2005 FORD F-350 SD Complaints

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 50 MPH, THE VEHICLE SHOOK VIOLENTLY. THE ENGINE MUST BE TURNED OFF IN ORDER FOR THE VEHICLE TO STOP SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES AND THEY REPLACED THE SWAY BAR. THE FAILURE CONTINUED AND THE DEALER STATED THAT THEY COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER IS AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 49,000 AND CURRENT MILEAGE WAS 83,000.

I WAS SLOWING DOWN TO A STOP LIGHT WHEN MY DRIVERSIDE REAR TIRE WAS SMOKING PROFUSELY. I STOPPED TO CHECK THE PROBLEM OUT AND THE REAR BRAKE WAS LOCKED UP. I SPOKE TO WORKERS AT THE FORD DEALERSHIP AND THEY TOLD ME THIS IS A NORMAL OCCURRENCE WITH THIS PARTICULAR MODEL TRUCK. I REPLACED THE DRIVERSIDE REAR CALIPER AND WENT ON MY WAY. TWO WEEKS LATER THE SAME THING HAPPENED TO THE PASSENGER SIDE REAR CALIPER. THE DEALERS I HAVE SPOKEN TO ONCE AGAIN SAID THIS IS A NORMAL OCCURRENCE AND THAT YOU ONLY GET ABOUT A YEAR OUT OF THE CALIPERS. AT OVER $250 A CALIPER THIS IS VERY EXPENSIVE. I DON'T TOW WITH MY VEHICLE OR ABUSE IT IN ANY WAY. I AM STRICT WITH MAINTAINING IT. *TR

I HAVE A 2005 FORD F350 SUPERDUTY(DIESEL). THE TRUCK HAS AN UNCONTROLLABLE FRONT END VIBRATION/OSCILLATION, WHENEVER I HIT A BUMP IN THE ROAD, USUALLY 50MPH OR FASTER. WHEN IT DOES THIS THERE IS NOTHING THAT I CAN DO TO STOP IT. THE ONLY THING THAT MAKES IT GO AWAY IS TO SLOW DOWN, ALMOST TO A COMPLETE STOP. THIS IS VERY DANGEROUS ESPECIALLY ON THE FREEWAY. I HAVE BECOME AFRAID TO DRIVE ON THE FREEWAY. AS I HAVE DONE SOME RESEARCH ON THIS SUBJECT, I HAVE FOUND THAT MANY PEOPLE ARE HAVING THIS PROBLEM WITH THIS MODEL TRUCK. I AM WORRIED ABOUT MY SAFETY AND THAT OF MY FAMILY. *TR

I OWN A 2005 F350 4X4 CREW CAB POWER STROKE DIESEL TRUCK. I HAD THE TRUCK IN FOR SOME WARRANTY WORK JUST BEFORE IT REACHED OVER 100.00 MILES. I HAD TO HAVE INJECTORS REPLACED. I LATER FOUND OUT THAT THE FUEL TANK WAS DELAMINATING. SILVER PARTICLE AND RUST IS GETTING INTO THE INJECTERS AND CLOGGING FILTERS. I BEEN TOLD THAT FORD IS NOT COVERING THIS PROBLEM AT ALL. THE TRUCK NOW HAS 109,000 MILES AND I NO LONGER HAVE A WARRANTY ON THE INJECTOR. THEY NEVER TOLD ME TILL AFTER THE WARRANTY WAS UP THAT THE FUEL TANKS WHERE FAILING. NOW FROM WHAT I CAN TELL EVERYONE IS HAVING PROBLEMS WITH THERE FUEL TANKS. FORD HAS CLAIMED THAT IT IS THE CAUSED FROM BIO-FUELS BUT I HAVE NEVER PUT A DROP OF BIO-FUEL IN MY TRUCK BEFORE. I ALSO BEEN TOLD THAT IF YOU BUY A NEW TANK IT WILL HAVE THE SAME PROBLEM. MY TRUCK WILL NOT RUN ALL THE TIME AND DIES ON ME OFTEN. I HAVE BEEN CHANGING FILTERS AND NOW THE INJECTORS ARE ACTING AS IF THEY ARE DAMAGED. CAN YOU PLEASE HELP? RICK *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 55 MPH, THE CONTACT DROVE OVER A BUMP IN THE ROAD AND THE STEERING WHEEL BEGAN TO SHAKE VERY BADLY. THE BRAKE PEDAL HAS TO BE DEPRESSED IN ORDER TO STOP THE SHAKING. THE FAILURE OCCURS WITHOUT WARNING AND ALMOST CAUSED A CRASH. THE DEALER INSPECTED THE VEHICLE, BUT FOUND NO FAILURES. THE FAILURE MILEAGE WAS 31,000.

VEHICLE HAS BEEN DIFFICULT TO START, RUNNING ROUGH AND BUCKS AND OFTEN STALLS WHILE DRIVING. VEHICLE WAS RECENTLY TAKEN TO FORD CERTIFIED SERVICE DEPARTMENT FOR FOREMENTIONED ISSUE, AND WAS TOLD THE FUEL TANK LINER HAS DELAMINATED AND RELEASED PARTICLES CAUSING DAMAGE TO THE FUEL PUMP, EIGHT INJECTORS, AND CLOGGED ALL FILTERS. COST OF REPAIRS ARE $5600.00. SERVICE DEPT. ADVISED THERE IS NO RECALL FOR THIS ISSUE EVEN THOUGH THIS IS A COMMON PROBLEM WITH MANY OF THESE TRUCKS. I HAVE ALSO SEARCHED MANY DISCUSSION FORUMS AND FOUND THERE ARE MANY PEOPLE WHO ARE HAVING SAME ISSUES SOME WHO HAVE REPLACED 3 OR 4 TANKS AND OTHER FUEL RELATED PARTS IN THE SAME TYPE VEHICLES. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPER DUTY. IN JANUARY OF 2006, WHILE DRIVING APPROXIMATELY 35 MPH OR MORE, THE VEHICLE BEGAN TO SHIMMY AND JUMP ON THE OPPOSITE SIDE OF THE ROAD WHEN MAKING LEFT TURNS. THE DEALER STATED THAT BOLTS WERE MISSING AND THE SHOCK MOUNTS FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. HE RETURNED THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE TIRES NEEDED TO BE REPLACED. AFTER REPLACING THE TIRES, A FRONT STABILIZER WAS INSTALLED ON THE FRONT END OF THE VEHICLE; HOWEVER, THE FAILURE PERSISTED. THE VEHICLE HAS NOT BEEN REPAIRED SINCE THE LAST INCIDENT. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS AND THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 61,635 AND FAILURE MILEAGE WAS 4,000. UPDATED 10/21/08. *JB

STEERING WHEEL SHIMMY/OSCILLATION (BACK AND FORTH MOTION), IMMEDIATELY FOLLOWING FRONT OR REAR WHEEL IMPACTS (PAVEMENT JOINTS, FROST HEAVES, ROUGH ROADS, ETC). NEAR LOSS OF CONTROL. MUST PULL OFF OF THE ROAD TO SLOW THE VEHICLE TO STOP SHIMMY. *TR

FRONT END SHAKE VIOLENTLY WHEN A POT HOLE OR SETTLED TRENCH IN THE ROAD IS HIT. IT DOESN'T EVEN HAVE TO BE A DEEP OR LARGE POT HOLE. I HAVE TAKEN MY TRUCK INTO THE SHOP AND THE TECH SAID THE FRONT END COMPONENTS LOOK GOOD (TIE-ROD ENDS ECT...). I HAVE CHANGED THE SHOCKS AND STEERING DAMPER AND IT DID NOT HELP. *TR

ODOMETER 23400 WHEN DRIVING ON ROUGH ROAD, CROSSING RR TRACKS, ECT. VEHICLE FRONT END SLAMS UPPER STOP TO LOWER STOPS VIOLENTLY. YOU MUST SLOW TO APX.30-40 MPH. TO REGAIN CONTROL. THERE IS NO LOSS OF STEERING CONTROL, OR BRAKING JUST A VIOLENT "HOPPING OF FRONT WHEELS" . THE VEHICLE SHAKES WILDLY. *TR