1996 FORD F-350 Complaints

TL*THE CONTACT OWNS A 1996 FORD F-350. WHILE PARKED, THE VEHICLE BURST INTO FLAMES. THE FIRE DEPARTMENT ARRIVED AND STATED THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT. A POLICE REPORT WAS FILED. IN JANUARY OF 2006, AFTER THE FIRE OCCURRED, THE CONTACT RECEIVED HER FIRST RECALL NOTICE FOR THE VEHICLE SPEED CONTROL. THE RECALL NUMBER WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 140,000.

1/07 SQUEAK IN FRONT LEFT WHEEL, TOOK TO SEARS AS BRAKES/BEARINGS UNDER WARRANTY. ENDED UP W/ COMPLETE BRAKE JOB FRONT & REAR. PICKED UP VEHICLE, POOR PEDAL PRESSURE, NO E-BRAKE. TOOK BACK TO SEARS THEY ADJUSTED. IN APRIL HAD REAR BRAKES FAIL TO STOP VEHICLE WHILE PULLING HORSE TRAILER. ONLY FRONT BRAKES ENGAGED. TOOK BACK COULDN'T FIND A PROBLEM. TOOK TO ANOTHER SHOP THEY FOUND ONLY PADS REPLACED ON RT REAR NOT ON LEFT. THEY DID COMPLETE BRAKE JOB ON REAR (NEW DRUMS AND PADS) TOOK IN 2 WEEKS LATER STILL NOT CORRECT AND HAD VIBRATION WHEN BRAKING. ENDED UP WITH RE-SURFACE OF FRONT ROTORS AND NEW PADS. 7/29/07 PULLING HORSE TRAILER REAR ENDED VEHICLE ON 19TH AVE IN SF DUE TO REAR BRAKES NOT ENGAGING AT ALL. ONLY FRONTS ENGAGED. REAR BRAKES NOT WORKING AT ALL. *JB

TL*THE CONTACT OWNS A 1996 FORD F-350. HE STATED THAT HE STARTED HIS VEHICLE AND NOTICED SMOKE COMING FROM UNDER THE HOOD. HE ALSO NOTICED FLAMES COMING FROM UNDER THE HOOD WHEN HE OPENED IT. THE CONTACT WAS ABLE TO PUT THE FIRE OUT WITHOUT CONTACTING THE FIRE DEPARTMENT. THERE IS A RECALL FOR THE VEHICLE SPEED CONTROL (RECALL #06V286000) WHICH STATED THERE COULD BE SMOKE AND FIRE COMING FROM UNDER THE HOOD. THE MANUFACTURER STATED THAT HIS VEHICLE WAS NOT INCLUDED AS PART OF THE RECALL. THE CURRENT AND FAILURE MILEAGE WAS 106,000. THE VEHICLE PURCHASE DATE WAS UNKNOWN.

DT*: THE CONTACT STATED THE VEHICLE SPEED CONTROL SENSOR CAUGHT ON FIRE. THE MANUFACTURER STATED THE VIN NUMBER WAS NOT INCLUDED IN THE VEHICLE SPEED SENSOR RECALL (06V286000) BECAUSE THE VEHICLE HAD A DIESEL ENGINE. THE VEHICLE CAUGHT FIRE FIVE MINUTES AFTER THE VEHICLE WAS PARKED AND THE SERVICE DEALER DETERMINED THIS WAS THE SAME SYMPTOMS THAT LED TO THE RECALL.

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 05V388000 CONCERNING THE VEHICLE SPEED CONTROL DEACTIVATION SWITCH. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN AND MODEL. THE VEHICLE HAS NOT BEEN REPAIRED. *AK

DT: THE CONTACT COMPLAINED ABOUT A BRAKE PROBLEM. THE BRAKE FLUID CAUSED CORROSION ON THE BRAKE FITTINGS. ON AUGUST 7, 2003 THE FRONT BRAKES FAILED WHILE THE VEHICLE WAS GOING UP HILL. THE FORD DEALER REPLACED THE TUBING AND FITTINGS. ON MAY 24, 2004 THE REAR BRAKES FAILED WHILE HE IN A PARKING LOT. AGAIN THE FORD DEALER REPLACED THE TUBING AND FITTINGS. ON NOVEMBER 1, 2005 THE MASTER CYLINDER EXPERIENCED CORROSION AT THE BRAKE FITTINGS, CAUSING THE BRAKES TO FAIL. THERE WAS BRAKE FLUID POURING OUT OF THE FRONT DRIVER SIDE WHEEL. ANOTHER DEALERSHIP DRAINED THE BRAKE SYSTEM AND REPLACED THE LINE. THE PROBLEM HAS NOT RECURRED. *AK UPDATED 11/29/2004 - *NM

INTERMITTENT SHUT DOWN OF THE ENGINE. NEARLY RE-ENDED WHEN VEHICLE JUST STOPPED WHILE GOING THROUGH AN INTERSECTION. THE CAMSHAFT POSOTION SENSOR (CPS) FAILED. THIS IS A WELL KNOWN PROBLEM THAT FORD HAS DONE NOTHING ABOUT. IT'S DANGEROUS. *JB

CRUISE CONTROL RECALL LIST DOES NOT INCLUDE THE FORD F350 TRUCK. MY CRUISE CONTROL QUIT WORKING DURING A ROUTINE SERVICE AT 60,000 MILES. SERVICE PERSONNEL AT BOBBY JONES FORD, AUGUSTA, GEORGIA, HAD APPARENTLY DISCONNECTED THE CRUISE CONTROL BECAUSE OF A FLUID LEAK FROM THE SWITCH. AFTER COMPLAINING, THIS VEHICLE HAD OTHER SWITCH FAILURES (TURN SIGNAL AND IGNITION SWITCHES) THESE SWITCHES WERE REPLACED AT MY EXPENSE, ALSO THE CRUISE CONTROL SWITCH WAS ALSO REPLACED AT THIS TIME (AT MY EXPENSE OF $20.88 PART AND $40.00 LABOR). THIS VEHICLE SHOULD HAVE BEEN INCLUDED IN THE RECALL OF THE OTHER FORD VEHICLES WITH THIS CRUISE CONTROL PROBLEM, RESULTING IN THE POSSIBILITY OF THE VEHICLE CATCHING ON FIRE. *JB

CRUISE CONTROL FAILED TO ENGAGE WHILE DRIVING AT 65 MPH. CONSUMER INSPECTED THE VEHICLE AND NOTICED THAT THE WIRING CONNECTED TO THE SPEED CONTROL DEACTIVATION SWITCH WAS BURNT. CONSUMER WENT TO THE DEALER AND PURCHASED A SWITCH AND INSTALLED IT HIMSELF. CONSUMER EXPRESSED CONCERN THAT THIS COULD CAUSE THE CRUISE CONTROL TO FAIL DISENGAGING INSTEAD OF ENGAGING. *AK

VEHICLE WAS PARKED FOR A FEW MINUTES WHEN ALL OF SUDDEN THE OWNER NOTICED THAT THERE WAS SMOKE COMING OUT OF THE HOOD. HE THEN APPROACHED THE VEHICLE AND PUT THE FIRE OUT BEFORE IT BECAME WORSE. RESULTS INDICATED THAT THERE WAS A SHORT WITHIN THE CRUISE CONTROL SWITCH.*AK