2021 FORD F-150 Complaints

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) however, the part to do the recall repair was not yet available. The contact stated upon parking the vehicle, he noticed that the underbody heat and noise insulators had detached and was hanging on the ground. The vehicle was taken to the dealer who informed the contact that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and a case was opened. The vehicle was not repaired. The failure mileage was approximately 7,000. VIN tool confirms parts not available.

The windshield wiper arms are defective as pieces of metal from the splines have come off and I do have them. I asked the dealership to check it when I had the last recall and oil change and evidently they did not even check it. I called Ford customer service today and the customer service rep said that my particular vehicle was not covered under the recall as it did not apply. Evidently they don't understand that there are more vehicles with the problem as mine is very evident. Consumer's vehicle was not part of the recall as they did see and have the parts that have fallen out of the wiper arms. They said that they can replace it under warranty but are not able to get the parts as they are going to the recall vehicles.

My truck was parked in my driveway when i noticed a slight bulge like curve in my rear window. When I opened the door the rear window completely shattered. My local Ford dealership confirmed that the Ford f150's have had this problem for years. They sent pictures to Ford about covering the replacement of the window. Ford refused

Have had squeeking breaks since receiving the truck a year ago. Brought in and was told to watch for a letter they don't have the part that my breaks are safe but the squeeking has gotten a lot worse. Also the dash board lights turn on and off when the car is off. The other day driving at speed on the expressway the whole dash board turned off all gages went to zero than rebooted. I was coasting trying to figure out what was happening so not sure if I lost power. 3 faults were sent to my phone. Restraint fault abs fault and tire pressure fault all showed up.

The center retaining bolt on the rear 9.75” 3/4 floating locker axle sheared off after only a few thousand miles, requiring an axle replacement.

Seal - Valve - Ford (KL3Z-9U465-A) I have the same engine that is failing in all of the new Ford Broncos - Ford's 2.7L V6 2nd Generation, however, I have this engine in an F-150. My vehicle has been sitting at the dealership for over a month, diagnosed with a faulty valve (same issue that is in the broncos) Seal - Valve - Ford (KL3Z-9U465-A) Something needs to be done about this - Ford has offered me no loaner or rental vehicle AND I am still paying car payments while it is sitting up there at Ford! Help

The contact owns a 2021 Ford F-150. The contact stated that while driving approximately 55 MPH in a rainstorm, the front windshield wipers became inoperable, causing a visibility hazard for the driver. The vehicle was taken to the local dealer who diagnosed that the wiper motors were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the vehicle was not included in the NHTSA Campaign Number: 22V250000 (Visibility). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 17,250.

The contact owns a 2021 Ford F150. The contact had received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated while driving 65 MPH in the rain, the front windshield wipers became inoperable. The contact stated no warning light was illuminated. The contact took the vehicle to local dealer, where it was diagnosed with needing the windshield wiper motor and the blades to be replaced. The dealer replaced the blades but the windshield wiper motor parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 15,400.

The bolt that secures the hub to the semi float axle shaft sheared on the rear passenger side. At this point, the only thing holding the wheel/hub assembly on the truck is spline friction and brake caliper. I discovered the issue today during a tire rotation, but based on the condition of the bolt it appears that the bolt has been sheared for some time--possibly from the factory. More owners reporting the issue here: https://www.f150forum.com/f129/2021-powerboost-rear-rotor-axle-bolt-sheared-515460/

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) and 22V193000 (Electrical System) however, the parts to do the recall repairs were not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact had not experienced a failure. VIN tool confirms parts not available on NHTSA Campaign Number: 21V986000. Parts distribution disconnect on NHTSA Campaign Number: 22V193000.