2021 FORD F-150 Complaints

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, there was an abnormal sound coming from the rear end of the vehicle. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the hub nut was fractured. The dealer replaced the hub nut and the rear axle and informed the contact that the repair was temporary. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 40,000. VIN tool confirms parts not available.

The vehicle will occasionally freeze on the infotainment splash screen. This prevents the rear view camera from activating when the vehicle is in reverse. Furthermore, the vehicle has already been serviced for a prior issue where the infotainment system (and rear view camera video) would momentarily freeze (1-4 seconds) when the camera was activated

High-speed highway travel this morning. Switched lanes and pressed accelerator; engine cut out. Seemed to be in no gear for 6-9 seconds before lurching into power again. Incident was very dangerous and forced a rapid slowing in fast lane affecting traffic behind me. This has happened 4 times in the past 8 months.

The contact owns a 2021 Ford F-150. The contact stated that the brake power booster was emitting a hissing sound when the brake pedal was being depressed. The contact used an excessive amount of pressure to depress the brake pedal. The ABS warning light was illuminated but deactivated independently. The vehicle was taken to the dealer, but the cause of the failure was not determined. The dealer confirmed that the failure was related to NHTSA Campaign Number: 21V533000 (Service Brakes, Hydraulic) however, the VIN was not included. The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not included in the recall. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 28,000.

My windshield wipers stopped working. It seems the wiper motor still kicks on and I can hear it move, but the wipers don’t move and are stuck. It’s almost as if the wipers are off track or something. Once my vehicle was stopped, I was able to move the wipers back down, but it won’t move after that. I can still hear the motor turning on though.

The contact owns a 2021 Ford F-150. The contact stated that while driving 65 MPH, several unknown warning lights were illuminated on the instrument panel and then turned off independently. The instrument panel then failed to operate as designed. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 57,000.

The on board generator auxiliary fails to work because of "ground fault". Complaint to dealer (McDonald Ford, Freeland, MI) who stated has been receiving numerous complaints of this failure but has no remedy nor direction from Ford. This has been a continuous problem for the last few months.

F150 is experiencing interior leaking from the windshield and other areas that Ford is unable to identify the cause. This can cause visibility issues and damage to electrical components resulting in a safety issue. The leaking causes the floor mats to be wet, which have also caused my foot to slip off the control petals. This could cause an accident. Ford is not able to identify the source, they were able to reproduce the leaks in the firewall but can't identify the source. Ford doesn't acknowledge this is a major issue and has only offered to caulk and seal in the most common areas. It was in the shop for four days March 25-27 and 22-23 2024. There are no warning issues just went floor mats and visible water on the interior of my windshield which I demonstrate to the dealership.

Tail lamp assembly both sides, allowing moisture within the lighting assembly potentially resulting in short circuit or fire if water comes in contact with electrical connections.

OBDii reader which connect to vehicle ECM reads perfectly independently, however when connected to a state emissions inspection machine, machine indicates no vehicle information available and results in failures due to ECM not responsive. Ford says it is a known issue but will not replace ecm unless recall is issued.