2005 FORD F-250 SD Complaints

TRUCK BECAME HARD TO START THEN STARTED STALLING. SOON AFTER THE CHECK ENGINE LIGHT CAME ON. TRUCK WAS TAKEN TO FORD DEALER WHERE IT WAS COMPUTER TESTED AND INSPECTED. THE FICM (FUEL INJECTOR CONTROL MODULE) WAS REPLACED AND REPROGRAMMED THE MODULES AT A COST OF 1,253.67. *TR

BOTH REAR BRAKES BURNING, THEN LEFT FRONT. LOSS OF BRAKING. BROUGHT TO DEALER TO HAVE REPAIRED. AFTER HAVING IT REPAIRED ( NOT COVERED UNDER EXTENDED OR OTHER WARRANTY AND SPENDING $1100.00) I WAS TOLD IT WAS DUE TO NOT DRIVING THE TRUCK ENOUGH. DROVE THE TRUCK THE NEXT DAY AND THE RIGHT REAR BRAKE WAS BURNING AGAIN AND LOST ALL BRAKES. AGAIN TOWED BACK TO THE DEALERSHIP AT WHICH POINT IT WAS EXPLAINED TO ME THAT THE MODEL YEAR 2005 HAS HAD A PROBLEM WITH THE BRAKES FREEZING IN THE CALIPERS CONSISTENTLY, HOWEVER FORD HAS NOT HAD ANY RECALLS. I WAS ALSO ADVISED THERE HAS BEEN A RE-DESIGN OF THE BRAKE PADS, WHICH MY ORIGINAL PADS HAD NOT CHANGED, BUT STILL HAD BRAKE MATERIAL. *TR

2005 F250 DIESEL. TRANSMISSION WOULD SHIFT ONTO REVERSE BUT WOULD BACK UP. TOOK IT TO FORD THEY TOLD ME REVERSE SNAP RING BROKE AND CRACKED TRANSMISSION CASE. 3900 TO FIX. FORD HAS A RECALL ON SNOW PLOW PACKAGES BUT MINE IS NOT JUST HAS THE EXACT SAME TRANSMISSION. *TR

2005 FORD F-250 SUPER DUTY, 69,000 MILES. TRAVELING APPROX 65 MPH, HIT A SMALL BUMP IN THE HIGHWAY AND THE FRONT SUSPENSION STARTED TO SHAKE UNCONTROLLABLY. I VERY NEARLY LOST COMPLETE CONTROL OF THE TRUCK. THIS NEVER HAPPENED BEFORE, BUT HAS HAPPENED TWICE SINCE. THE TIRE PRESSURE WAS CORRECT AT THE TIME OF THE FIRST INCIDENT, THE TIRES WERE BALANCED AND THE LUG NUTS WERE TORQUED TO FORD SPECS. REPLACED FRONT STEERING DAMPER, DID NOT RESOLVE THE PROBLEM. TALKED TO THE FORD DEALER AND THEY DENIED ANY KNOWLEDGE OF A SIMILAR PROBLEM. AFTER A FEW HOURS RESEARCH ONLINE, THIS PROBLEM IS WELL DOCUMENTED AND FREQUENT WITH THE FORD SUPER DUTY LINE FROM 05"-08". IT SEEMS TO BE AN ENGINEERING DEFECT AND FORD IS WELL AWARE OF THE PROBLEM, BUT IT DOES APPEAR THAT FORD HAS OFFERED ANY REMEDIES. THE NHTSA ALSO KNOWS OF THE PROBLEM. I VIEWED FOUR NHTSA VIDEOS THAT DEMONSTRATED THE IDENTICAL PROBLEM THAT I AM EXPERIENCING WITH MY TRUCK. I HAVE FOUND NO ACTION ON THE PART OF THE NHTSA. THIS PROBLEM NEEDS TO BE ACKNOWLEDGED AND CORRECTED BEFORE SOMEONE IS KILLED. *TR

TL* THE CONTACT OWNS A 2005 FORD F250 SUPERDUTY DIESEL. THE CONTACT STATED THAT THE ENGINE WOULD NOT START. THE ENGINE WOULD ONLY START WHEN FUEL WAS ADDED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE WHERE THE DEALER REPLACED THE FUEL INJECTORS BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS NOT FURTHER REPAIRED AND THE MANUFACTURER WOULD NOT ASSIST WITH THE REPAIR. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 115,000 AND THE CURRENT MILEAGE WAS 121,000.

2005 FORD F-250 SUPER CAB SUPER DUTY WOBBLE DANGEROUSLY WHEN DRIVING OVER THE SLIGHTEST RIPPLE OR BUMP IN THE ROAD OVER 50 MPH. EXTREMELY HARD TO CONTROL AND HARD TO STOP THE VEHICLE WHEN THE FRONT TIRES ARE SO OUT OF CONTROL AND WOBBLING. THE WHOLE TRUCK IS LIKE IT IS IN AN EARTHQUAK, WINDSHIELD CRACKS AND CUP HOLDERS FELL OUT. **TT

TL* THE CONTACT OWNS A 2005 FORD F250 SUPER DUTY. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE CONTACT DISCOVERED THAT FLAMES WERE COMING FROM UNDER THE VEHICLE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITHOUT THE ASSISTANCE OF THE FIRE DEPARTMENT. THE VEHICLE WAS THEN TOWED TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE FIRE BEGAN DUE TO TRANSMISSION FLUID LEAKING ONTO THE ENGINE MANIFOLD. THE TECHNICIAN STATED THAT THE WIRING HARNESS AND TRANSMISSION NEEDED TO BE REPLACED. THE WIRING HARNESS WAS REPLACED YET THE TRANSMISSION WAS NOT. THE VEHICLE WAS N OT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2005 FORD F250 SUPER DUTY. THE CONTACT HEARD A LOUD SQUEALING FROM THE VEHICLE. HE THEN INSPECTED THE VEHICLE AND DISCOVERED THAT THE REAR PASSENGER SIDE BRAKE DRUM WAS RUSTED. THE DEALER ADVISED THE CONTACT TO INFORM THE MANUFACTURER OF THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT TO HAVE THE VEHICLE TOWED TO THE LOCAL DEALER FOR DIAGNOSTIC TESTING. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 95,000 AND THE FAILURE MILEAGE WAS 94,000.

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. THE CONTACT STATED THE VEHICLE WAS INTERMITTENTLY EXPERIENCING FUEL SYSTEM FAILURES. THE CHECK ENGINE LIGHT WOULD INTERMITTENTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON VARIOUS OCCASIONS IN WHICH THE FUEL INFORMATION COMPUTER MODULE, EGR COOLER, FUEL INJECTOR PRESSURE RELAY AND THE INTER COOLER WERE REPLACED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 90,000.

FRONT ENDS STARTS TO WOBBLE STEERING WHEEL JERKS, IF HANDS AREN'T TIGHT ON STEERING WHEEL COULD PULL YOU OFF ROAD OR INTO ONCOMING TRAFFIC, ANYTIME YOU HIT UNEVEN ROAD OR BUMPY ROAD, TO CORRECT SLOW SPEED WAY DOWN IT WILL STRAIGHTEN UP. *TR