2002 FORD F-150 Complaints

CRASH, FRONT IMPACT, 2002 FORD F150 PICK-UP, 4 DOOR, CREW CAB, LARIT. VECHILE WAS TOTAL LOSS. THE AIR BAG DID NOT DEPLOY. THIS WAS THE ONLY ACCIDENT THIS VECHILE WAS INVOLVED IN. INJURIES. *NM

MANUFACTURER USES FAULTY ELECTRONIC COMPONENT IN VEHICLE IGNITION SYSTEM. NO PART OF SYSTEM PROVIDES FOR INDICATION OF POTENTIAL FAILURE OR COMPLETE FAILURE. ONCE PART FAILS, THE VEHICLE EXPERIENCES RANDOM MISFIRING IN CYCLINDER WHICH CAUSES DAMAGE TO SPARK PLUG THREADS OF ALUMINUM CYLINDER HEAD. EVENTUALLY SPARK PLUG IS BLOWN FROM CYCLINDER HEAD RESULTING IN LOSS OF POWER AND FUNCTION. RESULTING DAMAGE TO ALUMINUM CYLINDER HEAD REQUIRES REPLACEMENT AT COST OF @ $3,000. REPLACEMENT PARTS ARE IDENTICAL TO FAILED PARTS AND POTENTIAL REPEAT FAILURES CONTINUE. NO CORRECTIVE ACTION TO PARTS HAS BEEN REPORTED AND NO IMPROVEMENTS TO VEHICLE SENSING SYSTEM HAVE BEEN MADE. FORD MOTOR COMPANY DISCLAIMS ANY RESPONSIBILITY FOR DAMAGES EXCEPT THOSE COVERED UNDER INITIAL VEHICLE WARRANTY OR THOSE COVERED UNDER EXTENDED WARRANTY. IF WARRANTY DOES NOT COVER FAILURE OF ELECTRICAL COMPONENTS THEN FORD MOTOR COMPANY WILL NOT COVER COLLATERAL DAMAGES ( FAILURE OF CYLINDER HEAD SPARK PLUG THREADS). FORD MOTOR COMPANY PUBLISHED INTERNAL TECHNICAL SERVICE BULLETIN TO REPAIR FACILITIES THAT REQUIRES USE OF OSCILLISCOPE TO DETERMINE IF ELECTRICAL PART IS EXPERIENCING PROBLEM. FORD REPAIR FACILITY REFUSED TO RETURN DAMAGED CYLINDER HEAD AND FAULTY COIL-ON-PLUG ASSEMBLY STATING THAT THEY WERE REQUIRED CORE RETURNS. *NM

ON 12-29-2005 HEARD TAPPING NOISE COMING FROM ENGINE OF 2002 FORD F-150 HARLEY DAVIDSON. AFTER ACCELERATING FROM INTERSECTION NEAR HOME, I HEARD A LARGE BANG AND TRUCK LOST POWER. IMMEDIATELY PULLED TRUCK OVER AND HAD IT AAA TOWED TO LOCAL FORD DEALERSHIP. FORD DIAGNOSED THE TRUCK AND ACCORDING TO THE FORD SERVICE ADVISOR, #6 SPARK PLUG BLEW, CAUSING DAMAGE TO LEFT CYLINDER HEAD. APPROXIMATE DAMAGE REPAIR $3800.00. TRUCK ONLY HAD 57,000 MILES. *JB

DT*: THE CONSUMER STATED THE WINDSHIELD WIPERS AND RADIO WORK INTERMITTENTLY. THE DOME LIGHT REMAINED ILLUMINATED. THE WIPERS AND THE RADIO COME ON FOR A FEW MINUTES AND THEN STOP WORKING. THE WINDSHIELD WIPERS COME ON INTERMITTENTLY WITH THE SWITCH IN THE OFF POSITION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. *JB

DT*: THE CONTACT STATED WHEN THE CRUISE CONTROL WAS ACTIVATED THE VEHICLE ACCELERATED BEYOND THE SET SPEED. THE CONTACT PLACED THE VEHICLE INTO NEUTRAL AND COASTED WHILE ATTEMPTING TO TURN OFF THE CRUISE CONTROL SWITCH. AFTER NUMEROUS ATTEMPTS THE CRUISE CONTROL WAS DEACTIVATED, AND THE CRUISE CONTROL LIGHT INTERMITTENTLY ILLUMINATED. PRIOR TO THE INCIDENT THE CONTACT RECEIVED NHTSA RECALL 05V388000, REGARDING THE VEHICLE SPEED CONTROL. HOWEVER, THE RECALL WORK WAS NOT PERFORMED. THE RECALL REMEDY ADVISOR URGED THE CONTACT TO HAVE THE VEHICLE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED OR REPLACED. THE CONTACT BELIEVED THE RECALL REMEDY SHOULD ALSO INCLUDE REPLACEMENT OF THE MASTER CYLINDER. *AK

2002 F 150 V 4.2L V6 ENGINE. 83000 MILES HAS DEFECTIVE INTAKE MANIFOLD GASKET THAT CAN CAUSE LEAK OF COOLANT INTO CYLINDERS CAUSING ENGINE TO BLOW UP POSSIBLY CAUSING CAR TO BECOME UNCONTROLLABLE CAUSING A SERIOUS ACCIDENT. FORD HAS NO PLANS DESPITE RECEIVING NUMEROUS COMPLAINTS. *JB

WITHOUT NOTICE THE POWER STEERING LET GO ON MY TRUCK RESULTING IN THE UNIT LEAKING OUT 6 BOTTLES WERE REPLACED IN THE RESERVOIR AND CONTINUED TO LEAK ONTO THE GROUND. *NM

I WAS ADVISED BY FORD IN SEPTEMBER 2005 THAT MY 2002 F-150 TRUCK WAS INVOLVED IN THE SPEED CONTROL DEACTIVATION SWITCH RECALL AND INSTRUCTED TO REPORT TO MY DEALER FOR ASSISTANCE WHICH I DID. MY CRUISE CONTROL WAS DISABLED (WIRE CUT) BY THE DEALER AND TOLD THAT THE REPLACEMENT PART WOULD BE AVAILABLE BY NOVEMBER 2005. IT IS NOW JANUARY 2006 AND THE DEALER REPORTS THAT THEY DON'T KNOW WHEN THE REPLACEMENT PART WILL BE AVAILABE (FORD SAYS IT MAY BE FEBRUARY). MY COMPLAINT IS THAT I AM SUFFERING A LOSS OF USE BENIFIT FROM FORD'S DEFECTIVE EQUIPMENT FOR FIVE (5) MONTHS AND COUNTING AND THIS IS NOT FAIR OR RIGHT! *NM

ON SEPT 22,2005 MY 2002 FORD F150 BURST INTO FLAMES IN MY CARPORT WHILE I WAS SLEEPING. MY DAUGHTER CAME HOME AND WOKE ME JUST IN TIME TO GET OUT OF THE HOUSE BEFORE THE ENTIRE HOUSE BURNED. I RECEIVED THE RECALL NOTICE JUST A FEW DAYS AFTER THE FIRE. THE FIRE WAS WITNESSED TO START IN MY TRUCK. THE TRUCK WAS SO SEVERELY BURNED THAT SEVERAL INVESTIGATORS REPORTED THIS WAS TYPICAL OF WHAT THEY WHERE EXPERIENCING WITH FORD FIRES ALTHOUGH FORD'S INVESTIGATORS REPORTED THE CRUISE SWITCH WAS PROPERLY FUNCTIONING ACCORDING TO AN X-RAY OF THE PART. HOW THE PART COULD BE FOUND IS A MYSTERY SINCE THE TRUCK WAS SO DAMAGED. FORD IS NOT TAKING RESPONSIBILITY FOR ANYTHING. WE LOST EVERYTHING WE OWNED. *JB

DT: THE CONTACT STATED THE CABLE HOLDING THE SPARE TIRE SNAPPED. THE TIRE BOUNCED ON THE ROAD. THE VEHICLE WAS REPAIRED. *AK UPDATED 1/19/2006 - THE CONSUMER HAS THE FAILED CABLE IN HIS POSSESSION. THERE WERE NO INJURIES AND NO DAMAGE. *NM