2005 FORD F-250 SD Complaints

RIGHT REAR PARKING BRAKE FAILED. REAR BRAKE ASSEMBLY PLATE CORRODED THROUGH AND ALLOWED RETAINING STUD TO PULL THROUGH PLATE. PARKING BRAKE ASSEMBLY LOST INTEGRITY CAUSING BRAKE DRAG AND SQUEALING NOISE. BRAKE PART FAILED IN 65000 MILES. CONCERNED FAILURE COULD HAVE BECOME CATASTROPHIC AT FREEWAY SPEEDS IF PARKING BRAKE LOCKED UP WHEEL. PART IS AVAILABLE. *TR

TL* THE CONTACT OWNS A 2005 FORD F250 SUPER DUTY. HE EXPERIENCED BRAKE FAILURE TWICE WHILE DRIVING, BUT WAS ABLE TO AVOID TWO CRASHES. THE VEHICLE WAS TAKEN TO THE DEALER AND THE FRONT ROTORS WERE REPLACED. AFTER THE REPAIR HE EXPERIENCED REDUCED BRAKING CAPABILITY. HE ALSO SMELLED A BURNING ODOR DURING BRAKE APPLICATION AND UPON FURTHER INSPECTION, HE NOTICED THAT THE FRONT ROTORS WERE DEFECTIVE. HE WAS IN THE PROCESS OF TAKING THE VEHICLE BACK TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 59,300. UPDATED 12/07/09. *LJ UPDATED 12/08/09

I OWN A 2005 F250 SUPER DUTY, MY TRUCK EXPERIENCES THE "DEATH WOBBLE" WHEN EVER I GO OVER AN UNEVEN OR A POT HOLE IN THE ROAD. I LIVE IN ARKANSAS, AND OUR ROADS ARE NOT THE BEST. SO THIS HAPPENS JUST ABOUT EVERY TIME I DRIVE THE THING. I JUST PURCHASED THIS VEHICLE IN SEPTEMBER OF 2009. APPARENTLY WHEN I TEST DROVE THE TRUCK I WAS ON SMOOTH PAVEMENT OTHERWISE I WOULDN'T HAVE BOUGHT IT. *TR

SEVERE FRONT END WOBBLE CAUSING ENGINE TO FAIL, ALL POWER IS LOST ON THE VEHICLE ACCORDING TO FORD FICM HARNESS WAS BAD THEY REPLACED IT NOW THE ABS LIGHT INDICATES A PROBLEM WITH THE BRAKES......NO REPAIRS YET VEHICLE STILL IN SHOP. *TR

FORD F-250 SUPERDUTY- WHILE DRIVING AT 55MPH OR HIGHER,AND YOU HIT A SMALL POTHOLE OR DIP IN THE ROAD, THIS VEHICLE GOES INTO A VIOLENT SHIMMY. THE VEHICLE IS UNCONTROLLABLE AND EXTREMELY DANGEROUS. I WON'T LET ANY OF MY FAMILY MEMBERS RIDE IN THE TRUCK WITH ME AND CRINGE AT THE THOUGHTS OF HAVING TO DRIVE IT ON THE INTERSTATE! IT HAS SHAKEN ME OFF THE ROAD AND INTO THE DITCH OR MEDIAN SEVERAL TIMES. *TR

2005 FORD F-250 TRANSMISSION CIRCLIP IS COMING OFF CAUSING TRANSMISSION TO LEAK AND ULTIMATELY FAIL. WE KNOW OF 6 PEOPLE THAT THIS HAS HAPPENED TO, NOW US. FORD HAD A "CUSTOMER SATISFACTION BULLETIN 05B27" THAT EXPIRED AT THE END OF 2006. WE FOUND THIS ON OUR OWN. FORD IS ABSOLUTELY NO HELP WITH THIS ISSUE. PLEASE READ THE DIESEL FORMS ON THE INTERNET. *TR

TL- THE CONTACT OWNS A 2005 FORD F250. HE STATES THAT WHILE DRIVING AND WITH OUT WARNING THE VEHICLE STARTS TO STALL AND SHUTS OFF. HE THEN HAS TO PULL THE VEHICLE SIDE AND WAIT ABOUT 10 MINUTES AND THEN TURN THE VEHICLE BACK ON. WHEN THE VEHICLE IS TURNED BACK ON IT DRIVES FINE AFTERWARDS WITHOUT A PROBLEM. THE DEALER WAS CONTACT AND THEY TO;D HIM THAT THERE WAS A RECALL FOR THE VEHICLE BUT HIS VIN NUMBER WAS NOT INCLUDED. THE RECALL IS COMPONENT: ELECTRICAL SYSTEM:WIRING NHTSA CAMPAIGN ID NUMBER: 05V270000 , THE VEHICLE IS EXPERIENCING THE SAME SYMPTOMS INCLUDED IN THIS RECALL. THIS HAS OCCURED ONCE AGAIN WHERE THE VEHICLE WAS REPAIRED UNDER WARRANTY AND KNOW IS REOCCURING AGAIN BUT THIS TIME IT IS WORSE. THE VEHICLE WILL BE REPAIRED AT OWNERS EXPENSE. THE FAILURE MILEAGE WAS 60000 AND CURRENT MILEAGE WAS 103000.

TL*THE CONTACT OWNS A 2005 FORD F-250 PURCHASED BRAND NEW IN 2005. WHILE STEPPING ON THE DRIVER'S SIDE RUNNING BOARD, THE ENTIRE BOARD BROKE OFF THE TRUCK. THE RUNNING BOARD CONSIST OF FIVE MOUNTED PIECES AND ALL FIVE PIECES BROKE SIMULTANEOUSLY. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 17,520.

I BOUGHT A 2005 F250 CREW CAB AND SINCE ABOUT 25K MILES MY TRUCK WILL WOBBLE WHEN I HIT A BUMP AT 45-60 MILES PER HOUR. THE SHACK/WOBBLE IS SO INTENSE THAT YOU FEEL THE FRONT OF THE TRUCK IS GOING TO LOOSE THE TIRES. THIS HAS HAPPENED ABOUT 6 TIMES NOW AND I KNOW SOMETHING IS VERY WRONG BUT FORD WILL NOT DO ANYTHING EXCEPT TELL ME TO CHECK MY TIRE PRESSURE. TIRE PRESSURE IS CHECKED ALMOST MONTHLY ON MY TRUCK AND I KNOW THAT IS NOT THE ISSUE. IT IS HARD TO HAVE RE-CREATE THE ISSUE WITH A TECH, SINCE IT DOES NOT HAPPEN ALL THE TIME. I AM GETTING THE RUN AROUND WITH FORD AND HAVE SPENT THOUSANDS OF DOLLARS TRYING TO FIX THE PROBLEM MYSELF. I KNOW OF OTHER FORD OWNERS THAT HAVE THE SAME PROBLEM AND FORD REFUSES TO DO ANYTHING. *TR

2005 FORD F250 FRONT END SHAKES VIOLENTLY WHEN DRIVING OVER BUMPS IN ROAD INCLUDING SPEED BUMPS, AT ANY SPEED. SHAKES SO BAD THAT VEHICLE WANTS TO LEAVE THE ROAD SIDEWAYS. SHAKES LIKE A DOG WAGGING OFF WATER. REPLACED STEERING STABILIZER, SHOCKS, TIRES AND HAD FRONT ENT CHECKED. STILL SHAKING. GETTING READY TO TURN IN TO CLUNKER PROGRAM. NEVER BUY A FORD AGAIN, THEY KNOW THIS IS A PROBLEM. *TR