2015 FORD F-250 SD Complaints

When driving (Once going downhill 6% grade, several times driving level on the freeway and once on a 45 MPH road with ruts), the front end began shaking violently to the point I was losing control of the vehicle until I slowed down. The vehicle would be available for inspection upon request. Safety was impacted by the loss of control resulting from the vehicle violently shaking. I took the truck to a mechanic and he could not see any problems. Other than my mechanic, no one has inspected the vehicle. There were no warning lamps, messages, or symptoms prior to the event. I have dash cam video of the event.

Truck started to wobble/shake aggressively. Did some research and read about this situation called the “death wobble”. This is the second time it’s happened

The contact owns a 2015 Ford F-250. The contact was exiting a highway ramp at approximately 60 MPH when the check engine and reduced engine power warning lights illuminated. The contact pulled over, stopped the vehicle, turned off, and restarted the vehicle to reset the warning lights. The contact stated that the warning lights again became illuminated, and the vehicle started to lose motive power. The contact was able to safely reach his destination and later the vehicle was taken to an independent mechanic where the vehicle was diagnosed, and it was determined that the fuel pressure sensor needed to be replaced. The vehicle was test-driven and several unknown warning lights were illuminated. The vehicle was driven back to the mechanic who drained a fuel line and discovered metal shavings in the line. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 284,000.

The contact owns a 2015 Ford F-250. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the diesel particulate filter (DPF) had failed, and the failure was related to Ford Campaign Number: 20M06-2. The vehicle was then taken to the dealer, who informed the contact that the vehicle was not covered under the Campaign. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 111,000.

The contact owns a 2015 Ford F-250. The contact stated while driving 60 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer who stated that the exhaust gas temperature sensor needed to be replaced. The contact was informed that the vehicle was experiencing the failure listed in Technical Service Bulletin: 15M02. The contact was informed that the vehicle was out of warranty. The vehicle was repaired. On another occasion while driving 60 MPH, the diesel exhaust fluid low warning light illuminated. The contact was able to pull over and added more exhaust fluid, but the warning light illuminated again. The vehicle was taken to an independent mechanic and the contact was informed that the knock sensor needed to be replaced and the contact was referred to the local dealer. The vehicle was taken to the dealer and it was confirmed that the knock sensor needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that the vehicle was not under warranty. The failure mileage was 69,361.

The contact owned a 2015 Ford F-250. The contact stated while starting the vehicle in his garage, the RPM raised to 500 before the vehicle turned off. The contact stated on the third attempt to turn on the vehicle the engine exploded and caught fire. The contact stated no warning light was illuminated. The contact stated he was blown out of the vehicle. The contact did not sustain any injuries nor sought medical attention. The contact stated the vehicle was engulfed in flames and also burned down his residence. The fire department extinguished the fire on the residence and the vehicle. A fire report was filed. A police report was filed. The insurance company deemed the vehicle a total loss. The vehicle was towed to an auto shop. The vehicle was not diagnosed. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was approximately 38,000.

The contact owns a 2015 Ford F-250. The contact stated while driving 55 MPH, the vehicle went into "Reduced Engine Power” mode and decelerated to 20 MPH. The contact pulled over to the side of the road. The vehicle was towed to a certified mechanic who diagnosed that the fuel system had failed. The fuel pressure regulator was replaced however, the vehicle remained in "Reduced Engine Power" mode. The vehicle was taken to the dealer who diagnosed that the fuel pressure regulator failed again and needed to be replaced. The contact informed the dealer that the fuel pressure regulator had been previously replaced. The dealer re-inspected the vehicle and informed the contact that the fuel tank was rusted, and the fuel pump, injector pump, and fuel system needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 101,000.

My truck has what is known as the death wobble. I am having it repaired again because if I hit a bump while I'm driving down the road, it'll jerk over into other people's lanes almost hitting other cars. It's horrible this is the second or third time I've had to repair this and is a well-known issue between 2007 and 2019. Can something please be done about this? This is starting to get a little ridiculous that there's so many cars out there that are this unsaved over the fact that a company doesn't want to pay to fix them

This vehicle, like many others has a severe death wobble. I almost lost complete control of the vehicle on the freeway at 75MPH after hitting a pothole! I replaced tie rod ends and took it to the Ford dealer to have it aligned and had them check all other steering components. They only recommended new tires and said everything was tight and didn't need replacement. The tires have over 3/32's wear on them so they could have made it another summer before replacing them. It is at the dealer right now getting new tires but I am afraid this will not fix the actual problem. The problem had been reproduced at the dealer and the mechanic told me it was the worst one he has ever driven. This is a known vehicle defect and Ford will still not do anything to fix the issue since it has not been reported in new vehicles that are exactly the same. There were no messages or symptoms before this occurred and it was the scariest thing I have ever experienced. I am only a 118lb Female and it was almost impossible to control the vehicle

The truck has “death wobble“ or steering oscillation. When travelling on any road between 55 and 75 miles per hour, the truck will shake violently when you cross a bridge, train tracks, or imperfections in the road. You must nearly come to a complete stop as quickly as possible. It is difficult to turn or stop while this is happening. My vehichle has been well maintained and only has 105k miles. The death wobble started at 32k miles and Ford said this was normal. This is very dangerous and unsafe.