2020 FORD F-150 Complaints

The contact owns a 2020 Ford F150. The contact stated while parking he noticed smoke coming from the front to the vehicle, when the contact checked under the vehicle, he noticed that the plastic cover under the engine was detached and had leaves on it where the smoke was coming from due to it being nearby the exhaust pipe. The contact was able to stop the smoke by pouring water onto the leaves. The vehicle was not diagnosed. The contact sent pictures to the dealer however they have yet to communicate. The manufacturer was not contacted. The failure mileage was 34,590.

The contact owns a 2020 Ford F-150. The contact stated that there was abnormal engine noise intermittently detected. While releasing the accelerator pedal, the noise seized. The vehicle was taken to the dealer who was unable to duplicate the failure but provided fuel treatment. The vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer, Boulevard Ford Lincoln, of 18443 Coastal Hwy, Lewes, DE 19958 who was unable to duplicate the noise. The vehicle was not diagnosed or repaired. While pulling a trailer, the abnormal noise persisted. The manufacturer was contacted and referred to the NHTSA Hotline. The approximate failure mileage was 23,000.

Windshield wiper motors failed during a rain storm. Vehicle has only 10k miles on it, wiper motors were set to medium, went up half way, motor made a grinding noise, then wipers stopped moving in either direction. I am able to push them down manually, and the motor can raise them to about 25% then it begins to grind and they stop advancing again. This stinks an awful lot like the recall on 2021 F-150s for bad wiper motors. I suspect the recall campaign needs to be MUCH larger and include 2020 F-150s as well. This was incredibly dangerous and could have caused a serious accident. I had no front visibility during the storm.

At 20,000 mile my 2020 f150 has a horrific freaking noise coming from the passenger side lower control arm. It was aligned at ford dealership 10,000 miles ago. I did check the nut and bolt to confirm they were tight. It is obvious via witness marks that the bolt is moving and removing the frame powder coating. This noise is ridiculous and I’m concerned it causing further damage.

The contact owns a 2020 Ford F-150. The contact stated that after the horn button was pressed, a crack appeared on the steering wheel. No warning light was illuminated. The vehicle was then taken to a local dealer where it was diagnosed that the driver's side air bag needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 45,000.

Wiper motor is non operational. It has been verified by dealer part is non operational. Non operational wipers put myself and others at risk if there would be visual obscurities that would need to be removed during vehicle operation. The only sign was a loud grinding noise for a few wipes prior to operation ceasing.

Front passenger door will not unlock with key fob or driver door unlock button. Had repaired at Ford house once, currently in again as of 10/3/22

Transmission makes high whining / high pitch noise when accelerating at low speed from 3rd gear all the way to 8th gear (10 speed transmission). It occurs when at low RPM but has also occured when at higher RPM. During this high pitch noise, you can hear from 150ft away and is to the point where if it is constantly happening, windows cannot be down due to piercing noise. Noise can also be heard loud and clear through cab of truck when windows are up. I have real concern this could cause issues down the road on the transmissions longevity and durability. Tis nosie occurs from roughly 15MPH to 55MPH

I purchased my 2020 f150 5.0 4x4 in July 2022, I noticed the transmission having a slight change in shifting that that car salesman reassured me that it’s common with this year and model I took his word for it. Since than the truck and the shifting has gotten gradually worse from shifting to drive and into reverse the truck has slammed into gear on 3 occasions, up shift rough as well as down shift. My 2004 f150 has smoother gears and shifted with ease. I’ve contacted Omeara Ford of Thornton,Co where I purchased the truck from and there saying that they would need to get the truck into do a diagnostic and that their 3 months out. This doesn’t sit with me well as I’ve purchased the power train warranty and service contract and now if my truck brakes down I’m responsible?! I need to feel that my 50k truck is going to last and do what I need to do in order to make a living for myself and my family these 10 speed transmission need to be replaced in all the f150 newer models I am looking into the class action lawsuit

While approaching an intersection at approximately 40 mph, I attempted to stop my truck for a red stop light. Without warning, my brake pedal went to the floor and my truck did not slow down. Thankfully there was no one in front of me and there was no cross traffic as I rolled through the intersection. As I began to analyze the situation, I started repeatedly pumping my brakes but the pedal kept going to the floor and my truck was not slowing. Thankfully it was an open roadway and I was eventually able to put the truck in neutral and coast to a near stop, at which time I realized that I did have minor braking ability, but only at approximately 10 mph or less. Any faster than that and the pedal would go to the floor. Once stopped in a parking lot, I exited my truck and noticed a large amount of brake fluid beneath it. I immediately called for a tow truck and they towed it to my local dealer. They confirmed that the master cylinder had failed, which also caused the brake booster to fail, resulting in the loss of brake fluid and brake pressure. I should note that while repairing the previously mentioned parts, they also found a hole in the left front brake line, which they also replaced. It is not known if the issues are related. I should also note that in my attached photos, the fluid leaks photos were taken in 2 separate locations because employees of the store requested I moved my truck after I initially stopped.