2006 FORD F-250 Complaints

DRIVING ALONG AT ABOUT 45 MPH, HIT A ROUGH PATCH OF PAVEMENT AND THE FRONT END OF THE TRUCK BEGAN TO BOUNCE AND THE STEERING WHEEL BEGAN TO OSCILLATE BACK AND FORTH, ALTHOUGH THE TRUCK DID NOT GO LEFT OR RIGHT FROM THE LINE OF TRAVEL. AFTER SLOWING DOWN THE TRUCK CAME BACK UNDER MY CONTROL, BOUNCE AND OSCILLATION STOPPED. THIS HAS HAPPENED NUMEROUS TIMES (WEEKLY), WITH THE ORIGINAL TIRES AND WITH REPLACEMENT TIRES. I HAVE HAD THE FRONT END ALIGNED AND TIRES BALANCED. I CHECK THE AIR PRESSURE WEEKLY. ALL OF THIS HAD NO AFFECT ON THE OSCILLATIONS. I WOULD DRIVE OVER THE SAME AREAS DAILY ANDCOULD CONTINUE TO REPEAT WHAT HAD HAPPENED BY DRIVING THE SAME SPEED OVER THE SAME PIECE OF BAD PAVEMENT. IT IS NO WORSE OR BETTER THAN WHEN IT FIRST HAPPENED. BUT HAVING MY WIFE DRIVE THE TRUCK AND HAVE THE SAME ISSUE CONCERNED ME. I DID RESEARCH THAT LED ME TO FIND OUT THAT THIS IS A PROBLEM AFFECTS NUMEROUS F-250S AND TO YOUR WEBSITE. I WISH I HAD COMPLAINED ABOUT THIS WHEN IT BEGAN, BUT MY TRUCK WAS OUT OF WARRANTY AND I THOUGHT I WAS OUT OF LUCK (STILL MAY BE). *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT WAS DRIVING 20 -30 MPH ON A WET SURFACE. THE BRAKES WERE APPLIED LIGHTLY AND THE VEHICLE HYDRO-PLANED AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY AND THE CONTACTED WAS THROWN INTO THE REAR OF THE VEHICLE WITH THE SEAT BELT RESTRAINED ACROSS HIM. HE SUFFERED INJURIES TO HIS ENTIRE BODY AND WAS TAKEN TO THE HOSPITAL. THE POLICE WERE CALLED AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND THE INSURANCE COMPANY WAS NOTIFIED. THE MANUFACTURER WAS NOTIFIED AND A CLAIM WAS FILED. THE FAILURE MILEAGE WAS 115,000.

VIOLENT SHAKING/ VIBRATIONS @ HIGHWAY SPEEDS. I PULLED OVER TO COMPLETE STOP, WAITED, STARTED UP AND VIBRATION STOPPED. THIS HAS HAPPENED ON 3 OCCASIONS SINCE. *TR

DRIVING MY 2006 FORD F250 SUPER DUTY CREW CAB 4X4 AT HIGHWAY SPEED OF 70 MPH THE TRUCKS FRONT END BEGAN TO VIBRATE AND BOUNCE UNCONTROLLABLY AFTER GOING OVER AN UNEVEN SECTION OF BRIDGE. THE VIBRATION WAS SO BAD I THOUGHT THE FRONT END OF THE TRUCK WAS GOING TO TEAR ITSELF APART. AS I BEGAN TO SLOW THE TRUCK DOWN AND GET OUT OF THE NORMAL TRAFFIC LANES THE VIBRATION AND BOUNCING DID NOT FINALLY SUBSIDE UNTIL ABOUT 35 MPH. WHILE THIS OCCURRED WITH MY ENTIRE FAMILY IN THE TRUCK I WAS FEARFUL OF WHAT MAY HAPPEN AND WHEN IT MAY HAPPEN AGAIN AS WE WERE STILL SEVERAL HOURS FROM OUR HOME. A FEW MILES LATER WE CROSSED ANOTHER BRIDGE THIS TIME DOING 65 MPH AND THE FRONT END BEGAN TO VIBRATE AGAIN BUT STOPPED MUCH QUICKER THAN BEFORE ONCE I DECREASED TO 45MPH. THIS ISSUE IS RAMPANT ON THE VEHICLE REPORTING WEBSITES AND WILL EVENTUALLY GET SOMEONE KILLED. I PRAY FORD DECIDES TO FINALLY INVESTIGATE AND OFFER SOME FACTUAL EVIDENCE AND A PERMANENT SOLUTION TO THE PROBLEM SO MANY DRIVERS ARE EXPERIENCE WITH THESE TRUCKS.I LOVE MY FORD TRUCK BUT NOT AT THE COST OF LOSING MY LIFE OR CAUSE INJURY TO SOMEONE ELSE. *TR

THE RETAINING NUT SECURING THE TPMS SENSOR TO THE VALVE STEM DETACHED WHILE ADDING AIR TO A TIRE. THIS CLAIM IS BEING FILED BY OIL CHANGER, INC. ON BEHALF OF CELL-CRETE, A FLEET CUSTOMER OF OURS. A NEW TPMS SENSOR HAD TO BE INSTALLED. *TR

2006 F-250 SD 6.0 DIESEL ENGINE. A FUEL LEAK ONTO THE ENGINE DEVELOPED DUE TO A DEGRADED O-RING WHERE THE FUEL PRESSURE REGULATOR ASSEMBLY ATTACHES TO THE ENGINE MOUNTED FUEL FILTER. THE LEAKAGE WAS ESTIMATED AT 6 DROPS PER MINUTE WHEN THE ENGINE WAS RUNNING. THE HOUSING AND O-RING ARE SUBJECT TO APPROXIMATELY 45 PSIG AND ARE ON THE UPPER SECTION OF THE ENGINE. THE LEAK WAS DETECTED DUE TO STRONG ODOR OF UNBURNED DIESEL FUMES COMING IN THE HVAC SYSTEM WHEN STOPPED AT A LIGHT AND AT THE FRONT EXTERIOR OF THE TRUCK JUST AFTER SHUTTING THE ENGINE OFF. THE DEALER STATED AND MY OWN RESEARCH ON INTERNET FORUMNS INDICATED THIS IS A COMMON ISSUE. UNDER THE WRONG CIRCUMSTANCES THIS COULD BE A FIRE HAZARD AND AT BEST IS AN ISSUE WITH ENVIRONMENTAL IMPACT TO SOME DEGREE. THE DEALER IS MAKING THIS REPAIR AT MY EXPENSE. *KB

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 70 MPH OVER SMALL ROAD BUMPS, HE LOST CONTROL OF THE STEERING. THE VEHICLE BEGAN TO VIOLENTLY SHAKE UNTIL THE CONTACT STOPPED THE VEHICLE. THE FAILURE RECURRED WHENEVER THE CONTACT DROVE OVER ROAD BUMPS AT HIGHWAY SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS A COMMON OCCURRENCE. THE STEERING LINKAGES AND STEERING DAMPENER WERE REPAIRED. THE FAILURE RECURRED ONCE FOLLOWING REPAIRS. THE FAILURE MILEAGE WAS 43,200. UPDATED 10/13/11 *BF UPDATED 01/12/12

WHILE TRAVELING ON VACATION WITH A TRAVEL TRAILER IN TOW, THE TEMPERATURE GAUGE ON OUR 2006 FORD-F-250 (WITH A 5.4 LITER ENGINE) INDICATED THE ENGINE WAS OVERHEATING. AFTER STOPPING SEVERAL TIMES ON THE BERM OF AN INTERSTATE, THERE WAS NO INDICATION THAT THE ENGINE WAS HOT. SINCE WE WERE TRAVELING ON A HOLIDAY, THE TRUCK WAS FIRST TAKEN TO A PEP BOYS LOCATION WHERE THEIR EVALUATION SHOWED THERE WAS NO SIGN OF OVERHEATING. WE WERE ADVISED OF A SERVICE BULLETIN ISSUED ON THIS VEHICLE STATING THAT IT MIGHT EXHIBIT FALSE OVERHEATING. SO, WE CONTINUED OUR TRIP. TRUCK CONTINUED TO DISPLAY FALSE READINGS AND THE ENGINE STARTED TO DERATE. AT THIS TIME, WE HAD TO HAVE THE TRUCK TOWED TO A FORD DEALERSHIP, WHERE THEY INSTALLED AN UPDATED COOLANT CROSSOVER TUBE AND THERMOSTAT HOUSING TO CORRECT THE PROBLEM OF FALSE OVERHEATING. THIS WORK WAS DONE (PARTS & LABOR) AT A COST TO US OF $645.67 AFTER AAA DISCOUNT. THE COST TO US WAS A SURPRISE, AS THE DEALERSHIP WAS AWARE OF THE PROBLEM AND KNEW EXACTLY WHAT WAS NEEDED TO BE DONE TO RECTIFY IT. WE WERE TOLD THAT THIS KNOWN PROBLEM WAS A SERVICE BULLETIN NOT A RECALL BECAUSE IT IS NOT CONSIDERED A SAFETY ISSUE. HOWEVER, IT WAS VERY MUCH A SAFETY ISSUE FOR US AS WE WERE COMPELLED TO STOP SEVERAL TIMES ON THE SIDE OF A BUSY INTERSTATE BEFORE HAVING TO REQUEST THAT THE PICKUP AND TRAVEL TRAILER BE TOWED TO A SAFE LOCATION.

WHEN DRIVING HIGHWAY SPEEDS I NEVER KNOW WHEN THE FRONT END IS GOING TO VIOLENTLY SHAKE SO BAD THAT I CAN'T SEE OUT THE REAR VIEW MIRRORS TO EVEN KNOW WHO IS AROUND ME WHEN MY TRUCK IS COMPLETELY OUT OF CONTROL. I CAN'T BELIEVE SOMEONE HAS NOT DIED YET! IT'S NOT IF, BUT WHEN. A JOINT IN THE ROAD, POT HOLE, OR JUST A PAVEMENT IRREGULARITY CAUSES IT, BUT I NEVER KNOW WHEN. I'VE ASKED SERVICE AND SALES TECHS AT BOTH PHIL LONG FORD/LITTLETON, CO AND LAKEWOOD FORD/LAKEWOOD, CO AND RECEIVED THE SAME LINE OF CRAP, THAT I'M THE FIRST PERSON WHO EVER MENTIONED IT. CHECK MY TIRE PRESSURE IS WHAT I'M TOLD. ALL I HAD TO DO WAS GOOGLE THE PROBLEM AND I FOUND A SEEMINGLY ENDLESS LIST OF COMPLAINTS OF THE EXACT SAME PROBLEM. THIS SITE WAS ALREADY AWARE OF THE PROBLEM BECAUSE WHEN I WENT TO SELECT THE "FAILED COMPONENTS", STEERING WAS ALREADY HIGHLIGHTED. THIS IS A $50,000 TRUCK I'M AFRAID TO DO THE SPEED LIMIT IN. LOADED OR UNLOADED, PULLING A TRAILER OR NOT, THE PROBLEM CAN PRESENT ITSELF. HOW MANY COMPLAINTS OR DEATHS DOES IT TAKE BEFORE FORD IS HELD RESPONSIBLE FOR THIS DEFECT? *KB

SHIMMY- THE SHIMMY PROBLEM THAT OCCURS IN THE 4X4 F250 SHOULD STILL BE A SIGNIFICANT ISSUE FOR THOSE OF US THAT STILL OWN THESE TRUCKS. THE DEALER TRIED THE TIRE INFLATION STORY WITH ME, BUT THAT DID NOT CORRECT THE PROBLEM. ROAD RACING SPORT CARS FOR MANY YEARS I KNOW THAT ONE POUND CAN MAKE A DIFFERENCE IN HANDLING AND I MADE SURE THAT THE TIRES WERE INFLATED CORRECTLY. THEN THEY TOLD ME THAT FORD SENT THEM A NEW SET OF ALIGNMENT SPECS. WELL AS WE ALL KNOW NOW THAT DID NOT FIX IT EITHER. THEN THEY TOLD ME THAT THE TIRES BEING CUPPED WAS CAUSING THE SHIMMY, MY RESPONSE TO THAT WAS THAT IT WAS THE SHIMMY CAUSING THE TIRES TO CUP NOT THE TIRES BEING CUPPED CAUSING THE SHIMMY, ALTHOUGH THE WORSE THE CUPPING, THE WORSE THE SHIMMY. AFTER INSISTING ON NEW TIRES AND THEN THE NEW LINE UP SPECS, WE TRIED IT AGAIN. THEN 960 MILES LATER AND ONLY ROAD DRIVING THE SAME CUPPING WAS HAPPENING AGAIN. THEN IT WAS THE DAMPENER AND ATTACH POINT THAT WAS THE PROBLEM. THEN 2 YEARS LATER CAME THE LETTER ABOUT DECELERATING AND APPLYING THE BRAKES AND THEN ABOUT 45 MPH IT SHOULD FIX IT. I GUESS THAT WOULD BE OK UNTIL YOUR GOING DOWN THE INTERSTATE AT 70 MPH WITH AN 18 WHEELER BEHIND YOU GOING 70 MPH. WOULD IT BE OK AFTER WHAT COULD BE A SERIOUS AND POSSIBLY FATAL ACCIDENT THAT I COULD PULL OUT MY LETTER THAT I GOT FROM FORD AND TELL EVERYONE, SORRY BUT I DRIVE A FORD. *KB