2006 FORD F-250 Complaints

FIKM, INJECTORS, GLO PLUGS, IPR, HARMONIC BALANCER, PRV LOW OIL PUMP, HIGH OIL PUMP, FUEL FILTERS ALL REPLACED BETWEEN 277,000 AND 290,000 MILES ( 1ST TIME ON INJECTORS AND GLO PLUGS AT 277,000 MILES ON A 6.0L 2006 SUPER DUTY DIESEL)DUE TO LACK OF POWER DURING ACCELERATION BETWEEN 65 AND 75 MPH MORE THAN ONCE! SPENT MORE THAN $3,000.00 TO DATE TO CORRECT THIS ISSUE AND NOTHING HAS WORKED! FORD HAS SOME EXPLAINING TO DO, AND IT HAS BAFFLED EVEN ONE OR MORE OF THEIR BEST MECHANICS, AS WELL AS THE TOW TRUCK PERSON THAT HAD TO TOW IT AT 10:00 PM THIS PAST WEEK! NOW WHO IS RESPONSIBLE????? WE HAVE OWNED THIS TRUCK FROM NEW STATUS TO PRESENT AND YES 290,000 MILES ON A 6.0L DIESEL 2006..SURPRISE! THE VEHICLE WAS IN MOTION WHEN THIS ISSUE HAPPENED.... ON BOTH CITY STREETS AND INTERSTATES, AND IN THE DRIVEWAY WITH EMER. BRAKE ON AND ACCELERATION UP TO 2000 RPM'S AND IT CHUGS AND SPITS AND SPUTTERS AND THEN DIES AND WON'T RESTART UNTIL THE NEXT DAY! I CAN PROVIDE YOU SEVERAL RECEIPTS, BUT I AM NOT PUTTING THEM ONLINE FOR ALL TO VIEW VIN NUMBERS, ETC. ANY INFORMATION WILL BE GREATLY APPRECIATED! ALL THIS TROUBLE HAS GONE ON SINCE APRIL OF 2016 TO PRESENT. MY TRUCK IS A WORK VEHICLE AND HAS BEEN A GOOD ONE UNTIL NOW AND HAS TRAVELLED WELL FOR 10 YEARS OLD AND 290,000 MILES. I AM CURRENTLY STUCK IN GEORGIA TRYING TO FIX THIS ISSUE.

WHILE DRIVING AND GOING OVER A BUMP BETWEEN 60 AND 70 MPH ON THE HIGHWAY, THE TRUCKS FRONT END STARTS TO VIOLENTLY SHAKE CAUSING THE TRUCK TO LOSE CONTROL. NOTE ONLY DRIVING POSTED SPEED LIMIT. THIS HAS HAPPENED ON THREE (3) OCCASIONS MOSTLY RECENTLY 7/17/16 AND 7/19/16 WHILE TRAVELING S/B ON INTERSTATE 95 AND TRAVELING N/B ON INTERSTATE 95. THE DEFECT CAUSES YOU TO DRIVE AT REDUCED SPEEDS ON THE HIGHWAY. HAVE DONE RESEARCH AND IT IS A COMMON PROBLEM WITH FORD TRUCK WITH STRAIGHT FRONT AXLES. FORD IS AWARE OF THE PROBLEM.

I HAVE BF GOODRICH RUGGED TRAIL T/A 275 70 R18 TIRES ON MY 2006 FORD F250 WHICH WERE PURCHASED 25 MONTHS AGO AND HAVE 22000 MILES ON THEM. WHILE TOWING MY TRAVEL TRAILER I EXPERIENCED A SLIGHT VIBRATION WHILE DRIVING. I IMMEDIATELY PULLED OVER AND CHECKED THE VEHICLE AND CAMPER FOR NY VISIBLE SIGNS OF A PROBLEM. EVERYTHING A APPEARED TO BE IN GOOD WORKING ORDER SO I CONTINUED ON DRIVING SLOWER. AFTER ABOUT 10 MILES THE TIRE COMPLETELY BLEW UP DAMAGING MY VEHICLE AND SENDING THE TREAD OF THE TIRE ACROSS THE OTHER LANES TRAFFIC WHICH ALMOST CAUSED A MAJOR VEHICULAR ACCIDENT. I THOUGHT IT WAS BAD LUCK. I CHANGED THE TIRE AND CONTINUED DOWN THE ROAD. AFTER APPROXIMATELY ANOTHER 200 MILES I STARTED GETTING THE SAME VIBRATION FROM THE REAR DRIVERS SIDE TIRE. FEARING ANOTHER BLOW OUT AND HAVING NO SPARE TIRE I PULLED OVER AND SPENT THE NIGHT IN A CAMPGROUND. THE NEXT MORNING I WENT OUT TO GET TIRES AND UPON THE TIRE PERSONAL INSPECTING THE TIRE THEY SAID THAT IT HAD A AIR BUBBLE UNDER THE TREAD AND THAT IT TOO WOULD HAVE MORE THAN LIKELY BLOWN OUT ON ME. I DIDN'T THINK THAT THIS WAS COINCIDENCE ANYMORE. SO UPON GETTING HOME I CALLED BF GOODRICH AND MADE A COMPLAINT. THEN I RESEARCHED THE TIRES AND SAW THAT A BUNCH OF THEM WERE RECALLED. JUST THAT MINE WAS NOT WITHIN THE THE MANUFACTURE'S DATE CODE WITH IN A FEW WEEKS. I FEEL THAT IF I HADN'T HAD THAT CAMPER BEHIND ME THAT I PROBABLY COULD HAVE LOST CONTROL OF MY TRUCK WITH POSSIBLE CATASTROPHIC CONSEQUENCES.

ON JULY 4, 2016 MY GIRLFRIEND AND I WERE TRAVELING HOME, ABOUT AN HOUR AND HALF INTO OUR TRIP WE NOTICED A WEIRD VIBRATION, WE DECIDED TO GET OFF ONTO SATE RD 429, WE SLOWED WAY DOWN LOOKING FOR A PLACE TO PULL OVER, WHEN THE BACK PASSENGER TIRE TREAD COMPLETELY SEPARATED FROM THE TIRE. ONCE WE PULLED OVER WE NOTICED THE DAMAGE THE SEPARATED TIRE TREAD DID TO THE TRUCK BODY. I HAVE CALCULATED THE TOTAL MILEAGE OF 25196 ON THE TIRES, SINCE I BOUGHT THE TRUCK FROM KISSELBACK FORD IN ST. CLOUD FLORIDA WHO INSTALLED THE TIRES. I DECIDED TO REPLACE THE OTHER 3 TIRES FOR OUR SAFETY EVEN THOUGH THESE TIRES ARE RATED FOR 50,000 MILES. THE TIRE SHOP THAT INSTALLED THE NEW TIRES DID NOTE THE FRONT TIRE HAD BUBBLES FORMING, THIS IS AN INDICATION THAT THIS TIRE WAS ALSO PRONE TO TREAD SEPARATION POSSIBLY LEADING TO A MORE SERIOUS ACCIDENT. THE TIRES THAT ARE IN QUESTION IS CAPITOL HT 265-70-17 DOT NUMBER SKVR RC 4713. I HAVE RECEIVED 3 ESTIMATES FOR THE BODY WORK ESTIMATING AROUND $2500 PLUS THE COST OF FOUR NEW TIRES. I HAVE SEVERAL PICTURES THAT I CAN SEND.

HEADS WENT BAD NOW I HAVE TO REPLACE THE HEADS AND NEW HEAD STUDS BECAUSE THE OLD HEAD STUDS STRETCHED AND THE HEADS WARPED , ALSO HAD TO DO AN EGR DELETE . I WAS TOLD IT WAS BUILT PROOFING AND IT HAS TO BE DONE TO ALL 6.0 LTRS.

LIKE TOYOTA CARS, IF "WINTER-STYLED, RUBBER FLOOR MAT ON DRIVERS SIDE BECOMES UNHOOKED & SLIDES FORWARD, IT CAN LODGE THE ACCELERATOR DOWN CAUSING A HIGH SPEED. IT HAS HAPPENED TO ME SEVERAL TIMES, ALMOST CAUSING ME TO LOOSE CONTROL. THESE ARE FORD FACTORY INSTALLED MATS I PAID EXTRA FOR AT TIME VEHICLE WAS PURCHASED NEW. OCCURS WHEN I ACCELERATED HARD, SUCH AS TO PASS ANOTHER CAR OR ENTER/MERGE ONTO AN INTERSTATE. HAD TO PUT CAR IN NEUTRAL AND PULL MAT BACK. HAS HAPPENED SEVERAL TIMES SINCE VEHICLE WAS PURCHASED.

TRUCK "DEATH WOBBLE" - DRI\VING ON I 25 AT ABOUT 60 MPH WE HIT A SMALL BUMP IN THE ROAD AND THE TRUCK BEGAN TO VIOLENTLY SHAKE. WE THOUGHT WE HAD A BLOWOUT, BUT THE TIRES WERE OK. IN FACT, BEFORE OUR TRIP WE HAD OUR TIRES CHECKED AND WERE TOLD THEY WERE FINE. AFTER GOING TO A DEALER I HAVE DISCOVERED THAT THIS IS A KNOWN PROBLEM CALLED THE "DEATH WOBBLE". IT IS AN ENGINEERING DEFECT AND HAS NOTHING TO DO WITH TIRES AS FORD WOULD LIKE TO ASSUME. I RECEIVED A NOTICE FROM FORD IN DEC 2015 ACKNOWLEDGING THE "SEVERE VIBRATION" AND BLAMING IT ON THE TIRES. IT IS NOT THE TIRES IT IS AN ENGINEERING DEFECT. WHAT IS BEING DONE REGARDING A RECALL TO FIX THIS PROBLEM? UNLESS YOU HAVE EXPERIENCED THE VIOLENT SHAKING YOU HAVE NO IDEA HOW TERRIFYING IT IS AND THE POTENTIAL TO CAUSE A SERIOUS IF NOT DEADLY ACCIDENT. I KNOW I AM NOT THE ONLY ONE COMPLAINING AS I HAVE READ NUMEROUS ACCOUNTS ON FORUMS, SEEN YOUTUBE VIDEOS AND HAD THE ACKNOWLEDGEMENT FROM A DEALER ABOUT THE PROBLEM!!!. PLEASE HELP.

PLEASE REOPEN THIS INVESTIGATION. EVERY PERSON THAT I KNOW WITH A FORD F250 4X4 HAS THIS PROBLEM ON OCCASION. YOUR FAILURE TO MAKE FORD FIX WILL KILL SOMEONE. HOW MANY PEOPLE HAVE TO DIE? DATE INVESTIGATION OPENED: MAR 14, 2008 DATE INVESTIGATION CLOSED: MAR 31, 2009 NHTSA ACTION NUMBER: EA08007 COMPONENT(S): SUSPENSION MY TRUCK HAS 60,000 MILES NOW AND I HAVE REPLACED ALL 4 TIRES NEARLY 3 DIFFERENT TIMES IN THE LAST 15,000 MILES. THAT'S AN AVERAGE OF TIRES LAST 5000 MILES. I HAVE ENCOUNTERED THIS PROBLEM MANY TIMES, AND CONSTANTLY GET A "RUN-AROUND" THAT IT'S THE TIRES. MY TIRES ARE PROPERLY INFLATED. YESTERDAY, I WAS TRAVELLING ON INTERSTATE 45 YESTERDAY AT 70 MPH'S AND TRAFFIC SUDDENLY SLOWED TO A CRAWL. I HAD TO APPLY MY BRAKES AGGRESSIVELY AND WHEN I HIT A CERTAIN SPEED BETWEEN 35MPH AND 60 MPH, THE TRUCK BEGAN TO RANDOMLY BOUNCE AND WAS COMPLETELY UNCONTROLLABLE. I COULDN'T EVEN STEER. I NEARLY CRASHED INTO SEVERAL VEHICLES ON THE ROAD. WHILE THE FRONT END OF THE VEHICLE WAS VIOLENTLY BOUNCING (IT BOUNCED SO VIOLENTLY IT BROKE A FOLDING DOWN TV MOUNT / MOUNTED IN THE CEILING OF THE TRUCK), I HUNG ONTO THE STEERING WHEEL FOR DEAR LIFE (LIKE HANGING ONTO A BULL 8 SECONDS) AND CONTINUED TO SLOW EVEN FURTHER, AND ULTIMATELY HAD TO DRIVE OFF INTO THE GRASS ELSE I WAS GOING TO CRASH. THE DEATH WOBBLE WENT AWAY WHEN I APPROACHED A COMPLETE STOP < 15MPH. IN THE SAME TRUCK, I HAVE HAD THIS DEATH WOBBLE INCIDENT HAPPEN OVER 200 TIMES SINCE OWNING THE VEHICLE. I HAVE EVEN HAD THIS SAME PROBLEM HAPPEN WHILE HAULING CAR'S ON CAR TRAILERS. IT IS SCARY. AFTER MARKET MFRS MAKE CLAIMS THAT IT'S DUE TO THE TRACK BAR AND BUSHINGS AND THESE KITS ARE AVAILABLE TO FIX THE ISSUE, BUT FORD AND THE TSA DENIES ITS A REAL PROBLEM. BEFORE I PAY OUT THOUSANDS FOR A AFTERMARKET SUSPENSION, I EXPECT FORD TO FIX THIS, THE CORRECT WAY.

I REPLACED THE RADIATOR 3 TIMES AND CHANGE THE THERMOSTAT TO ,THE RADIATOR KEEPS POPPING, IT'S GETTING OLD,I ALSO CHANGED THE HEATER CORE AND IT POPPED . MAN WHAT IS GOING ON.IT HAPPENS WHEN I'M STATIONERY SITTING OVER NIGHT AT HOME.

TRUCK VIOLENTLY SHAKES AFTER HITTING A BUMP OR DIP IN THE ROAD AND DOESN'T STOP UNTIL I SLOW DOWN TO ALMOST A COMPLETE STOP. RECEIVED A LETTER FROM FORD ABOUT THIS PROBLEM BUT THE ONLY SOLUTION THEY OFFER IS TO CHECK TIRE PRESSURE WHICH I DID AND OF COURSE DID NOTHING.