2005 FORD F-250 SD Complaints

I WAS HEADING DOWN MY STREET IN MY NEIGHBORHOOD AND JUST BEFORE THE STREET BENDS TO THE LEFT MY TRUCK STALLED AND I LOST MY POWER BRAKES AND POWER STEERING. DOING THE BEST I COULD I TURNED THE WHEEL JUST ENOUGH TO AVOID THE CAR PARKED ON THE SIDE OF THE STREET THEN I PROCEEDED TO RUN THROUGH MY NEIGHBOR'S WROUGHT IRON GATE AND PLASTER COMING TO REST ON THE HILL IN HIS FRONT YARD. AFTER ASSESSING THE DAMAGE, I TRIED TO START MY TRUCK TO SEE IF I COULD MOVE IT. IT STARTED AND I MOVED IT TO MY DRIVEWAY. AFTER THE REPAIRS WERE DONE AT THE BODY SHOP I THEN TOOK IT TO MY MECHANIC WHERE HE DISCOVERED A FAULTY WIRE IN THE WIRE HARNESS CAUSING THE ENGINE TO STALL WITHOUT ANY NOTICE OR SIGNS OF TROUBLE. LATER I LEARNED FROM MY INSURANCE COMPANY THAT THERE WAS A RECALL FOR THE 2004-2005 MODELS FOR THE WIRE HARNESS SPECIFICALLY, THAT I NEVER RECEIVED ANY INFORMATION ON. *TR

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED THAT THE TURNING SIGNALS, BRAKE LIGHTS, REVERSE LIGHTS AND TAIL LIGHTS MALFUNCTIONED. THE FAILURE RECURRED ONCE AND THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THEY INFORMED THE CONTACT THAT THE VIN HAD NOT BEEN INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 11V352000 (EXTERIOR LIGHTING). THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. WHILE DRIVING BETWEEN 10 AND 25 MPH, THE VEHICLE STALLED. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 182,000.

TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE CAUSED THE FAILURE TO OCCUR AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER:05V26600 (FUEL SYSTEM,GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 105,669. UPDATED 02/12/15*LJ UPDATED 08/24/2017*CT

LOSING WATER AND OIL FROM EXHAUST, WHITE SMOKE. VEHICLE LOSING COOLANT FROM EXHAUST PIPE. HARD START. ACTS LIKE HIGH PRESSURE OIL, BLOWS LOTS OF WHITE SMOKE OUT OF EXHAUST. INSTALLED IDS/ COMPUTER AND INSTALLED COOLANT PRESSURE GAUGE IN LINE ON COOLING SYSTEM. MONITORED ECT/EOT AND COOLANT PRESSURE.. GOT VEHICLE TO NORMAL OPERATING TEMP. ECT/EOT WERE AT 15 DEGREES DIFFERENCE WHICH IS MAXIMUM ALLOWANCE FOR OIL COOLER TEMP.FORD RECOMMENDS IT BE REPLACED WHEN IT REACHES 15 DEGREE DIFFERENCE. ALSO RECOMMEND REPLACE EGR COOLER WITH OIL COOLER AS A SET. PERFORM TSB 09-08-3, TEST DEGASS BOTTLE-OK. EGR TEST ON VEHICLE PASSED, INSTALLED PRESSURE GAUGE. ROAD TEST FOR HEAD GASKETS - 21 PSI IN COOLING SYSTEM FAILED. PERFORMED TURBO OVER BOOST - TEST PASSED. FAILED ITEMS: HEAD GASKETS, OIL COOLER. WHEN TEARING APART NEED CHECK CONCERN WITH HIGH PRESSURE OIL SYSTEM. ESTIMATE TO REPAIR AROUND $7000 WHICH NEITHER FORD NOR DEALER, LEGACY FORD, WILL COVER UNDER WARRANTY. WHAT IS THE WARRANTY FOR IF NOT TO REPAIR FORD'S JUNK? SO NOW AN EXPENSIVE TRUCK SITS UNUSABLE BECAUSE OF FORD AND THEY HAVE LOST A LONG TIME BELIEVER IN FORD VEHICLES, THIS IS MY LAST FORD. *TR

CRANK, NOT START. HIGH PRESSURE OIL SYSTEM LEAK. PUMP FITTING LEAKING AND IPR DAMAGED. REMOVED AND REPLACED HP OIL PUMP, QUICK CONNECT AND IPR. COST $1380.29 AFTER ONLY 705 MILES, MORE REPAIRS NEEDED, OF COURSE NOT COVERED BY WARRANTY AGAIN. WHY ISN'T SOMETHING BEING DONE TO FORCE FORD TO PAY FOR REPAIRS TO THIS JUNK THEY PUT TOGETHER? WORK DONE BY LEGACY FORD. *TR

CRANK, NO START. NUMEROUS CODES. FICM FAILED VOLTAGE TEST, POWER BALANCE TEST. REPLACED FICM W REMANUFACTURED MODULE, ENGINE CONTROL (EEC). INSTALL CAC TUBE. REPLACE SERPENTINE BELT, ATO FUSE, CAE FUSE, AIR INLET CONNECTION AND AA CLAMP. COST $1294.68 WHY WASN'T THIS UNDER WARRANTY, SINCE SO MANY OF THESE TRUCKS NEED SAME REPAIRS? WORK DONE BY LEGACY FORD NEW OWNER OF FORD OF WALLA WALLA.. *TR

CHECK GAUGE LIGHT CAME ON. TEMPERATURE GAUGE ALMOST TO TOP. TOWED FROM ONTARIO, OR., TO BAKER, OR. FOR REPAIRS. REPLACED COOLANT CAP, STILL NOT RIGHT. SAND DEGAS BOTTLE AND RETEST, STILL FAILED. REMOVE TURBO ASSEMBLY AND INTAKE. PRESSURE TEST. EGR COOLER FAILS. REPLACE EGR COOLER AND INSTALL INTAKE. DISASSEMBLE TURBO AND INSPECT. CARBONED UP. REPLACED CENTER ROTATING ASSEMBLY AND UNISON RING. REASSEMBLED AND TRIED TO START. STATIC LOCKED. REMOVED ALL GLOW PLUGS, CRANK ENGINE TO CLEAR ALL CYLINDERS AND REINSTALL GLOW PLUGS. HAD TO CLEAR CARBON FROM INTAKE AND REPLACE EGR VALVE, RUN EGR TEST AFTER FULLY WARMED UP, EGR SYSTEM PASSED. CODES PO404, P0405, P115A AND U0100. DONE UNDER WARRANTY BY GENTRY FORD. THIS DEALER GIVES VERY DETAILED REPORT, BE NICE IF THEY ALL DID. *TR

HARD TO START. REPLACE BRACELET KIT. UNDER WARRANTY BY FORD OF WALLA WALLA. GOOD COMPANY. REPLACED BY LEGACY. NO MORE WARRANTY WHEN DEALERS CHANGE?. *TR

STOPPED AT A STOP SIGN, ACCELERATED TO MAKE LEFT TURN,HIT EITHER A BUMP OR PATCH OF SAND WHEN STEERING TOOK TO LEFT THEN RIGHT AND COULD NOT GET BACK. HIT A GUARDRAIL AND LANDED IN DITCH. MY TRUCK IS TOTALED BUT LUCKILY I WAS NOT SEVERELY INJURED. *TR