1999 FORD F-350 Complaints

FORD F350 V10, MULTIPLE SPARK PLUG EJECTIONS FROM CYLINDER HEADS. HAS HAPPENED MANY TIMES, REINSERTED PLUGS PER "FORDS" RECOMMENDATION, AS IF I WAS UNABLE TO PROPERLY TORQUE PLUGS. NOW I AM LEFT WITH MY FAMILIES TRUCK, STRIPPED HEADS AND NO MONEY TO FIX IT. *TR

DRIVING ON BLACKTOP DIVIDE HIGHWAY AND THE CABLE THAT HOLDS THE SPARE TIRE BROKE (CORRODED THROUGH) LETTING THE SPARE TIRE DROP OUT FROM UNDER THE TRUCK. THE TIRE THEN ROLLED ACROSS THE HIGHWAY AND JUST MISSED HITTING AN ON COMING CAR. THIS IS A COMMON PROBLEM WITH THE SPARE TIRE HOLDER FROM WHAT I READ ON THE INTERNET CHAT ROOMS. *TR

THE BATTERIES ON MY 1999 F350 CREW CAB DUALLY WITH A 7.3 DIESEL WENT DEAD. WHEN I TRIED TO CHARGE THE BATTERIES THE CHARGER SHOWED AN EXTREMELY HIGH DRAW. I HEARD A SOLENOID CLICKING UNDER THE DRIVERS SIDE BATTERY AND THE RADIO WOULD TURN ON AND OFF. I ALSO NOTICED THAT MY HEATER CONTROL WOULD WORK EVEN WITH THE KEY OFF. AFTER TAKING TO THE LOCAL FORD DEALER I WAS TOLD THAT THE WINDSHIELD WAS LEAKING AND WATER HAD DAMAGED THE GEM MODULE AND THE FUSE BLOCK. REPAIR COST TO REPLACE THE GEM MODULE, FUSE BLOCK AND SEAL THE LEAKING AREA WAS $1063.01. WHEN CHECKING THE INTERNET TO SEE WHAT THE GEM MODULE CONTROLLED I FIND THAT THE WATER LEAK IS A KNOW PROBLEM DUE TO A SKIP OR VOID IN THE PRODUCTION SEALER. ACCORDING TO THE FORUMS I HAVE READ THERE ARE MANY MANY TRUCKS WITH THIS SAME PROBLEM. FROM WHAT I FOUND THERE ARE TWO TSB'S ISSUED FOR THE WATER LEAK. THEY ARE TSB 99-2-3 AND 04-23-9. FROM COMMENTS ON THE INTERNET SEVERAL TRUCKS HAVE CAUGHT FIRE AND BURNED UP. FORD APPARENTLY DOESN'T THINK THIS IS A PROBLEM AND HAS NOT TAKEN ACTION TO CORRECT THE PROBLEM NOR WILL THEY ASSIST IN THE REPAIR. *TR

THE DOOR HANDLE ON THE FORD SUPER DUTY AND LOCK MECHANISM ARE PLASTIC. WHICH IN TURNS BREAKS VERY EASILY.THIEVES KNOW THIS AND TARGET THESE VEHICLES AT AN ALARMING RATE. MY SUPER DUTY HAS BEEN BROKEN INTO 3 TIMES IN 4 MONTHS. FORD HAS NO FIX TO STOP THIS DESIGN FLAW. *TR

1999 FORD F-350 WITH A RECALL ON THE CAMSHAFT SENSOR. CONSUMER STATES THAT HE HAS HAD TO REPLACE 2 CAMSHAFT SENOSRS. HE ALSO STATES DUE TO THIS FAILURE HE CARRIES AN EXTRA ONE IN THE GLOVE BOX. *KB

EMERGENCY BRAKE FILL NOT HOLD TRUCK ON A HILL AND CABLE BREAKS EVERY YEAR. HAVE ADJUSTED, REPLACED PEDAL, CABLE, ETC. *TR

TL*THE CONTACT OWNS A 1999 FORD F350. THE VEHICLE HAS COOPER TIRES. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE BEGAN VIBRATING EXCESSIVELY. THE CONTACT PULLED OVER AND NOTICED THAT THE REAR DRIVER SIDE TIRE WAS COMPLETELY SEPARATED FROM THE VEHICLE. HE REPLACED THE TIRE. FOUR WEEKS LATER, THE TREAD SEPARATED FROM THE FRONT DRIVER SIDE TIRE. TWO WEEKS LATER, THE REAR PASSENGER SIDE TIRE EXPERIENCED THE SAME FAILURE. THE MANUFACTURER STATED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06T016000 (TIRES:TREAD/BELT); HOWEVER, ALL THREE TIRES WERE REPLACED. THE VIN, ENGINE SIZE, TIRE LINE AND SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 19,000.

TL*THE CONTACT OWNS A 1999 FORD F350 SUPER DUTY. WHILE DRIVING 44 MPH, THE CONTACT FELT THE AIR PRESSURE BEING RELEASED FROM HIS TIRES. HE PULLED OVER AND NOTICED A CRACK THAT WAS APPROXIMATELY TWELVE TO THIRTEEN INCHES ON ONE OF HIS CAST ALUMINUM RIMS. THE RIM WAS PLACED ON A SIXTEEN INCH TIRE. THE VEHICLE CAME EQUIPPED WITH THE RIM AND ITS SPECIFIC NAME WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 196,800. UPDATED 10/03/07 *TR

TL*THE CONTACT OWNS A 1999 FORD F350 SUPER DUTY. WHILE DRIVING 65 MPH, THE VEHICLE PULLED TO THE RIGHT. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER SIDE TIRE WAS FLAT AND THE RIM WAS CRACKED. HE FELT THAT THE CRACKED RIM CAUSED THE FAILURE. THE DEALER DID NOT INSPECT THE VEHICLE. APPROXIMATELY ONE YEAR LATER, THE VEHICLE PULLED TO THE LEFT WHILE DRIVING 65 MPH. HE INSPECTED THE VEHICLE AND NOTICED THE SAME FAILURES, BUT ON THE DRIVER SIDE TIRE AND RIM. HE BELIEVED ONCE MORE THAT THE CRACKED RIM CAUSED THE FAILURE. AS OF SEPTEMBER 19, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 180,000 AND CURRENT MILEAGE WAS 285,500. THE DEALER INFORMATION IS UNAVAILABLE.

I HAVE HAD 2 STEERING GEAR BOXES BREAK ON MY TRUCK. THE FIRST WAS WHEN MY TRUCK WAS HIT WHILE PARKED. THE INDIVIDUAL HIT THE FRONT OF MY VEHICLE AND DENTED IN THE FRONT BUMPER AND FENDER. IT WAS NOT UNTIL WE WENT TO LOAD THE TRUCK ON THE WRECKER THAT WE DISCOVERED THE BROKEN BOX. THE SECOND TIME I WAS DRIVING DOWN THE ROAD AND THE PERSON IN FRONT OF ME SLAMMED ON THEIR BRAKES TO AVOID AN INDIVIDUAL MAKING A TURN IN FRONT OF THEM. I JERKED MY WHEEL TO THE LEFT TO GO OVER THE CURB AND AVOID THE ACCIDENT BUT WHEN MY TIRES HIT THE CURB IT SHEARED OF THE PITMAN ARM RIGHT BELOW THE STEERING GEARBOX WHICH RESULTED IN ME LOSING MY STEERING. I THEN PLOWED INTO THE VEHICLE INFRONT OF ME WITH NO WAY TO AVOID THEM. THE CURB WAS NOT A VERY BIG ONE AND IT WORRIES ME THAT THIS IMPORTANT PART BROKE SO EASY. *TR