2003 FORD F-250 Complaints

DRIVING 60 MPH OR GREATER AND HIT A BUMP THE FRONT END WILL VIOLENTLY SHAKE AND YOU HAVE TO PULL OVER AND SLOW WAY DOWN TO STOP IT. THERE WAS A RECALL FOR NR 62 PARTS BUT THAT DOESN'T STOP THE DODGE DEATH WOBBLE. THIS IS GOING TO CAUSE AN ACCIDENT AND KILL SOMEONE. DODGE WILL NOT REIMBURSE ME FOR THE REPAIRS THAT I PAID FOR THAT INCLUDED THE RECALL NR62. THE REPAIRS WERE DONE BEFORE I RECEIVED THE RECALL. IN THE RECALL IT IS STATED THAT THEY WOULD PAY FOR REPAIRS IF THEY WERE ALREADY DONE. EVERYONE ONE SEEMS TO KNOW ABOUT THE DODGE DEATH WOBBLE BUT WON'T FIX IT. *TR

I WAS TRAVELING ON THE HIGHWAY DURING FIVE O CLOCK TRAFFIC AT A SPEED OF APPROXIMATELY 40 MPH WHEN SUDDENLY THE VEHICLES IN FRONT OF ME BEGAN CRASHING INTO EACH OTHER. I PRESSED MY FOOT ON THE BRAKE PEDAL TO STOP AND SUDDENLY THE PEDAL WENT STRAIGHT TO THE FLOOR AND I SMASHED INTO THE BACK OF THE CAR IN FRONT OF ME. TODAY THE AUTO SHOP HANDLING THE REPAIRS CALLED ME IN TO LOOK AT WHAT HAPPENED. THE MASTER CYLINDER BROKE COMPLETELY FREE FROM THE BOOSTER. THE METAL BRACKETS BROKE IN HALF AND SEPARATED CAUSING THE LOSE OF BRAKES AND THE ACCIDENT. I HAVE PHOTOS OF THE MASTER CYLINDER BLOWN AWAY FROM THE BOOSTER. *TR

TRUCK IS LIGHTLY USED. TODAY I HOOKED UP THE HORSE TRAILER TO HAUL HORSES AND WHEN I WAS HEADED DOWN THE DRIVEWAY AND USED THE BRAKES THEY COMPLETELY FAILED. I ENGAGED THE TOW MODE ON THE TRANSMISSION AND USED THE E-BRAKE TO STOP. THERE WAS NO WARNING JUST BRAKE PEDAL TO THE FLOOR FAILURE. IF THIS FAILURE OCCURRED 2 MINUTES LATER I WOULD OF BEEN AT HIGHWAY SPEED. THERE WAS A LARGE LEAK ON THE MAIN BRAKE LINE ABOVE THE REAR FUEL TANK. I INSPECTED THE MAIN BRAKE LINE AND EVERY PLACE THE BRAKE LINE IS ATTACHED TO THE FRAME THERE IS SIGNIFICANT CORROSION OF THE BRAKE LINE . 2 INCHES FROM THE ATTACHMENT THE BRAKE LINE LOOKS BRAND NEW. LOOKS LIKE THE ENGINEERS USED A DISSIMILAR METAL AND CAUSED A CORROSION CELL. 10 YEAR OLD TRUCK AND I AM SPENDING $800.00 TO REPLACE THE ENTIRE MAIN BRAKE LINE. THIS TYPE OF FAILURE ON A $50,000 TRUCK SHOULD NOT BE HAPPENING. DEALER SAYS HE HAS NEVER SEEN THIS BEFORE. THIS IS A SERIOUS SAFETY FAILURE. *JB

THREAD SEPARATION , THIS IS THE SECOND BFG TIRE THAT HAS SEPARATED REFER TO ODI NUMBER 10508448. *TR

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A NOISE IN THE VEHICLE AND HE NOTICED THAT THE FUEL TANK WAS DRAGGING ON THE GROUND. THE CONTACT MENTIONED THAT THE FUEL TANK STRAPS FAILED WHICH CAUSED THE FUEL TANK TO NOT BE RESTRAINED PROPERLY. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 56,000. *TR

COMPLETE FAILURE OF THE BRAKING CAPABILITIES OF THE TRUCK. REAR MAIN BRAKE LINE ABOVE FUEL TANK BURST. BRAKE FLUID LEAKING ALL OVER GROUND. PEDAL WENT RIGHT TO FLOOR. HAD TO PUMP MANY TIME TO GET TRUCK TO STOP, COULD HAVE BEEN INVOLVED IN DEADLY ACCIDENT. *TR

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 228,000. *TR

TL* THE CONTACT OWNS A 2003 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING UP AN INCLINE APPROXIMATELY 45 MPH, THERE WAS A SUDDEN REDUCTION IN THE ENGINE POWER AND THEN STALLED. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. A CHEMICAL BURNING ODOR EMITTED OUTSIDE OF THE VEHICLE. THE FAILURE OCCURRED SPORADICALLY AND WHENEVER THE FUEL TANK LEVEL REGISTERED QUARTER OF A TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE FUEL TANK LINING WAS SEVERELY DAMAGED AND THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THAT WHILE PERFORMING AN OIL CHANGE, HE NOTICED THAT THE FRAME WAS RUSTED SEVERELY.THE CONTACT PERFORMED A THOROUGH INSPECTION OF THE VEHICLE AND ALSO DISCOVERED THAT THE FUEL TANK STRAPS WERE SEVERELY RUSTED. THE FRONT STRAP WAS COMPLETELY DETACHED FROM THE VEHICLE AND THE SECOND STRAP WAS PARTIALLY HANGING FROM THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.

TL* THE CONTACT OWNS A 2003 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE CLUTCH FAILED. UPON FURTHER INSPECTION THE CONTACT NOTICED THAT THE PLASTIC BUSHING HAD FAILED AND THE ROD WAS DETACHED FROM THE CLUTCH. THE CONTACT WENT TO THE DEALER, PURCHASED A NEW BUSHING AND REPAIRED THE VEHICLE HIMSELF. THE RECENT FAILURE WAS THE SECOND CLUTCH FAILURE ON THE VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 58,000. UPDATED 10/24/12 *CN UPDATED 11/9/2012 *JS