2002 FORD F-150 Complaints

THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION AND THE AIR BAGS FAILED TO DEPLOY, CONSUMER WAS INJURED.*JB

ENGINE MISFIRES IN COLD WEATHER WHILE DRIVING CAUSING SERIOUS LOSS OF POWER FIRST STARTED AT 341 MILES AND CONTINUES TO DATE.*JB

THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND THE AIR BAGS FAILED TO DEPLOY. *JB *TS

BOTH LOCKING PAWLS ON MANUAL SEAT ADJUSTMENT MECHANISM DO NOT LOCK INTO PLACE WHEN SEAT ADJUSTMENT LEVER IS RELEASED. ONE OR THE OTHER PAWL LOCKS INTO PLACE AND A LARGE AMOUNT OF SHIFTING FORCE IS THEN REQUIRED TO MOVE THE SECOND PAWL INTO A POSITION WHERE IT WILL ENGAGE. THIS WOULD ONLY BE A MINOR INCONVENIENCE IF IT WERE NOT FOR THE SEAT BELT CONFIGURATION OF THIS VEHICLE. THIS SEAT BELT ATTACHES NOT TO THE SUB FLOOR OR PILLAR BUT TO THE SEAT ITSELF. IF (AS HAS HAPPENED MANY TIMES TO ME) YOU ARE UNDER WAY AND REPOSITION THE SEAT, YOU MAY NOT REALIZE THE SEAT IS NOT SAFELY LOCKED INTO POSITION. IF YOU WERE THEN INVOLVED IN AN ACCIDENT THE STRAIN ON THE ENGAGED PAWL MIGHT BE BEYOND DESIGN PARAMETERS. WHEN THE UNENGAGED PAWL, TRAVELING TO ITS NEXT LOCKED POSITION UNDER THE FORCES OF THE ACCIDENT, MEET THE MASS OF THE OCCUPANT AND SEAT, THE SHEAR FORCES MAY CAUSE FAILURE OF THE PAWL ALLOWING THE OCCUPANT AND HIS /HER SEAT TO BE UNCONTROLLED DURING AN ACCIDENT. THIS COULD RESULT IN UNNECESSARY INJURY TO THE OCCUPANT. AN AIR BAG SRS COULD EXACERBATE THIS CIRCUMSTANCE CAUSING ESCALATING INJURY(S).

CONSUMER COMPLAINED ABOUT THE PITMAN ARM ON THE VEHICLE. ALSO STATED THAT WHILE DRIVING THE VEHICLE THE PITMAN ARM FELL OFF WHICH IT CAUSED COMPLETELY LOST OF STEERING AND THE CONSUMER HIT ANOTHER VEHICLE ON THE HIGHWAY WAS CONTACTED AND HAS AGREED THAT THERE WAS NO BOLT PUT INTO THE PART THAT FELL OFF BUT THERE STILL NOT DOING NOTHING ABOUT IT. TS PHOTOS ATTACHED. *TT

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE CHAISE ON THE VEHICLE. ALSO STATED THAT DEALER WAS CONTACTED AND HAS AGREE THAT THERE IS A PROBLEM WITH THE VEHICLE BUT WONT TAKE IT IN UNTIL AFTER JANUARY THE 2ND. TS

WHILE AT HIGH SPEED VEHICLE VIBRATES AND PULLS TO THE RIGHT. CONSUMER TOOK TO THE DEALER AND THEY REPLACED THE DRIVESHAFT. PROBLEM WAS STILL PRESENT. TS THE WHEELS AND TIRES WERE ALSO CHANGED BUT TO NO AVAIL. *JG

VERY SERIOUS FAILURE!!! WHILE BACKING UP A STEEP HILL IN 4WD. THE TRUCK'S PITMAN ARM CAME COMPLETELY OFF OF THE SPLINED SHAFT THAT COMES OUT OF THE STEERING BOX. SO, THERE WAS NO LONGER ANY CONNECTION BETWEEN THE STEERING WHEEL AND THE FRONT WHEELS. THE RETAINING NUT AND LOCK WASHER CAME OFF, TOO, AND WERE RECOVERED. THE LOCK WASHER IS OF THE HELICAL SPRING TYPE, AND HAS A BLACK OXIDE FINISH. BECAUSE OF THIS FINISH, IT IS EASY TO DEDUCE FROM THE WEAR MARKS ON THE WASHER. THAT THE RETAINING NUT WAS NOT TORQUED AT THE FACTORY. LUCKILY THIS FAILURE OCCURRED AT ALMOST ZERO SPEED IN A DRIVEWAY. CLEARLY, HAD IT OCCURRED AT FREEWAY SPEED (WHICH IS WHERE THE TRUCK WOULD HAVE BEEN 2 MILES LATER), THE RESULTS COULD HAVE BEEN CATASTROPHIC. THE OWNER OF THIS CAR, WOODY PORTER, IS MY FATHER-IN-LAW. I WAS DRIVING IT AT THE TIME OF THE FAILURE, AND FILLED OUT THIS FORM FOR HIM WITH HIS PERMISSION. IF YOU HAVE ANY QUESTIONS, YOU MY CONTACT ME, JOHN GUNTHER, AT 650-802-8384. THANKS. DT

WAS DRIVING DOWN THE ROAD THE STEERING WHEEL JERKED TO THE RIGHT COULD NOT GAIN CONTROL BACK. THERE IS ONE SKID MARK 35 FEET LONG HIT AN ELECTRIC POLE WHEN CAME TO REST THE BACK PASSENGER TIRE HAD BROKE OFF AT THE AXEL. DT

WHILE DRIVING THE VEHICLE IN REVERSE, TO PARK THE VEHICLE SUFFERED SUDDEN ACCELERATION WHEN SHIFTED FROM DRIVER INTO REVERSE VEHICLE COLLIDED WITH ANOTHER CAR CAUSING DAMAGE TO HIS VEHICLE AND OTHER CAR. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURRTHER INFORMATION. TS