2020 FORD F-150 Complaints

Transmission clunks randomly in various situations that are unpredictable. It will occasionally slam itself into a gear which is obviously creating an unsafe situation, especially when towing. Other times it can't figure out which gear it wants, creating yet more unsafe situations, especially when towing. Fuel mileage is excessive even for a pickup truck. After scanning with BlueDriver, fuel trim numbers are significantly out of range causing excessive fuel consumption and lack of power.

The contact owns a 2020 Ford F-150. The contact stated that the vehicle was parked due to an unknown electrical door lock malfunction. Additionally, the contact stated that the vehicle would inadvertently roll forward while stopped without input from the driver. The contact depressed the brake pedal to stop the vehicle. The contact stated that the failure recurred while the vehicle was stopped and the gear shifter was in park(P). The contact stated that after exiting the vehicle, the vehicle rolled forward, struck, and ran over a passenger before coming to a stop. The passenger suffered head injuries and sought medical attention. A police report was not filed. The vehicle was taken to an independent mechanic and diagnosed with a defective gear shift indicator. The contact was informed that the gear shift indicator needed to be replaced. The contact was unsure if the vehicle was repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,000.

This safety problem has happened twice in the last 3 months without warning. There are no check engine or service lights on of any kind. I was operating my vehicle on paved city roads driving at normal pace for the conditions. First time this incident happened I was driving approximately 25 mph beginning to scrub speed for a stoplight. Without warning the vehicle shutoff and had no power to anything. The warning on the dash said put vehicle in park to restart. I had to park on a 45mph road with traffic and no shoulder to restart my vehicle. After this first incident I took my vehicle to the dealership and they were unable to find anything wrong. The second time this same incident happened was yesterday 5/4/22. I was turning right at approximately 10-12mph and vehicle shutoff without warning. Lost power to all systems. I had to again park the vehicle on a busy road abruptly to restart, only after having to place vehicle in park. Pending visit to dealership on Monday 5/9/22. Ford has also been contacted and incidents documented.

When at a stop sign, with the auto start stop engaged, I went to accelerate and the engine stalled with the following message of "auto start stop shift to P, then restart engine". This was extremely dangerous and a safety issue that Ford needs to fix. I was in the middle of an intersection and thankful no other vehicles approaching. I had to shift to Park, turn ignition switch off and restart engine. Vary concerning in driving this vehicle anymore!

While towing and in cruise control transmission shifts erratically and will not upshift out of lower gears unless done manually. Clunks going into some gears and while downshifting

MY WIFE AND I WERE STOPPED AT A STOPLIGHT IN HOT SPRINGS ARKANSAS ON MARCH 8, 2022. ANOTHER VECHICLE RAN INTO US ALMOST HEAD ON AT AN ESTIMATED 30 MPH. THERE WAS CONSIDERABLE DAMAGE TO THE FRONT END OF OUR TRUCK. THE AIR BAGS DID NOT DEPLOY. WE WERE TAKEN TO THE HOSPITAL. MY WIFE HAS SOME BROKEN BONES IN HER BACK AND HAS EXPERIENCED SIGNIFICANT PAIN SINCE THE ACCIDENT.

Right rear axel snapped just at the outside of the axel bearing The vehicle felt like it was shaking for about 4 seconds, at the same time the following warnings appeared, Antilock Brake Fault, Hill Start Assist Warning, Tire Pressure Warning, Hill decent control fault, Pre Collision Assist Not Available. The vehicle was traveling on I-293 left lane at high way speed, cruise control set. The vehicle tilted and made a near 90degree turn to the right heading towards the MerriMack River, Manchester NH. Poor steering control almost zero, brakes failed, shifted auto trans to lowest gear. Aimed for snow wind row to stop or reduce speed. came to rest at the right lane separation zone for ramp @ 6.3 mile marker. Towed to LondonDerry Ford, Londonderry NH Vehicle inspected by State Farm Insurance for body damage unable to see underside damage except snapped axel. Inspected by by Londonderry Ford for underside damage. Vehicle body damage set at an estimated 11,731. Front wall of bed box all rivets snapped. Accident Date 06 Feb. 2022 @ 07:30 vehicle mileage at time 10,672 vehicle date in service 27 Feb 2021 Filed complaint with Ford #CAS35691689 Carrie at Ford Factory claims spec. 8665676518 ext.76792. I inspected the axel at the break point on both halfs, judging from visual inspection and photo enlargement the axel appears to be a poor casting with a discoloration in the center pock marks over aprox. 80% of the face area of the break. The road conditions were dry and clear, straight road, snow plow row to right, traffic light. All lug nuts tight and in place. ** I believe it is note worthy that Ford is taking responsibility by running axel failure through Warranty and body damage through General Council. They refuse to place this in writing, they are also urging that I let them run it through Sate Lemon Law, to me it sounds like they want to hide it. Another exact same failure at AutoFair Ford Manchester NH as of 3/31/2022 sounds fishy to me. ,

The contact owns a 2020 Ford F-150. The contact stated while driving approximately 40 MPH, there was an abnormally loud sound coming from the vehicle. There were no warning lights illuminated. The contact later became aware that the panoramic sunroof had exploded causing the abnormal sound. The vehicle was taken to the local dealer; however, the cause of the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 22,025.

Truck turned over but display was blank and all gauges read off. Front windows would not roll down. The check manual(wrench) was indicated on the DIC. Truck had been shifting strangely for a few days and it’s performance seems diminished. Will be checked at dealer. Battery checked and no problems nor loose cables found.

Ii stopped at a stop sign and the auto stop feature engaged. As I began to pull out the engines started and then stalled. I received an error message in the message center above the steering wheel, it said “AUTO STOP START SHIFT TO P THE RESTART THE ENGINE”. Fortunately it was a secondary road. There was a car coming but I was able to coast to the side of the road, activate my flashers before he arrived. I put the vehicle in park and was able to restart the engine without a problem. It did not happen again.