1999 FORD F-350 Complaints

THE TRUCK WAS BOUGHT IN CANADA AND SHIPPED TO GERMANY APROX. JUNE 2000. BECAUSE OF MUCH CORROSION AT THE CHASSIS I DECIDED TO REMOVE THE CHEAP BITUMEN PROTECTION AND TO COVER THE CHASSIS WITH SPECIAL PAINTS. DOING THIS, I DISCOVERED, THAT THE IRON BELTS OF THE FUEL TANK WAS COMPLETELY ATTACKED BY CORROSION. MAY BE 20 % OF IRON HAD CHANGED INTO FEO. IN THIS MOMENT, THE BELT WOULD NOT HAVE BROKEN, MAY BE 3 OR 5 YEARS LATER. IF MY REPORT IS NOT 100 % CLEAR IT'S BECAUSE ENGLISH IS NOT MY MOTHER LANGUAGE.

1999 FORD F-350. UNIT #1 WAS TRAVELING WESTBOUND IN THE RIGHT HAND LANE ON THE OHIO TURNPIKE. UNIT #1 HAD A RIGHT TIRE BLOWOUT CAUSING THE DRIVER TO LOSE CONTROL AND STRIKE THE GUARDRAIL OFF THE RIGHT SIDE OF THE ROADWAY. UNIT #1 CAME TO A CONTROLLED STOP AFTER STRIKING THE GUARDRAIL. *LN ACCORDING TO THE POLICE REPORT, ALL THE TIRES WERE IN GOOD CONDITION, BUT ALL WERE FROM DIFFERENT MANUFACTURERS AND ALL HAD DIFFERENT READ PATTERNS. THE DRIVER STATED THE TIRE BLOWN TIRE NEEDED TO BE REPLACED. (OHIO TRAFFIC CRASH REPORT # 10-0460-91)*JB

BRAKE LINE RUPTURED WHILE DRIVING. AFTER CHECKING THE METAL BRAKE LINES FOUND ALL TO RUSTED BADLY. *TR

1 OPERATING HOUR AFTER COMING DOWN A 7% GRADE MY 1999 F350 TRUCK WITH CAMPER SUFFERED COMPLETE BRAKE FAILURE DUE TO A CORRODED BRAKE LINE. THE FAULT OCCURRED IN A CLIP WHERE MOISTURE AND ABRASIVES HAD BEEN HELD AGAINST THE STEEL BRAKE LINE. NEARBY DIESEL FUEL LINES EXHIBITED NO RUST. BECAUSE FORD USED STEEL THAT CAN RUST FOR THE CRITICAL BRAKE LINE, MY FAMILY ALMOST LOST OUR LIVES AND POTENTIALLY CAUSED THE DEATHS OF OTHERS. THE REPLACEMENT LEFT PAR OF THE ORIGINAL BRAKE LINE IN PLACE. *TR

TL*THE CONTACT OWNS A 1999 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED IN NOVEMBER 2009 UNDER NHTSA CAMPAIGN ID NUMBER: 06V286000 (VEHICLE SPEED CONTROL). IN MARCH 2010, THE VEHICLE WAS PARKED WHEN IT SUDDENLY CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE YET THEY WERE UNABLE TO DETERMINE THE ORIGIN OF THE FIRE. A FIRE REPORT WAS AVAILABLE. THE VEHICLE WAS DESTROYED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 109,000.

TL*THE CONTACT OWNS A 1999 FORD F350. THE CONTACT STATED THAT THE PASSENGER SIDE REAR DUAL WHEEL STUDS FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY REPLACED THE EIGHT DEFECTIVE WHEEL STUDS. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000. THE VIN WAS UNAVAILABLE.

I NOTICED A STRONG DIESEL SMELL WHILE DRIVING MY 1999 FORD F350 PICKUP TWO WEEKS AGO. UPON INVESTIGATION I FOUND DIESEL HAD SPRAYED ON THE TOP OF THE HOT ENGINE. I TOOK THE TRUCK TO A LOCAL SHOP; THE MECHANIC TOLD ME, "YEAH, WE SEE THIS ALL THE TIME, USUALLY ON TRUCKS OF THIS AGE. IT'S THE FUEL DRAIN VALVE BEHIND THE FILTER CASING." I DO NOT LIKE THE IDEA OF ANY FUEL SPRAYING ONTO THE TOP OF A HOT ENGINE! *TR

I HAVE A 1999 F350 SUPER DUTY DIESEL WITH A 7.3 ENGINE AND MY INSIDE LIGHT DO NOT WORK RIGHT SOME TIMES IT WILL JUST COME ON AS YOU ARE DRIVING DOWN THE STREET AND SOME TIMES IT WONT COME ON WHEN YOU OPEN THE DOOR .THE INSIDE LIGHT IS GETTING WORSE MY TRUCK WOULD JUST STOP RUNNING AS YOU ARE DRIVING DOWN THE STREET OR AT A STOP LIGHT. I WENT INTO THE FUSE BOX UNDER THE STEERING WHEEL AND I THOUGHT IT COULD BE A FUSE COME TO FINE OUT THAT MY RELAY FUSE TO THE INSIDE LIGHT WAS SO HOT THAT IT COULD HAVE STARTED A FIRE SO I PULLED IT OUT NOW I DRIVE AROUND WITH NO INSIDE LIGHTING. *TR

TL*THE CONTACT OWNS A 1999 FORD F350 CREW CAB. AS HE WAS TRYING TO GET OUT OF THE VEHICLE THE REAR PASSENGER AND DRIVER SIDE DOOR WOULD NOT OPEN. THE CONTACT STATED THAT THE PASSENGER HAD TO CLIMB OVER THE FRONT SEAT IN ORDER TO GET OUT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THEY NEEDED TO REPLACE THE CABLES ON THE DOOR. THE CONTACT WAS RESPONSIBLE FOR PAYING THE REPAIR COST OF $600 SINCE THERE WERE NO RECALLS OR WARRANTIES. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 75,000. UPDATED 01/12/11*LJ UPDATED 03/02/11

(THE DEATH WOBBLE) 1999 FORD F-350 4X4 SHAKES VIOLENTLY AFTER HITTING A BUMP BETWEEN 45 TO 70. THE STEERING WHEEL WILL SHAKE OUT OF YOUR HANDS. *TR