2000 FORD F-350 Complaints

DT: THE STEERING SHAFT (POWER STEERING GEAR BOX OUTPUT SHAFT) SNAPPED OFF WHILE APPROACHING A STOP SIGN AT ABOUT 35 MPH. WHEN THIS HAPPENED THE VEHICLE DID STOP WITH NO ACCIDENT. I AM IN THE PROCESS OF FIXING THIS PROBLEM. *TT

WHILE DRIVING AT A REDUCED SPEED ON THE INTERSTATE FREEWAY, BECAUSE OF RAIN, I STARTED TO EXPERIENCE A VIBRATION FROM THE TIRES. AT THE FIRST OPPORTUNITY I PULLED OFF INTO A REST AREA TO CHECK THE TIRE PRESSURE THINKING THAT I HAD A TIRE THAT WAS GOING FLAT. I MEASURED THE AIR PRESSURE IN ALL 4 TIRES ON MY 2000 FORD F-350. I MEASURED 60LBS IN THE FRONT AND 70LBS IN THE REAR. I INSPECTED THE WHEELS TO SEE IF THERE WAS ANY APPARENT PROBLEM WITH THE TIRE BUT I COULDN?T FIND ANYTHING. I DEDUCED THAT THE VIBRATION MIGHT BE A RESULT OF THE TIRE THROWING A BALANCING WEIGHT AND I DECIDED TO CONTINUE ON MY JOURNEY SINCE I COULDN?T FIND ANY PROBLEM. ABOUT 8 MILES FURTHER UP THE ROAD I SUFFERED A TREAT SEPARATION FROM THE TIRE WHICH CAME ACTUALLY CAME OFF THE TIRE. THE TIRE DID NOT LOSE AIR IMMEDIATELY AS A RESULT OF THE FAILURE (IT DID HAVE A SLOW LEAK THAT DRAINED THE TIRE AFTER ABOUT 6 HOURS). I WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE THROUGH THE ENTIRE INCIDENT AND COULD SAFELY DRIVE IT UNTIL I COULD FIND A SAFE PLACE MILE FURTHER UP THE ROAD WHERE I REPLACED THE DAMAGED TIRE. THE RESULTING INCIDENT DAMAGED THE FENDER AREA OF MY VEHICLE AND WILL REQUIRE PROFESSIONAL REPAIR. AS I MENTIONED EARLIER I WAS DRIVING AT A REDUCED SPEED FOR THIS SECTION OF THE INTERSTATE FREEWAY BECAUSE OF HEAVY RAIN AND AT NO TIME DID MY SPEED EXCEED 60MPH. THE AIR TEMPERATURE FROM THE TIME I FIRST NOTICED THE PROBLEM UNTIL THE FAILURE WAS 43 TO 38 DEGREES. *AK

WHILE DRIVING 5-70 MPH CONSUMER LOST POWER STEERING/BRAKING. CONSUMER MANAGED TO PULL OVER, AND HAD THE VEHICLE TOWED. DEAALERSHIP REPAIRED THE POWER STEERING AND BRAKE COMPONENTS, BUT THE CONSUMER WAS STILL HAVING THE SAME PROBLEMS. *AK

WHILE DRIVING AT APPROXIMATELY 40 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A HEAD ON COLLISION WITH ANOTHER VEHICLE. UPON IMPACT, THE SEAT BELT FAILED TO RESTRAIN THE DRIVER CAUSING THE DRIVER TO HIT THE WINDSHIELD. DRIVER SUSTAINED INJURIES. *AK

BOTH PASSENGER AND DRIVERS SIDE AXLE SEALS ON FRONT REAR ARE HANGING OUT OF END OF AXLES. DRIVERS SIDE IS LEAKING OIL.DEALER ALREADY REPAIRED THIS PROBLEM ONCE AT 30K NOW IT IS MY COST PARTS COUNTER SAID FORD REDESIGNED SEALS BECAUSE OF SO MANY PROBLEMS

PURCHASED TIRES FROM COSTCO FOR THE BACK OF MY PICKUP. THEY PLACED 82.5 PSI IN THE REAR TIRES OF A EMPTY PICKUP...AS DIRECTED BY MICHELIN. THIS CREATED A VERY SERIOUS SAFETY ISSUE AS THE TRUCK DID 3 REVOLUTIONS DOWN THE FREEWAY DUE TO SEVERELY CROWNED TIRES. SOMEONE HAS TO STOP THIS RECOMMENDATION OR SOMEONE IS GOING TO BE HURT/KILLED. THIS IS A COMMON SENSE ISSUE THAT NEITHER COSTCO OR MICHELIN WILL ADDRESS. I WOULD LIKE A RESPONSE TO THIS EMAIL IF POSSIBLE. THIS PRACTICE HAS TO BE STOPPED, PLEASE REVIEW WITH YOUR ENGINEERS. THANK YOU DON PREUITT. *JB

CONSUMER STATED FRONT RIMS CRACKED. AS A RESULT, THE TIRES WERE LOSING AIR. *AK...RIMS CRASHED AT BASEOF SPOKE, RESULTING IN LOSS OF AIR. ACCORDING TO MANUFACTURER THESE RIMS WERE RATED AT 2440 LBS EACH, 4880 LBS TOTAL CAP ON FRONT. TRUCK RATED AT 5200 LBS FRON GUW-ACTUAL WEIGHT WITH ONE PASSENGER IS 4960 LBS, RESULTING IN RIMS OPEATING IN OVERLOADED CONDITION BEFORE ANY LOAD AT ALL IS PLACED IN OR ON TRUCK. DEALER CAN'T DO ANYTHING. *AK

2000 FORD F 350. CLUTCH WILL NOT DISENGAGE DRIVELINE WHEN DEPRESSED. 2 ND FAILURE OF SUCH NATURE. VEHICLE WILL KEEP ROLLING IN CURRENT GEAR AND SPEED WHEN CLUTCH IS DISENGAGED. CAN DO NOTHING BUT STALL THE ENGINE BY HARD BRAKING OR TURNING OFF THE KEY BOTH CREATE OTHER DANGERS. FIRST FAILURE HAPPENED AT 38K MILES SECOND AT 52K. PAID FOR FIRST REPAIR OUT OF POCKET- SAID TO BE THE CLUTCH MASTER CYLINDER BOOT RIPPING WHILE UNDER PRESSURE. SEEKING FORD TO FIX THIS TIME. FORD DEALERSHIPS IN NORFOLK VA AND KNOXVILLE TN DENY THAT THIS IS A SAFETY ISSUE. I DO NOT UNDERSTAND THEIR LOGIC. *AK

THE CONSUMER WAS INVOLVED IN A FRONTAL COLLISION WITH A ELEVATED CRANE PILLAR WHILE DRIVING 20-30 MPH AND NEITHER AIR BAG DEPLOYED. THE DRIVER AND THE PASSENGER WERE BOTH RESTRAINED IN THEIR SEAT BELT. THE DRIVER RECEIVED MINOR INJURIES, BUT THE PASSENGER WAS TRANSPORTED TO THE LOCAL HOSPITAL BY AMBULANCE DUE TO HEAD INJURIES. THE DEALER WAS NOT NOTIFIED. *JB

2000 F350 7.3 DIESEL - CAM POSITION SENSOR FAILED, SHUTTING DOWN ENGINE. LUCKILY VEHICLE HAD JUST PULLED OUR OF DRIVEWAY AND WAS ABLE TO GET TO SIDE OF ROAD. THE ENGINE RESTARTED AFTER 10 MINUTES BUT DIES AGAIN AFTER A FEW SECONDS. CAM POSITION SENSOR WAS REPLACED, SOLVING PROBLEM. EMPLOYEE AT DEALERSHIP UNOFFICALLLY SAID THIS WOULD PROBABLY HAPPEN AGAIN IN APPX. 40,000 MILES. THIS TRUCK IS USED TO PULL HORSE TRAILERS ON THE INTERSTATE. IF THIS IS GOING TO BE A REPEAT OCCURANCE, I DON'T WANT MY FAMILY OR MYSELF IN THE TRUCK IF THIS HAPPENS ON THE INTERSTATE AT 70MPH. I NO LONGER FEEL SAFE IN THIS TRUCK.*AK