1998 FORD F-250 Complaints

TL* THE CONTACT OWNS A 1998 FORD F-250. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT TIRE STORE AND THE MECHANIC REFUSED TO MOUNT THE REAR DRIVER SIDE TIRE BECAUSE THE RIM WAS SEVERELY RUSTED. ALL OF THE OTHER RIMS WERE IN THE SAME CONDITION, INCLUDING THE SPARE THAT WAS NOT EVEN MOUNTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 220,000. *TT*JB

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY REPORTED PROBLEMS AND THAT IF THERE WERE ANY ISSUES, THE NHTSA WOULD HAVE REPORTS OF THIS. TIRES WERE IMPORTED BY TBCBRANDS OR TBC CORPORATION AND A PRIMARILY SOLD BY LES SCHWAB TIRE STORES. DRIVER'S REAR; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 73 LBS) PASSENGER'S REAR; DOT 535TLE50 1815, MADE IN CHINA (DEFECTIVE, 43 LBS) DRIVE'S FRONT; DOT YJ5TLEV2 2815, MADE IN VIETNAM (YELLOW, CURRENTLY AT 15 LBS) PASSENGER'S FRONT; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 75 LBS)

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY REPORTED PROBLEMS AND THAT IF THERE WERE ANY ISSUES, THE NHTSA WOULD HAVE REPORTS OF THIS. TIRES WERE IMPORTED BY TBCBRANDS OR TBC CORPORATION AND A PRIMARILY SOLD BY LES SCHWAB TIRE STORES. DRIVER'S REAR; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 73 LBS) PASSENGER'S REAR; DOT 535TLE50 1815, MADE IN CHINA (DEFECTIVE, 43 LBS) DRIVE'S FRONT; DOT YJ5TLEV2 2815, MADE IN VIETNAM (YELLOW, CURRENTLY AT 15 LBS) PASSENGER'S FRONT; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 75 LBS)

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY REPORTED PROBLEMS AND THAT IF THERE WERE ANY ISSUES, THE NHTSA WOULD HAVE REPORTS OF THIS. TIRES WERE IMPORTED BY TBCBRANDS OR TBC CORPORATION AND A PRIMARILY SOLD BY LES SCHWAB TIRE STORES. DRIVER'S REAR; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 73 LBS) PASSENGER'S REAR; DOT 535TLE50 1815, MADE IN CHINA (DEFECTIVE, 43 LBS) DRIVE'S FRONT; DOT YJ5TLEV2 2815, MADE IN VIETNAM (YELLOW, CURRENTLY AT 15 LBS) PASSENGER'S FRONT; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 75 LBS)

SAILUN IS NOT A CURRENTLY A VALID CHOICE AS A TIRE BRAND NAME:, NOR IS TARRAMAX H/T A VALID CHOICE AS A TIRE LINE:, WHY I HAVE SUBMITTED THIS REPORT UNDER THE UNKNOWNCATEGORY FOR BOTH OF THESE CELL INPUTS. PURCHASED (4) NEW SAILUN, TARRAMAX H/T, LT265/75R-16 TIRES (IN JANUARY 2016). AFTER APPROXIMATELY 13,000 MILES OF USE, STARTED EXPERIENCING AN UNUSUAL VIBRATION AT HIGHWAY SPEEDS. AFTER MANY HOURS OF TROUBLESHOOTING THE VIBRATION PROBLEM, IT WAS FINALLY REVEALED AT ANOTHER TIRE CENTER (USING A HUNTER ROAD FORCE TEST/BALANCING MACHINE...AT AN EXTRA COST) THAT 3 OF THE 4 TIRES WERE ACTUALLY DEFECTIVE (RED (75 LBS, 73 LBS AND 43 LBS) CONDITION, REPLACE TIRE) AND THE 4TH TIRE USABLE (YELLOW (15 LBS) CONDITION, SLIGHTLY OUT OF ROUND, BUT ARE STILL USABLE...FOR HOW LONG, IS ANYONE GUESS). ROAD FORCE TESTING REVEALED THAT THE INTERNAL BELTS HAD SEPARATED AND ARE THE CAUSE FOR THE OUT OF ROUND TIRE CONDITION. THIS IS WHY THE VIBRATION HAS GOTTEN SIGNIFICANTLY WORST OVER THE PAST MONTH...MORE BELT SEPARATION WITH EACH USE. ACCORDING TO THE TIRE EXPERT TECHNICIAN AT DISCOUNT TIRES, "THE TIRES ARE EGG SHAPED RATHER THAN ROUND LIKE A DOUGHNUT AND THIS CONDITION IS WHAT IS CAUSING THE VIBRATIONS EVEN THOUGH THE TIRES ARE SHOWING BALANCED ON OTHER BALANCING MACHINES AT OTHER SHOPS. OTHER BUYERS HAVE COMPLAINED ON-LINE ABOUT THIS SAME PROBLEM, BUT I SUSPECT THEY HAVE NOT OFFICIALLY REPORTED THESE PROBLEMS TO THE NHTSA. TBCBRANDS CUSTOMER SERVICE IS CLAIMING THAT THERE HAS NEVER BEEN ANY REPORTED PROBLEMS AND THAT IF THERE WERE ANY ISSUES, THE NHTSA WOULD HAVE REPORTS OF THIS. TIRES WERE IMPORTED BY TBCBRANDS OR TBC CORPORATION AND A PRIMARILY SOLD BY LES SCHWAB TIRE STORES. DRIVER'S REAR; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 73 LBS) PASSENGER'S REAR; DOT 535TLE50 1815, MADE IN CHINA (DEFECTIVE, 43 LBS) DRIVE'S FRONT; DOT YJ5TLEV2 2815, MADE IN VIETNAM (YELLOW, CURRENTLY AT 15 LBS) PASSENGER'S FRONT; DOT 535TLE50 1615, MADE IN CHINA (DEFECTIVE, 75 LBS)

FORD F-250 4X4 FORD RECALL 11S21(NHTSA 11V385) FUEL TANK STRAP CORROSION INSPECTION AND REPLACEMENT WAS CONDUCTED. THE FUEL TANK WAS ALSO FOUND TO BE RUSTED UNDER THE STRAP AREA ONLY. AFTER THE OLD STRAPS WERE REMOVED THE TANK STARTED TO LEAK FUEL AND FORD NOR THE DEALER WOULD REPLACE THE TANK. IF THE STRAPS ARE COVERED FOR CORROSION THEN THE TANK SHOULD BE ALSO DUE TO THE CORROSION TRANSFERRING TO THE TANK SURFACE. THE DEALER PLACED NEW STRAPS OVER A RUSTED TANK. THE TRUCK WILL NEED OVER $1200.00 IN REPAIRS FOR SAFE OPERATION AND TO REMEDY THE NOW LEAKING FUEL. *TR

THE EVENING OF JULY 26TH, 2011 APPROXIMATELY 10:00PM EST, AN ENGINE FIRE OCCURRED IN OUR 1998 FORD F-250 TRUCK (EXT CAB, TRITON V-8 ENGINE, LARIAT ED). THE F-250 HAD BEEN PARKED IN A REMOTE PARKING AREA ON THE INTERIOR AREA OF THE MASON COUNTY FAIR GROUNDS. DUE TO COUNTY FAIR ACTIVITIES DURING THAT DAY, THE TRUCK HAD NOT BEEN STARTED FOR OVER 10 HOURS WHEN THIS FIRE OCCURRED. THE LOCAL FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. IT TOTALED THE ENGINE, BUCKLED THE HOOD, BLISTERED THE PAINT, ETC. LUCKILY THERE WAS NO PROPERTY DAMAGE, NOR WAS THERE ANY BODILY INJURY. WE HAD PURCHASED THE TRUCK IN APRIL OF 2010. THIS TRUCK WAS IN PRISTINE (EAT OFF THE ENGINE) CONDITION. SINCE WE HAVE OWNED IT, IT HAD REGULAR OIL CHANGES (MOBIL-1 SYNTHETIC ONLY). ASIDE FROM THAT, AND OTHER NORMAL MAITENANCE, THERE HAD BEEN NO MODIFICATIONS TO THE VEHICLE, WHICH HAD STOCK EQPT WHEN WE PURCHASED IT. NO-OFF ROADING, MY SON BABIED THIS TRUCK. HE DID NOT EVEN LIKE GOING TO HIS GIRLFRIEND'S HOME WITH IT, BECAUSE SHE LIVED ON A DIRT ROAD. HE IS MORE THAN JUST LEFT WITHOUT A VEHICLE, HE IS HEARTBROKEN, TO SAY THE LEAST. I HAVE CHECKED THAT THERE WAS A POLICE REPORT. 911 WAS CALLED, BUT ULTIMATELY IT IS THE FIRE DEPARTMENT THAT MADE THE REPORT. I NOTIFIED FORD ON JULY 27TH, 2011. ON JULY 30TH, 2011 I RECEIVED A LETTER FROM MARIA AGUILERA, PRODUCT CLAIMS LEGAL ANALYST, FORD'S OFFICE OF GENERAL COUNCIL IN DEARBORN, MI. WE ARE WORKING TO GATHER INFORMATION REQUIRED BY HER AT THIS TIME. *KB

1998 FORD F-250 (EARLY BUILD) WITH 201,992 MILES, HAD THE GAS TANK STRAP RUST AND BREAK RESULTING IN THE GAS TANK DROPPING TO THE PAVEMENT. THE FORWARD (FRONT) GAS TANK STRAP FAILED AND THE GAS TANK FELL TO THE PAVEMENT CAUSING THE RELEASE OF APPROXIMATELY 22 GALLONS OF FUEL. THE RESULTING SPILL REQUIRED A CLEANUP BY THE LOCAL FIRE DEPARTMENT. THE SPILL CLEANUP RESULTED IN A $453 CHARGE BY THE FIRE DEPARTMENT. THE VEHICLE WAS TOWED TO A REPAIR SHOP AT A COST OF $112. THE FUEL TANK AND STRAPS REQUIRED REPLACEMENT AT A COST OF $978.00. TOTAL COST OF EVENT $1,500. *TR

ON APRIL 9TH 2011 MY FUEL TANK STRAPS BROKE WHILE DRIVING AT 45 MPH. THE TRUCK WAS PULLED TO THE SIDE OF THE ROAD AND THE TANK WAS HANGING BY THE FUEL LINES AND TANK NECK. THE TRUCK IS A FORD F-250 LIGHT WITH A 24 1/2 GALLON FUEL TANK, THAT HAS 102000 MILES. I REPLACED BOTH STRAPS AT A COST OF $34.00. I PAINTED THE NEW STRAPS TO PREVENT FUTURE PROBLEMS. *TR

THE METAL STRAPS HOLDING THE GAS TANK ON MY 1998 F250 (REGULAR DUTY) RUSTED TO PIECES ONE AT A TIME UNTIL THE LAST STRAP BROKE AND THE GAS TANK DROPPED ON TO THE ROAD. IT IS A MIRACLE THE TANK DIDN'T GET WEDGED UNDER THE VEHICLE OR EXPLODE FROM BEING DRAGGED ON THE ROAD. *TR