2004 FORD F-250 SD Complaints

TL* THE CONTACT OWNS A 2004 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES AND WAS UNABLE TO RESTART. IN OTHER INSTANCES, THE VEHICLE RESTARTED WITH A DELAY AND THE ENGINE WAS SLOW TO GAIN SPEED, BUT LATER ACCELERATED AT A HIGH RATE OF SPEED. DAN COLLINS FORD (541-947-4965, LOCATED AT 351 N O ST, LAKEVIEW, OR 97630) AND CROWN MOTORS (541-947-4965, LOCATED AT 351 NORTH O. STREET, LAKEVIEW, OR 97630) WERE NOTIFIED, BUT WERE UNABLE TO REPLICATE THE FAILURE. IN ADDITION, BLACK SMOKE WAS PRESENT AND THE VEHICLE IDLED HIGH AND LOW. THE VEHICLE WAS NOT REPAIRED AND WAS UNSAFE TO BE DRIVEN. THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 11,686.

TAKARA RECALL I WAS DRIVING DOWN THE FREEWAY WHEN THE CHECK ENGINE LIGHT CAME ON I ALL THE SUDDEN HAD A LOSS OF POWER AND IT WAS LIKE THE MOTOR WAS SPUTTERING LIKE IT HAD A MISFIRE AFTER THAT IT'S VERY HARD TO START AND BARELY MOVES IT COMES UP WITH MULTIPLE INJECTOR CODES THAT ALL FAILED AT THE SAME TIME SOME HIGH SOME LOW

2004 FORD F250 SD 6.0L SPUTTERS, LUNGES & DIES OUT WHEN IDLE, WAITING IN TRAFFIC OR DRIVING SLOWLY. LUCKILY, IT'S BEEN STARTING RIGHT BACK UP. IT HAS BEEN OCCURRING QUITE OFTEN LATELY. LOOKED UP POSSIBLE CAUSES AND FOUND RECALL 05V270000 FROM 2005, WHICH SEEMS TO BE THE EXACT ISSUE I AM HAVING. CALLED FORD AND WAS TOLD THERE ARE ZERO RECALLS PERTAINING TO THIS TRUCK AND THAT THAT PARTICULAR RECALL DOES NOT INCLUDE MY TRUCK. I HAVE SEEN MANY OF THE SAME COMPLAINTS ABOUT THIS SAME EXACT VEHICLE AND HOW THIS ISSUE HADN'T BEEN COVERED UNDER SAID RECALL. I HAVE THE NHTSA RECALL NO EA05003, BUT IT HAS TIMED OUT AND IS NO LONGER AVAILABLE FOR VIEWING ON THIS SITE. PLEASE REALIZE THAT ALL THESE SAME VEHICLE OWNERS ARE HAVING THE SAME DANGEROUS ISSUE AND IT ISN'T BEING TAKEN SERIOUSLY BY FORD OR THE NHTSA.

CPSC: HEATED SEAT COVER WAS PLUGGED INTO 2004 FORD F250 SUPER DUTY VIA THE DC 12V. THE VEHICLE WAS ON FOR 30. *DT *TR

THE PARKING BRAKES WERE NEVER VERY EFFECTIVE AND DESPITE BEING REPAIRED SEVERAL NOTHING HAS BEEN ABLE TO IMPROVE THEM. THE TRUCK HAS A MANUAL TRANSMISSION AND DISC REAR BRAKES. IT IS DANGEROUS TO PARK IT ON A HILL EVEN IF ITS LEFT IN GEAR.

ON SATURDAY, 6/2/18, MYSELF, HUSBAND AND ANOTHER PASSENGER WERE INVOLVED IN AN INCIDENT IN GOOCHLAND COUNTY, VA. ROAD CONDITIONS WERE NORMAL, NO ROUGH ROAD, POTHOLES AND NO ITEMS IN ROADWAY. WE WERE TRAVELING ON A RURAL, TWO LANE ROAD WITH NO SIDE SHOULDERS(JUST TREES) WHEN OUR LEFT REAR TIRE STARTED VIBRATING AND MAKING A STRANGE NOISE. BEFORE WE HAD TIME TO SLOW DOWN, WE HEARD LOUD BANGING AND CRUNCHING. SEEING AS THERE WAS NO PLACE TO PULL OVER, WE HAD TO STOP AND INVESTIGATE IN THE MIDDLE OF THE LANE. WHAT WE SAW WAS A STILL FULLY INFLATED TIRE, WITH THE TREAD TORN OFF AND FLAPPING. THIS COMPLETELY DESTROYED THE BED AND WHO KNOWS POSSIBLY WHAT ELSE OF OUR TRUCK. THE TIRES HAVE GOOD TREAD LIFE, WERE INFLATED TO THE MANUFACTURER SUGGESTED PRESSURE AND WERE NOT DRY ROTTED OR WORN UNEVENLY. WE HAD TO HAVE THE TRUCK TOWED AN HOUR BACK HOME BECAUSE OF THE CONDITION. I HAVE REACHED OUT TO THE MANUFACTURER AND HAVE NOT BEEN ABLE TO GET ANYWHERE WITH THEM. THIS IS NOT A FLUKE, SEEING AS I AM NOT THE ONLY ONE COMPLAINING ON HERE ABOUT THIS ISSUE. WE WERE EXTREMELY LUCKY THAT WE WERE NOT INJURED OR EVEN KILLED. OUR TIRES ARE 33X12.50X16.5 BF GOODRICH ALL TERRAIN T/A KO. PICTURED BELOW IS THE PROOF OF TIRE TREAD SEPARATION AND DAMAGE DONE TO MY VEHICLE.

TL* THE CONTACT OWNS A 2004 FORD F-250 SD. AFTER PARKING THE VEHICLE AND ATTEMPTING TO EXIT, THE VEHICLE BEGAN TO ROLL BACKWARDS. THE CONTACT WAS ABLE TO DEPRESS THE BRAKE PEDAL TO STOP THE VEHICLE, AND APPLIED THE EMERGENCY BRAKE. IT WAS LATER DISCOVERED THAT THE EMERGENCY BRAKE WOULD NO LONGER FUNCTION. ON ANOTHER OCCASION, THE CONTACT PARKED, TURNED OFF THE ENGINE, AND EXITED THE VEHICLE. UPON RETURNING TO THE VEHICLE, IT WAS DISCOVERED THAT IT HAD ROLLED APPROXIMATELY 30 FEET FROM THE ORIGINAL PARKED POSITION. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 124,000.

"FICM & ICP RECALL" RECEIVED A RECALL NOTICE FROM FORD JULY 2005 IN REGARDS TO FAULTY FICM AND ICP. THE FICM WAS REPAIRED AUGUST 2005 BY A FORD DEALERSHIP. NOTE, WE DID NOT HAVE ANY ISSUES WITH THE TRUCK PRIOR TO THE FIX. JANUARY 2006 WE HAD TO TAKE THE TRUCK INTO THE SHOP DUE TO THE ENGINE RUNNING ROUGH WHILE IDLING AND ACCELING; THE FICM WAS REPLACED DUE TO A SHORT; THE ISSUE THAT WAS JUST FIXED ON THE TRUCK. THE TRUCK HAS BEEN IN THE SHOP 5 TIMES SINCE JANUARY 2006 AND HAS COST US OVER $11,000 OUT OF POCKET TO TRY AND RESOLVE THIS ISSUE THAT STARTED AFTER THE INITIAL RECALL FIX. WE HAVE CONTACTED FORD HDQRS AND THEY ADVISED TO TAKE THE TRUCK INTO THE DEALERSHIP WHICH WE DID MULTIPLE TIMES. OVER THE LAST FEW MONTHS THE SURGING HAS BECOME INCREASINGLY WORSE. WHILE TRAVELING IN HEAVY TRAFFIC ON I5 PULLING A 30' 5TH WHEEL TRAILER, THE TRUCK SURGED FORWARD UNEXPECTEDLY JUST MISSING THE CAR IN FRONT OF US. A FEW WEEKS AGO I WAS STOPPED AT AN INTERSECTION, WHEN I BEGAN TO TAKE MY FOOT OFF THE BRAKE TO MOVE FORWARD THE TRUCK SURGED FORWARD 3 FEET. I WAS LUCKY THERE WASN'T ANOTHER CAR CLOSE OR A PERSON IN THE STREET. JUST THE OTHER DAY I WAS PARALLEL PARKING AND WHEN I TOOK MY FOOT OFF THE GAS TO BACK UP A LITTLE THE TRUCK SURGED BACKWARD ALMOST HITTING THE CAR IN BACK OF THE TRUCK. THE TRUCK ALSO STALLS JUST BEFORE COMING TO A COMPLETE STOP OCCASIONALLY. THIS ISSUE HAS BECOME EXTREMELY DANGEROUS IN THAT I DON'T FEEL SAFE DRIVING THE TRUCK. I LOOKED INTO THE CALIFORNIA LEMON LAW AND IT SOUNDS LIKE THE TRUCK MIGHT BE COVERED UNDER THIS. WE NEED TO GET RID OF THIS TRUCK BUT FEEL FORD DOES NOT STANDS BEHIND THEIR PRODUCT. I HAVE ATTACHED THE RECALL NOTICE AND SOME OF THE RECEIPTS FOR THE REPAIRS DONE TO THE TRUCK JUST IN REGARDS TO THIS SURGING ISSUE. I WAS ONLY ABLE TO ATTACH 5 DOCUMENTS BUT HAVE MANY MORE IF NEEDED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THIS IS THE 8TH SEPARATION OUT OF 11 TIRES THEY HAVE ALL HAPPENED AFTER ABOUT 2 HOURS OF HIGHWAY DRIVING THIS ONE BLOW AND CAUSED ABOUT 2300 DOLLARS OF DAMAGE TO MY TRUCK NOT INCLUDING THE TIRE 3 MILES SOUTH OF IOLA KANSAS COMING FROM INDEPENDENCE MISSOURI IT GAVE ABOUT 3 TO 5 SECONDS OF BOBBLE AND AS I APPLIED THE BRAKES TO PULL OVER IT BLEW. THIS CAUSED THE TRUCK TO GO INTO THE ON COMING TRAFFIC AND I WAS JUST ABLE TO GET CONTROL OF THE TRUCK AND GET IT OFF THE ROAD.BF GOODICH CLAIM THERE IS NOT A PROBLEM WITH THIS TIRE BUT I HAVE DISCOVERED WHY THEY SAY THAT. THIS SIZE OF TIRE USUALLY IS PURCHASED FOR JEEPS AND SMALL PICKUP WEIGHING 3000 TO 4000 POUNDS BUT IS RATED FOR E LOAD WHEN YOU USED THE TIRE ON A LIGHTER VEHICLE IT DOES NOT HEAT UP BUT MY PICKUP IS 9000 LBS. BEFORE THIS LAST TRIP I HAD COSTCO CHECK THE TIRES AND AIR PRESSURE THE DAY BEFORE THE TRIP AND I CHECKED THEM ON THE DAY OF THE TRIP. SO I KNOW THEY WERE AIR TO THE REQUIRED PRESSURE. I BELIEVE THE TIRE MUST BE RECALLED AND LOAD RATED NO HIGH THAN C

DRIVING ON THE HIGHWAY , COMPLETE LOSS OF THROTTLE BUT THE ENGINE WAS STILL RUNNING AT A LOW AMPERAGE. WAS ABLE TO PULL OFF THE ROAD AND TURNED IT OFF. IT WOULDN'T START BACK UP RIGHT AWAY. HAD TO WAIT A WHILE IT WOULD START AND LIMPED IT HOME. NO PROBLEMS FOR A FEW DAYS, THEN IT STARTED ACTING UP AGAIN. A COUPLE TIMES IT WOULD START, BUT AT A LOW IDLE WITH NO RESPONSE OF THE GAS PEDDLE. THE FINAL STRAW WAS LAST WEEK. I WAS DRIVING ON THE HIGHWAY TO WORK. EACH TIME I CAME TO A STOP, IT WOULD LOSE THROTTLE. I WAS ABLE TO TURN IT OFF AND BACK ON TO GET GOING. THEN AT A MAJOR INTERSECTION OF HWY 41 AND 145, IT WOULDN'T TURN BACK ON AND I WAS IN THE MIDDLE OF THE HWY. I HAD TO PUSH IT TO THE SIDE OF THE ROAD AND IT WOULD TURN BUT NOT START. I HAD IT TOWED TO MY MECHANIC ON SATURDAY AND MONDAY WHEN THEY GOT TO IT, AFTER CHARGING THE BATTERIES, IT STARTED RIGHT UP AND THEY HAVEN'T BEEN ABLE TO GET IT TO FAIL...WHEN THIS HAPPENS, THERE IS NO OIL PRESSURE ON THE GAUGE. THIS IS DANGEROUS AND POTENTIALLY HAZARDOUS OR DEADLY. I COULD HAVE EASILY BEEN INJURED OR KILLED IF I HAD BEEN HIT.