURNT SMELL WAS NOTICED. UPON INSPECTION, A RED WIRE UNDER THE DRIVER SEAT WAS ON FIRE. ALSO, THE ELECTRICAL WIRING HARNESS FOR THE POWER SEATS AND SEAT HEATER WAS INOPERABLE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHO DETERMINED THAT THE WIRES RUBBING AGAINST THE SEAT FRAME CAUSED THE FIRE. THE DEALER REPLACED THE 3 WIRING HARNESSES CONNECTED FROM THE DASH TO ALL SEATS IN THE VEHICLE. THE MANUFACTURER WAS ALERTED AND DENIED THE CLAIM.

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON THE HIGHWAY IN STOP AND GO TRAFFIC, THE VEHICLE STRUCK ANOTHER VEHICLE IN THE REAR AND THE AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT AND NO INJURIES WERE SUSTAINED. THERE WAS EXTENSIVE DAMAGE TO FRONT OF THE VEHICLE; THE INSURANCE ADJUSTOR DEEMED THE VEHICLE A TOTAL LOSS. THE POLICE WAS ALERTED AND A REPORT WAS TAKEN. A MANUFACTURING REPRESENTATIVE INSPECTED THE VEHICLE AND DETERMINED THE AIRBAGS SHOULD HAVE NOT DEPLOYED DUE TO THE IMPACT AND NO DEFECT WAS FOUND. THE MANUFACTURER WAS ALERTED.

I OWN A 2002 FORD F-150 SUPERCREW 4X4 PICKUP WITH 5.4L V8 GAS ENGINE AND AOD AUTOMATIC TRANSMISSION. AT 48,500 MILES ON THE VEHICLE THE OD ON/OFF SWITCH WOULD NOT STAY ENGAGED AND WAS FLASHING INTERMITTENTLY I TOOK THE TRUCK TO A LOCAL TRANSMISSION SHOP WHO SHOWED ME METAL SHAVINGS IN THE TRANSMISSION PAN AND WAS TOLD THE TORQUE CONVERTER MUST BE REPLACED AND THE TRANSMISSION MUST BE REBUILT. I AGREED TO THE WORK BECAUSE I NEED A DEPENDABLE VEHICLE. I HAVE NEVER ABUSED THE TRUCK IN ANY WAY AND DO NOT HAUL ANY TYPE OF TRAILERS WITH THE VEHICLE. *NM

DT*: THE CONTACT STATED THE POWER WINDOWS, HORN AND TURN SIGNALS FAILED INTERMITTENTLY. THE FUSES WERE REPLACED BY THE CONTACT AND THE WINDOWS, HORN AND TURN SIGNALS RESUMED PROPER FUNCTION. WHEN THE IGNITION WAS ENGAGED, SMOKE EMITTED FROM UNDER THE DASH BOARD AND FROM UNDER THE HOOD. A SERVICE DEALER INSPECTED THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED.

THE BRAKE PEDAL STOPPED MOVING WHEN ACTUATING THE ADJUSTABLE PEDALS. THE ACCELERATOR PEDAL MOVES SO THERE IS NO STEP OVER HEIGHT DIFFERENCE BETWEEN THE PEDALS. WITH THE PEDALS BEING AT THE SAME HEIGHT POSITION THERE IS NO WAY TO DIFFERENTIATE BETWEEN THEM OR STEP ON BOTH AT SAME TIME. *JB

MY 2002 FORD F150 HARLEY DAVIDSON PICKUP TRUCK EJECTED A SPARK PLUG WHILE DRIVING ON THE HIGHWAY . THIS IS THE THIRD INCIDENT OF FAILURE AND AM CONCERNED FOR MY SAFETY AS THE TRUCK LOOSES POWER WHILE AT HIGHWAY SPEEDS AND COULD CAUSE AN ACCIDENT . IN ADDITION THE FAILING PLUG THIS TIME WAS ONE RIGHT UNDER THE FUEL RAIL AND THE COIL WAS PREVENTED FROM CONTINUING TO PULL OUT BY THE FUEL RAIL ADDING CONCERN THAT IT COULD PUNCTURE AND CAUSE AN ENGINE FIRE .WHEN CONTACTING FORD THEY BASICALLY TOOK MY INFORMATION AND OFFERED NO ASSISTANCE . *NM

I HAVE A F150 2002 FORD PICKUP WITH 55,000 MILES ON IT. MY PARENTS AND I HAD JUST FINISHED LUNCH AND GOT IN MY TRUCK. I TURNED THE KEY AND WE HEARD 2 LOUD POPPING NOISES AND THE MOTOR STARTED RUNNING ROUGH (PULSING). TURNED THE VEHICLE OFF, OPENED THE HOOD ONLY TO DISCOVER THE SPARK PLUG HAD BLOWN OUT OF THE #8 HOLE AND WAS LAYING DOWN IN A CREVICE ON THE ENGINE AND THEN ROLLED OUT OF SIGHT. WE HAD TO CALL A FLATBED TOW TRUCK AND WERE TOWED 82 MILES BACK TO NORTH COUNTRY FORD, COON RAPIDS, MN ON A SATURDAY NIGHT WHERE WE LEFT THE VEHICLE. ON MONDAY MORNING I FOUND OUT TO MY SURPRISE FROM THE SERVICE DEPARTMENT AT NORTH COUNTRY FORD THAT THE EXTENDED WARRANTY I HAVE ON THE TRUCK WOULD NOT COVER THE $2,300 COST. NORTH COUNTRY SENT OUT THE HEAD TO HAVE THE HOLES DRILLED LARGER FOR THE SPARK PLUGS. I HAVE DRIVEN FORD PRODUCTS FOR OVER 45 YEARS BUT THIS WILL BE THE LAST FORD UNLESS FORD OWNS UP TO THIS PROBLEM AND DOES A RECALL AND CREDITS PEOPLE LIKE MYSELF WHO HAVE BEEN INCONVENIENCED. *JB

I RECEIVE STORM DAMAGES TO MY VEHICLE. DURING THE PROCESS OF REPAIRING THE VEHICLE WE SUSTAIN INJURIES FROM THE WINDSHIELD FIBERS AND GLASS, IN THE VENTS WHICH THE REPAIR SHOP SAID THAT THE GLASS IS IMPOSSIBLE TO REMOVE. THE TRUCK HAS A DEFECT IN THE HEAT CONTROL AND THE RADIO PANEL GET EXTREMELY HOT. WE INHALE THE FIBER FROM THE GLASS , IT GOT IN OUR EYES, STINGING AND ITCHING, ETC. I WAS TOLD THAT THIS MAY BE A PRODUCT PROBLEM. *NM