2002 FORD F-150 Complaints

THE PASSENGER SEAT BROKE IN MAY 06, BACK OF SEAT WOULD COLLAPSE ON SEAT. TOOK TRUCK TO AUTO SHOP AND WAS TOLD "SEAT/ BACK BAR"? WAS BROKEN. ON 07/08/06 DRIVER SIDE SEAT BROKE, SAME TYPE OF BREAK, BACK OF SEAT LEANS FORWARD ONTO SEAT, WILL NOT CATCH. *JB

ORIGINAL WINDSHIELD SEAL BEGAN LEAKING WATER INSIDE CAB AND INTO DASH COMPARTMENT RESULTING IN ELECTRICAL FAILURE. THE LEAK ORIGINATED IN THE DRIVER SIDE VALLEY ON TOP OF THE CAB OF THE TRUCK. THE VALLEYS ALLOW WATER TO FLOW DIRECTLY TO AND POOL UP AT THE WINDSHIELD WHEN VEHICLE IS PARKED. I REMEDIED THIS BY CAULKING THE AREA TO PREVENT FURTHER WATER DAMAGE. *NM

FORD F-150 BLEW OUT A SPARK PLUG FROM THE HEAD, THIS IS A KNOWN PROBLEM AND HAS HAPPENED TO THOUSANDS OF PEOPLE AND FORD REFUSES TO DO ANYTHING ABOUT IT. AVERAGE COST OF REPAIR TO THE CUSTOMER IS 3500. *JB

AT ABOUT 75K MILES, A VERY FAINT WHINE WAS COMING FROM THE BACK END OF THE VEHICLE, MAINLY AUDIBLE WITH ACCELERATION AND AT SPEEDS OF ABOUT 35 MPH. IT SLOWLY PROGRESSED, WE TOOK IT TO A LOCAL FORD DEALERSHIP AND WAS TOLD THAT THIS IS HAPPENING WITH MANY FORD 150'S WITH THIS YEAR, IT WAS A DEFECT IN THE PARTS (THE MATERIAL IT WAS MADE WITH). WE WERE TOLD TO CONTINUE TO DRIVE IT UNTIL NOISE WAS TOO LOUD. AT 92K MILES, IT WAS A PRETTY LOUD WHINE AT ALL SPEEDS EXCEPT ABOUT 70 MPH, AND THEN PROGRESSED TO A GRINDING NOISE. I JUST TOOK IT INTO THE DEALERSHIP, THEY SAID THE REAR DIFFERENTIAL, PINION AND CARRIAGE GEARS WERE "TORN UP". THEY FOUND A REPLACEMENT AND TOTAL COST IS $1800. AT THIS POINT FORD IS NOT FIXING PART, SINCE THERE IS NO EXTENDED WARRANTY, BUT THIS IS NOT A PART THAT SHOULD BE GOING OUT AT 90K MILES EITHER, AND WITH THE DEALERSHIP SAYING THIS IS HAPPENING OFTEN AND THERE WAS A DEFECT IN THE PART, FORD SHOULD BE RECALLING THIS, OR AT THE VERY LEAST PAYING FOR THE FIX WHEN IT STARTS TO GO BAD. *JB

SINCE PURCHASE OF VEHICLE THREE COILS HAVE GONE BAD AND HAD TO BE REPLACED. I WAS TOLD BY THE MECHANIC AT A FORD DEALERSHIP TO NOT WASH THE MOTOR ON THE VEHICLE. I WAS ALSO TOLD THAT THEY HAVE HAD SEVERAL PROBLEMS WITH THE COIL CONFIGURATION ON ALL FORD, LINCOLN, AND MERCURY VEHICLES SINCE THEY SWITCHED TO INDIVIDUAL COILS FOR EACH CYLINDER. THIS IS VERY EXPENSIVE TO REPLACE AND IT HAS TO BE CHECKED ON THE COMPUTER TO TELL WHICH ONE IS BAD. *JB

I WAS DRIVING DOWN THE ROAD ABOUT 45 MPH, WHEN I HEARD A LOUD NOISE SO I PULLED OVER , FOUND THE PASS SIDE REAR PLUG WAS SHOT OUT OF THE MOTOR AND LAYING ON THE TOP OF THE ENGINE. THE COIL PACK IS CRACKED AND THE MOUNTING BRACKET SNAPPED OFF. I HAVE DONE NOTHING TO FIX THIS YET!YES I HAVE OLD PARTS. *JB

I RECENTLY RESPONDED TO HAVE THE RECALL FOR THE CRUISE CONTROL ON MY 2002 F-150 COMPLETED. SINCE THEN, MY CRUISE CONTROL HAS FAILED TO WORK AND WHEN I HIT THE "ON" BUTTON AND THE "COAST" BUTTON AT THE SAME TIME, MY HORN WILL BLOW. THE DEALER HAS INFORMED ME THAT THERE IS AN $89 DIAGNOSTIC FEE FOR SOMETHING THAT HAS NEVER WORKED SINCE THIS " FACTORY FIX". IT HAD WORKED UP UNTIL I DROVE IT IN THAT DAY. *JB

MY 2002 FORD F150 SVT LIGHTNING EJECTED THE VERY BACK PASSENGER SIDE SPARK PLUG. I WAS IDLING AT A RED LIGHT, A LOUD POP, AND SOMEHOW DROVE THE TRUCK TO THE NEAREST FORD DEALER. (JOE SARTAIN FORD, DECATUR, AL) *NM

WHILE DRIVING DOWN THE STREET, AT A SLOW RATE OF SPEED, AND MAKING A SLIGHT TURN TO THE LEFT, THE TIE-ROD END ON THE DRIVER'S SIDE BROKE OFF AND JAMMED INTO THE WHEEL. THE TIE-ROD GOUGED THE INSIDE OF THE ALUMINUM AND PUNCTURED THROUGH THE WHEEL. I WAS ABLE TO BRING THE TRUCK TO A STOP IN THE MIDDLE OF THE STREET. BOTH THE INNER AND OUTER TIE-RODS ON THE DRIVES SIDE WHERE REPLACED. THE ALUMINUM WHEEL ALSO NEEDS TO BE REPLACED AS IT IS SCORED AND WILL NOT HOLD AIR. *NM

I PURCHASED A USED 2002 FORD F150 4X4 FROM THE MANAGER OF A FORD DEALERSHIP. WITHIN 7 MONTHS A SPARK PLUG BLEW, WE DID NOT KNOW IT WAS SUCH A PROBLEM BUT WE REPAIRED IT AND A COUPLE OF MONTHS LATER IT DID IT AGAIN WE REPAIRED IT THINKING MAYBE WE DID NOT REPAIR THE FIRST ONE CORRECTLY. THEN A MONTH LATER IT DID IT AGAIN. I SEARCHED WEB SITES AND SAW IT WAS A GREATER PROBLEM. I TOOK MY TRUCK INTO A FORD DEALERSHIP-(WHICH SAY THEY CAN NOT REALLY SAY WHAT THE PROBLEM IS EXACTLY?) IT COULD BE FROM A BLOWN SPARK PLUG.. BUT REFUSE TO GIVE THAT AS A REASON? I WONDER WHY? SO THEY HAVE QUOTED ME ABOUT $3200.00 IN REPAIRS NOT INCLUDING LABOR, WHICH WILL TAKE IT UP TO ABOUT $5000.00!!! I CAN NOT AFFORD THIS AS IT TOOK EVERYTHING FOR ME TO PAY FOR THIS TRUCK, WHICH I FEEL WAS SOLD TO ME BY THE DEALERSHIP AND EVEN THE PREVIOUS OWNER OF THE TRUCK THAT KNEW OF A PROBLEM AND DID NOT DISCLOSE IT TO ME. SO MY TRUCK WILL SIT UNTIL I DECIDE WHAT TO DO, AS I MAKE MONTHLY CAR AND INSURANCE PAYMENTS ON IT. *NM