2012 FORD F-350 Complaints

The contact owns a 2012 Ford F-350. The contact stated that on several occasions while driving at various speeds, while driving over a small bump in the roadway, the vehicle began violently shaking. The vehicle was brought to a complete stop, and the shaking stopped. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The manufacturer was notified of the failure. The failure mileage was unknown.

Twice in the last 60 days while driving on the Interstate, once at 75mph and this last time at 60mph my Ford F350 has gone into violent shaking, so much so that I was barely able to contain it. I was able to force it off the road and come to a stop. I had to sit there for several minutes then decided to drive slowly to the off ramp. I was able to drive without any wobble and get off the interstate. I took it the first time to Lynn Wood Automotive in Layton, they kept it for several days and found nothing. The second time I took it to Ed Kennely Ford Service. A few of the service writers gathered around as I explained what happened then were nodding there heads and smiling indicating that they had seen is happen several times. I made an appointment next week on July 11th 7:30 am. This was a very dangerous situation and one that I feel very lucky to have gotten it off the road. THis should be a definite RECALL as lives are being put to risk.

The contact owns a 2012 Ford F-350. The contact stated that while driving approximately 45-50 MPH, the vehicle drove over a bump and experienced the death wobble. The contact pulled over and restarted the vehicle. The contact was able to drive to the residence. The vehicle was taken to the dealer, where it was diagnosed that the tie rods and shock absorbers needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The contact related the failure to Technical Service Bulletin: 05UPF250SW (05-16 Ford F250 / F350 4WD Vehicles with Steering Wheel Oscillation); however, the vehicle was not covered under the TSB. The failure mileage was approximately 98,000.

The contact owns a 2012 Ford F-350. The contact stated while driving 70 MPH, the vehicle lost motive power and the vehicle was smoking. Additionally, the contact noticed a clinging sound coming from the engine compartment. The contact stated that an 18-wheeler that was driving behind the vehicle, almost crashed into the rear of the vehicle. The contact was able to get the vehicle to the shoulder of the road safely and exited the vehicle. The contact stated the vehicle was engulfed with heavy smoke, but a fire was not present. The contact was concerned for her safety. The vehicle was towed to the dealer where it was diagnosed with a failed fuel system. The contact was informed that the fuel system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 116,000.

The upper oil pan is leaking and getting worse. Seems to be happening on all 6.7 motors.

Summary: We purchased a brand new 60000 dollar truck in 2012 or 2013 and was assured by the dealer that it had a warranty to cover any issues until either 100,000 miles or 5-6 years, whichever came first. After 4 years of ownership and around 67,000 miles, the truck started experiencing problems with a high idle and then abruptly shutting off. When taken to the dealer, they couldn't replicate the issues during a brief evaluation. However, a week later, while on the way to the bank, to get cash out for are stay at the hospital to give birth to are 6th child the truck shut off and wouldn't start again. The dealer diagnosed the problem as a faulty high-pressure fuel pump due to water in the fuel and tried to charge the author $15,000 for repairs. The author questioned why the diesel fuel water separator and the second fuel filter system on the truck didn't catch the issue earlier and criticized the dealer for their negligence in ensuring safe and reliable transportation.

The contact owns a 2012 Ford F-350. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to the dealer who replaced the reductant heater however, the failure reoccurred. The contact stated that the first repair was covered under Manufacturer Communication Number: 10137151 (Engine and Engine Cooling). The contact took the vehicle to a certified mechanic who determined the same failure had occurred and a similar repair needed to be completed. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the fix was not covered under warranty. The contact was referred to the NHTSA Hotline. The approximate failure mileage was 56,000.

The contact owns a 2012 Ford F-350. The contact stated while driving at an undisclosed speed, he became aware that the horn was not functioning properly. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the clockspring. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V337000 (Air Bags) however, the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 90,000.

Component; Fuel filter Component Available; Yes Safety; Fuel leak on engine ( Fire Risk ) Reproduced; No Inspected; No Warnings; Smell of fuel/Fuel on ground and water

The contact owns a 2012 Ford F-350. The contact stated while driving approximately 65 MPH, the vehicle drove over a small depression in the roadway and the vehicle started vibrating violently. The contact was able to steer the vehicle however, it was difficult to keep the vehicle in the lane. The contact stated he stopped depressing the accelerator and was tapping the brake pedal to slow the vehicle. The contact stated no warning light was illuminated. The contact stated that after slowing down to 30 MPH, the vibration stopped, and he regained control of the vehicle. The contact stated that the vibration failure had become a recurring failure at various speeds. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the front shocks, steering control arms, and ball joints needed to be replaced. The vehicle was repaired; however, the contact stated that the vibration failure had reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.