2021 FORD F-150 Complaints

While driving my truck, I attempted a merge onto interstate 80, and completely lost power. I was accelerating to merge, and when the transmission shifted the truck lost all power. This is a dangerous situation and should be addressed. I cannot believe that nothing is being done about the issue, and Ford knows about this, as my local dealership is months out on transmission repairs.. It would sure be great if the agency responsible for forcing a recall would work for us..

The contact owns a 2021 Ford F-150. The contact stated that while driving in the rain at an undisclosed speed, the windshield wipers became inoperable. The vehicle was taken to the dealer, where it was determined that the windshield wipers motor needed to be replaced. The dealer informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 22V842000 (Visibility) because the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 85,000.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V509000 (Parking Brake) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

It started with the loss of Sirius, then intermittently maps, and now the radio is gone and my display on my dash goes black and restarts. I will be driving down the road (interstate) and all of my dash disappears. No speedometer at all. The APIM is out and Ford has no APIM's available. I took it to local Ford and they confirmed the APIM was out. It controls the whole truck and weird things have happened. Locks, seating changing, steering wheel changes. There is a case opened with Ford but apparently no timeline on fix.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V842000 (Visibility) and the vehicle was repaired; however, prior to the repair, the windshield wipers operated erratically, damaging the wiper blades and left a 2-inch streak across the windshield, causing an issue with visibility while driving. The vehicle was diagnosed but was not repaired due to the cost. The manufacturer was made aware of the failure. The contact stated that the wiper blades were not included in the NHTSA Campaign Number: 22V842000 (Visibility) repair. The failure mileage was 54,556.

Passenger side rear axle retainer bolt sheared off. My vehicle was manufactured 20 days after the existing recall. Repair was done under warranty but obviously should be included as part of the recall.

When moving the shift lever from Drive to Reverse, and physically feeling the two detents from Drive, through Neutral, and into Reverse, intermittently the shift lever will still indicate Neural and the vehicle will stay in Neutral even after two physical detents have been felt (i.e. the truck should indicate and be in Reverse after two physical detents). The truck and shift lever will stay in Neutral even after I remove my hand from the shift lever. The truck will only engage reverse after physically pressing the shift lever further forward within the physical Reverse detent area. There were no warnings on the dash and no trouble codes present within the system. The vehicle is available for inspection, and a video is available, however it is intermittently operating in this manner. When performing a 3-point turn on a roadway, this has led me to believe that my vehicle was engaged in Reverse, but it was in fact not, but in Neutral. This has introduced significant delay in what would otherwise be a safe maneuver and has put me and my occupants safety at risk. The local Ford dealership has updated the shift software, but it has continued to operate this same way intermittently. I have demonstrated this to the dealership service advisor and shown a video to the shop foreman, however the dealership is unwilling to replace the shifter because there is no trouble code. The vehicle has not been inspected by anyone other than the local Ford dealership.

The contact owns a 2021 Ford F-150. The contact stated while the vehicle was at the dealer for tire rotation services, the dealer informed his wife that the rear passenger's side axle bolt was fractured and was stuck inside the hub of the wheel. The dealer determined that the rear passenger's side axle needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.

--Exhaust leak, at left first band clamp downstream from catalyst --Safety is of immediate concern due to exhaust leak directly under driver seat --Local Ford dealership service dept did not fix leak --Exhaust leak was inspected and reported to local Ford dealer service dept- NOT fixed On 20 November 2023, I purchased a 2021 Ford F-150 XL, VIN: [XXX] , from Crain Ford of Jacksonville, Arkansas, 1800 School Drive, Jacksonville, Arkansas 72076. Phone 501-436-4981. After driving the vehicle for a day, I noticed a fluid leak on my garage floor under the vehicle’s engine area. On 21 November 2023, I took the vehicle to the dealership, which I bought the truck from, Crain Ford or Jacksonville, AR. They inspected the underside and found no leaks and suggested I just keep an eye out for any fluid leaks. The next week I kept watching for leaks, and each day I saw what appeared to be a fluid leak of some type or fluid on the floor of my garage. On 27 November 2023, I took the vehicle back t o the same dealership, Crain Ford, and I showed them a video of the leak I discovered. The video can be viewed at: [XXX] As the video shows, upon cold startup of the vehicle, you can see water leaking from the band clamp on the exhaust system just below the left catalyst. I fully understand that the fluid is water and is a byproduct of the combustion system and is normal. That is NOT the problem, the problem is, if water can leak out at the band clamp on the exhaust system, as shown, then so can deadly exhaust fumes right under the driver area. I showed the video to the Ford service dept foreman and he had a technician check the exhaust and assured me that the band clamps were at factory spec torque and they could smell or observe no leaks. I took the vehicle home. The next morning, there is still a deadly exhaust leak occurring at the band clamp on the exhaust pipe as I can see water dripping out, just as the first video showed INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Broken Right Rear Axle bolt, F150 with ~37500 mileage, Max tow Package, Already identified by FORD customer "satisfaction" Program 22B34