2005 FORD F-250 SD Complaints

VEHICLE STARTS TO SHAKE UNCONTROLLABLY AFTER HITTING A SMALL BUMP (POTHOLE, BRIDGE CONNECTOR) AT HIGHWAY SPEEDS (50-70 MPH). VEHICLE IS DIFFICULT TO CONTROL, AND STEERING IS SOMETIMES UNRESPONSIVE UNTIL VEHICLE SLOWS DOWN BELOW 40 MPH. THIS PROBLEM HAS CAUSED THE VEHICLE TO VEER TO THE LEFT ACROSS THE CENTER LINE, BUT THIS DOES NOT ALWAYS OCCUR. LOCAL DEALERS HAVE INSPECTED THE VEHICLE AND FOUND NO PROBLEMS WITH SUSPENSION OR CONTROL COMPONENTS. INCIDENT DATE IS JUST ONE OF AT LEAST 3 OCCURRENCES. WEB BASED USER GROUP/BULLETIN BOARDS REFER TO THIS PROBLEM AS THE 'DEATH WOBBLE' OR 'DEATH SHAKE' BECAUSE OF ITS VIOLENT NATURE, TENDENCY TO OCCUR AT HIGH SPEED, AND TENDENCY TO CAUSE THE VEHICLE TO DRIFT OFF THE ROAD. *TR

2005 FORD SUPER DUTY DIESEL 6.0 WAS UNABLE TO REREGISTER MY VEHICLE WITH THE CALIFORNIA DEPARTMENT OF MOTOR VEHICLES, UNLESS I RETURNED MY VEHICLE TO THE DEALER TO HAVE A RECALL/FLASH MEMORY RE FLASHED. I HAD NO CHOICE BUT TO DO THIS, OTHERWISE THE DMV WOULD NOT RENEW BY REGISTRATION. DEALER STATED FORD TRUCK DID NOT PASS CALIFORNIA EMISSIONS STANDARDS. ISSUE. FUEL ECONOMY FELL DRASTICALLY, AND POWER/TORQUE NOT LIKE BEFORE "UPGRADE" MANDATED TO MY TRUCK. SINCE THAT TIME, THE TURBO CHARGER HAS FAILED, AND UNIT NEEDS TO GO IN FOR REPAIR. I THINK WITH THIS REFLASH, I DID NOT GET WHAT I PAID FOR WITH THE RECALL REQUIREMENT BEING DONE. TRUCK DOES NOT HAVE THE POWER AND TORQUE AS ADVERTISED SINCE IT FAILED CALIFORNIA SMOG REQUIREMENTS ON A VEHICLE THAT DOES NOT REQUIRE SMOG TESTING. DEALER STATES FORD FAILED "RANDOM" EMISSION STANDARDS TEST OF A UNIT PICKED IN THE FIELD FOR TESTING, AND ALL VEHICLES IN SAME TRUCK FAMILY HAD TO BE REFLASHED IF SERIAL NUMBER UNDER THE ONE THEY TESTED. I ASKED CAL AIR RESOURCES BOARD TO LOOK INTO THIS, THEY WERE INTERESTED, BUT 8 MONTHS LATER STILL NO ANSWER. I DID NOT GET WHAT I PAID FOR. *TR

FICM HAD TO BE REPLACED AFTER MANY REPAIRS TO MY F250 FORD PICK UP 6.0 DIESEL NHTSA#05V270000 RECALL MY TRUCK BROKE DOWN ON THE FREEWAY I PAID $1,115.00 TO FIX THE PROBLEM THE DEALER TOLD ME THAT IT WAS NOT A WARRANTY PROBLEM ALL THOUGH MY TRUCK HAS HAD THIS PROBLEM FOR A LONG TIME PLEASE ADVISE. *TR

ON SEVERAL OCCASIONS WHILE TRAVELING OVER SPEEDS OF 55 MPH, THE VEHICLE SHAKES UNCONTROLLABLY IF YOU HIT A FLAW IN THE ROAD, SUCH AS A BUMP. IT HAS CAUSE MYSELF AND WIFE TO NEARLY LOSE CONTROL OF THE VEHICLE, FORTUNATELY THERE WERE NO OTHER VEHICLES CLOSE AS ON ONE OCCASION THE TRUCK CHANGED LANES WHILE SHAKING VIOLENTLY. I AM A FORMER TRUCK MECHANIC AND HAVE NEVER SEEN ANYTHING LIKE THIS. THE DEALER HAS TOLD US THAT THERE IS NO PROBLEM, YET I VIEW THIS AS A POTENTIALLY LIFE THREATENING ISSUE, WE HAVE NOT DRIVEN THE VEHICLE ON THE HIGHWAY SINCE THE LAST EPISODE. *TR

AS I HIT SPEEDS OF 65+ MPH, IF I HIT ANY ROUGH SURFACE, BRIDGE ABUTMENT, OR SMALL POT HOLE THE TRUCKS FRONT END WOULD PROCEED TO SHAKE VIOLENTLY OUT OF CONTROL ONLY STOPPING AFTER I BROUGHT THE TRUCK TO A COMPLETE STOP ON SIDE OF HIGHWAY. GOT BACK ON HIGHWAY AND EXACT SAME PROBLEM HAPPENED 1.5 MILES FARTHER UP ROAD. SHAKE IS SO VIOLENT I CAN HARDLY MAINTAIN CONTROL OF THE VEHICLE TO EVEN BRING IT TO A STOP. *TR

MY F250 SUPER DUTY TRUCK STALLS WHILE DRIVING, SPECIALLY AFTER TURNING CORNER. ALL 3 TIMES THE COMPLETE FUEL INJECTOR ASSEMBLY WAS REPLACED , 5/15/07, 12/15/07 & 8/15/07. HAD FUEL TANK CLEANED AND FOUND RUST REMAINS IN BOTTOM OF FUEL TANK. THE COMPUTER AND WIRE HARNESS HAD TO BE REPLACED 12/15/07. FUEL TANK RUSTS FROM INSIDE AND BLOCKS FUEL LINE FROM FUEL TANK AND WATER SEPARATOR AND CONSEQUENTLY STARVES INJECTORS FROM FUEL WHICH IS WHY THEY BURN UP. SEE WWW.FORDDOCTORSDTS.COM/ARTICLES/ARTICLE-07-07.PHP. EACH TIME I BRING IN THE TRUCK IT COSTS FOR A TRUCK WITH BETWEEN $1,000-$4,000 WITH ONLY 110,000 MILES ON THE TRUCK. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SD. WHILE DRIVING 55 MPH, THE VEHICLE SURGED TO 60 MPH WITHOUT WARNING AND THEN SHUT OFF. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE AND THE FAILURES WERE INTERMITTENT. AS OF DECEMBER 12, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 64,045 AND CURRENT MILEAGE WAS 64,055.

1. ANNUAL VIRGINIA STATE SAFETY INSPECTION. 2. FRONT BALL JOINTS FAILED INSPECTION, 2005 FORD F-250 4X2 SUPER DUTY PICK UP WITH 50,000 MILES. 3. BALL JOINTS REPLACED. *TR

A SUDDEN LOSS OF ELECTRICAL SYSTEM COMPONENTS WHILE OPERATING ON THE HIGHWAY. ABS WARNING LIGHT CAME ON FOLLOWED DIMMING OF LIGHTS AND REDUCTION OF WINDSHIELD WIPER SPEED AND AN INCREASE IN RPMS NOT INITIATED BY THE OPERATOR. *TR

2005 F-250 SUPERDUTY LARIAT 4 DOOR 4X4 VIOLENT SHAKING WHEN HITTING ROUGH ROADS. *TR