2005 FORD F-250 SD Complaints

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. WHILE DRIVING 60 MPH, THE STEERING WHEEL BECAME VERY LOOSE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THIS WAS AN ONGOING FAILURE WITH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND TO BILLINGSLEY FORD LINCOLN OF LAWTON (8209 NW QUANAH PARKER TRAILWAY BLDG. 1, LAWTON, OK 73505, (580) 536-3325) ON SEVERAL OCCASIONS, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED OR DIAGNOSED. THE CONTACT STATED THAT THE MANUFACTURER WAS ALSO NOTIFIED MANY TIMES AND ADVISED HIM TO LEAVE A MESSAGE AND SPEAK WITH THE OWNER OF THE DEALER. THE CONTACT RECEIVED FORD ACTION BULLETIN NUMBER: 09L02 (STEERING: WHEEL AND HANDLE BAR, TIRES). THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

WHEN STEPPING ON BRAKES WHILE DIRECTIONAL IS ON THE DIRECTIONALS STOP FUNCTIONING WHILE IN MOTION AND TURNING WHICH IS A SERIOUS SAFETY HAZARD IM WONDERING WHY NHTSA 11V352000 IS ALLOWING FORD TO ONLY REPAIR CERTAIN VINS ESPECIALLY WHEN MY YEAR MAKE AND MODEL ARE SPECIFIED IN THE SUMMARY.WITH THE SAME EXACT SYMPTOMS???

ON SEVERAL OCCASIONS, MY F250, SUPER DUTY 6.0 DIESEL BECAME SLUGGISH AND GAS MILEAGE SUFFERED IMMENSELY. THEN, WITH ONLY 53,000 MILES, MY LEFT REAR DISK BRAKE CALIPER WAS DRAGGING AND STARTED SMOKING. AT MY COST AND ON THE LEFT REAR, I HAD FORD REPLACE THE CALIPER, PADS, BRAKE LINE AND RESURFACE THE ROTORS. ALSO, THE RIGHT REAR ROTOR WAS RESURFACED. AT 54,000, I MAKE A 100 MILE TRIP AND THE RIGHT REAR CALIPER STARTED DRAGGING. I AM NOT SURE HOW TO FIX THIS SINCE NO ONE HAS THE SOLUTION.ADDITIONALLY, I DO NOT HAVE THE MONEY TO REPLACE THE ENTIRE BRAKE SYSTEM. HOWEVER, THIS COULD CAUSE TOTAL BRAKE FAILURE AND A POSSIBLE FIRE RESULTING IN FATALITIES.

TIRE BEGAN TO SHIMMY, PULLED OVER FOUND NOTHING WRONG, 25 MILES LATER TIRE BLEW AT HIGHWAY SPEED CAUSING LOSE OF CONTROL. TIRE BELTS DID EXTENSIVE DAMAGE TO VEHICLE. SAME TIRE AS NHTSA RECALL NUMBER 15T-061 BUT MANUFACTURED 4 MONTHS PRIOR TO EARLIEST RECALL PRODUCTION DATE.

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FICM FUEL INJECTION CONTROL MODULE (FICM) HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART AND WAS PUSHED TO THE RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE DEALER INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 141,000.

WHILE DRIVING HOME FROM WORK, JUST LEAVING TOWN I HIT 50 MPH AND THE TRUCK STARTS TO WOBBLE FROM SIDE TO SIDE AND VIBRATE TILL I SLOW DOWN TO UNDER 40 MPH. I GOT THE NOTICE FROM FORD TELLING ME IT ALL HAD TO DO WITH TIRE PRESSURE. I INFLATED THE TIRES TO THE REQUIRED PRESSURE AND IT ONLY MADE THINGS WORSE. I HAVE CONTACTED THEM THE FIRST TIME THIS HAPPENED ONLY FOR THEM TO TELL ME THERE IS NOTHING WRONG. CLEARLY THERE IS A PROBLEM. I HAVE SPENT SO MUCH MONEY REPLACING PARTS IN THE FRONT END OF THIS TRUCK. TIRES ARE NOW JUNK ON THE FRONT END. THE ONLY THING I COULD DO IS UNDER INFLATE THE FRONT TIRES TO GAIN BETTER CONTROL AND DRIVE SLOWER. STILL WOBBLES JUST NOT AS BAD. THIS IS AN ON GOING PROBLEM I HAVE EVERYDAY.

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING ON TWO SEPARATE OCCASIONS. THE MECHANIC WAS UNABLE TO LOCATE A FAILURE ON EACH VISIT. THE VEHICLE WAS ALSO TAKEN TO THE DEALER WHO DISCOVERED THAT THE FAILURE WAS CONTRIBUTED TO THE FAULTY FUEL INJECTION CONTROL MODULE AND FUEL PUMP. THE VEHICLE WAS REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 138,576. MA 08/10/15 UPDATED 11/30/2015 *JS

WHEN SPEED CONTROL IS ENGAGED--SOMETIMES WHEN THE DECREASE BUTTON IS PUSHED THE SPEED OF VEHICLE INCREASES. VEHICLE IS 6.0 L DIESEL. THE SAME EVENTS OCCURRED WITH ANOTHER '05 F 250 DIESEL. *TR