2005 FORD F-350 SD Complaints

DRIVING ON INTERSTATE I-85 IN NORTH GA ON SUNDAY, FEBRUARY 24TH TRAVELING 65MPH. REAR DRIVER SIDE TIRE TREAD FLIES OFF. TRUCK ROCKS AND MAKES A LOT OF NOISE. ABLE TO MAINTAIN CONTROL OF VEHICLE AND MOVE TO EMERGENCY LANE. TIRE APPEARS TO HAVE PEELED APART LIKE A BANANA. *DT*JB

DRIVING DOWN THE HIGHWAY I HIT A SMALL BUMP AT 65MPH AND THE ENTIRE FRONT END STARTED VIOLENTLY SHAKING LIKE IT WAS GOING TO FALL APART. HAS HAPPENED TO ME 3 TIMES NOW AND TO MY PREGNANT WIFE 3 TIMES IN ONE TRIP! VERY SCARY AND A SERIOUS ISSUE THAT SHOULD BE RECTIFIED IMMEDIATELY. EXTREMELY DANGEROUS SITUATION AT 60MPH+ OR ANY SPEED REALLY.

2005 FORD F-350. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE FIRE. *SMD ATTORNEY SENT ADDITIONAL CORRESPONDENCE. *LD UPDATED 07/18/2017 *JS

I WAS DRIVING ON A TWO LANE BACK ROAD AROUND 45 TO 50 MPH, AND MY TRUCK STARTED VIOLENTLY SHAKING AND I LOST ALL CONTROL OF STEERING. I WENT INTO THE ONCOMING LANE, LUCKILY NO ONE WAS COMING, AND HAD TO HIT MY BRAKES HARD TO GET THE SHAKING TO STOP. IT HAS ALSO HAPPENED WHILE DRIVING AT SPEEDS OF 35-40 ON A CITY STREET AND 60 MPH ON A HIGHWAY. THIS IS KNOWN AS DEATH WOBBLE. THE WOBBLE WAS SO BAD THAT IT LOOSENED THE TRACK BAR AND THE BOLT HOLDING THE POWER STEERING HARD LINE. I LOST ALL POWER STEERING FLUID WITHIN SECONDS. I HAVE RESEARCHED IT, TRIED REPLACING SEVERAL PARTS, LIKE TIE-RODS, AND IT HAS LESSENED A LITTLE BIT, BUT IF I HIT A BUMPY ROAD OR EVEN JUST A PATCH OF NEW PAVEMENT, IT STARTS SHAKING. I HAVE READ A LOT OF OTHER FORD OWNERS ARE EXPERIENCING THIS SAME ISSUE WITH THEIR TRUCKS.

THE HEAD BOLTS HAVE A KNOWN DEFECT, WHICH FORD FILED A CLASS ACTION SUIT AGAINST THE ENGINE MANUFACTURE NOVASTAR FOR AND WON. THIS DEFECT/WEAKNESS CAN CAUSE THE BOLTS TO FAIL/BREAK CAUSING MANY COMPONENTS TO BECOME DAMAGED. THIS CAN POTENTIALLY CAUSE AN ACCIDENT AND/OR INJURY TO THE VEHICLES OCCUPANTS. I BELIEVE THIS ISSUE NEEDS TO BE ADDRESSED AS A RECALL BECAUSE ACCORDING TO MY RESEARCH ALL OF THE 6.0 DIESEL ENGINES IN THIS YEAR/MODEL ARE AFFECTED.

VEHICLE STALL/DIE WHILE DRIVING WITHOUT ANY WARNING. WHEN THE VEHICLE DIES, UNABLE TO TURN THE STEERING WHEEL AND NO POWER AT ALL. HAVE A RECALL NUMBER 05S34, BUT FORD DEALERSHIP WON'T REPAIR IT BECAUSE MY VIN ISN'T ON RECALL. WHAT SHOULD I DO NEXT?

TIRE FAILURE CAUSING ACCIDENT WITH PROPERTY DAMAGE AND MINOR INJURIES. TIRE WAS THE FRONT LEFT TIRE ON A 2005 FORD F350 4X4 SRW. TIRE HAD APPROXIMATELY 25,000 MILES. ACCIDENT OCCURRED WHILE TOWING A FIFTH WHEEL TOY HAULER TRAILER. TRAILER IS 25' LONG WITH AN APPROXIMATE EMPTY WEIGHT OF 5500 LBS. ALSO IN THE TRAILER WERE PERSONAL EFFECTS INCLUDING ONE MOTORCYCLE WITH AN APPROXIMATE WEIGHT OF 550 LBS. TIRE PRESSURE WAS CHECKED AT 76 PSI COLD 3 DAYS PRIOR TO INCIDENT. ACCIDENT OCCURRED WHILE ON AN INTERSTATE HIGHWAY. THE WEATHER WAS SUNNY WITH TEMPERATURES IN THE 70S TO LOW 80S. SPEED OF VEHICLE AT TIME OF INCIDENT WAS 60-65 MPH. APPROXIMATELY 30 MILES PRIOR TO INCIDENT, A STOP WAS MADE FOR FUEL WITH DRIVER DOING A WALK AROUND VISUAL INSPECTION WITH NO DEFECTS NOTED. LEFT FRONT TIRE BLEW WITH NO ADVANCED WARNING. THIS CAUSED THE VEHICLE TO PULL HARD TO THE LEFT. VEHICLE LEFT THE ROADWAY INTO THE MEDIAN. VEHICLE JACK-KNIFED AND OVERTURNED TO ITS RIGHT SIDE. GUARD RAIL STOPPED VEHICLE FROM ENTERING ONCOMING TRAFFIC. FIFTH WHEEL TRAILER OVERTURNED ONTO ITS RIGHT SIDE. OCCUPANTS OF VEHICLE, ONE ADULT MALE DRIVER AND ONE ADULT FEMALE PASSENGER SELF EXTRICATED VIA THE BACK WINDOW. DRIVER UNINJURED. PASSENGER NOTED MINOR CUTS, 'ROAD RASH', BRUISES AND PAIN TO LEFT WRIST. BOTH OCCUPANTS REFUSED TREATMENT AND TRANSPORT BY EMERGENCY RESPONDING UNITS. UPON INSPECTION, IT APPEARS, TO THE OPINION OF THE DRIVER, THAT THE TIRE FAILED AT THE SIDEWALL NEAR THE BEAD CAUSING A RAPID LOSS OF AIR AND SUBSEQUENT DELAMINATION OF TIRE STRUCTURE. THE TRUCK AND FIFTH WHEEL WAS TOTALLY DAMAGED BEYOND REPAIR. THE FEMALE PASSENGER CONTINUES TO MONITOR INJURIES WITH NO MEDICAL ATTENTION SOUGHT AT THIS TIME. TRUCK AND TRAILER WAS TOWED BY A LOCAL SALVAGE AND RECOVERY COMPANY TO THEIR YARD. TRUCK AND TRAILER WERE RELEASED BY THE DRIVER/OWNER TO THE INSURANCE COMPANY FOR INSPECTION, ALTHOUGH HE MAINTAINS OWNERSHIP OF VEHICLES.

THIS HAS TO DO WITH 19.5" WHEELS MANUFACTURED BY VISION WHEEL,SPECIFICALLY WHEEL # 81A-9770MBO. ON THE BACK OF THE WHEEL THERE IS A RELIEF MACHINED AROUND EACH LUG HOLE THAT IS ABOUT 1/8"DEEP X 3/4" IN DIA. WHETHER THIS IS A MANUFACTURING DESIGN OR A FLAW I AM NOT SURE,BUT PREVIOUS WHEELS OF THE SAME MODEL NO. DO NOT HAVE THIS AND ARE FLAT ON THE BACK. SHOULD THE LUGS NUTS BE OVER TIGHTENED IT CRACKS THE RIM AROUND THE LUG HOLE AND STARTS TO PULL THROUGH. I FOUND THIS SHORTLY AFTER I GOT MY TRUCK BACK FROM THE TIRE SHOP AND WAS LOOKING AT THE NEW WHEELS.IT IS NOT READILY NOTICEABLE AND WAS JUST LUCK THAT I SAW IT. MY CONCERN IS THAT THIS COULD HAPPEN ANY TIME A WHEEL IS TAKEN OFF FOR SOME SERVICE OR ANOTHER. IF THE WHEEL LUG NUTS GET OVER TORQUED THIS OCCURS. THESE WHEELS ARE USED PRIMARILY BY PEOPLE THAT CARRY HEAVY LOADS AS THE 19.5 TIRES AFFORD BETTER STABILITY. SHOULD SOMEONE NOT BE AWARE OF THIS ISSUE THERE IS THE POSSIBILITY OF LOOSING A TIRE. THIS COULD BE RESOLVED SIMPLY BY NOT MACHINING THE BACK OF THE WHEEL AS WAS NOTED ABOVE. I BELIEVE THIS COULD BE A HAZARD. CONTACT INFO CAN BE OBTAINED HERE: HTTP://WWW.VISIONWHEEL.COM/CONTACT.CFM

FOR THE PAST WEEK MY TRUCK HAS BEEN TAKING LONGER TO START THEN NORMAL TODAY IT STARTED TO STALL ON MY I WAS ABLE TO GET IT HOME WHILE IT STALLED 4 MORE TIMES ON THE WAY. SHOPPED AT A FRIENDS SHOP ON THE WAY HOME AND HAD THEM SCAN THE COMPUTER FOUND OUT MY FICM IS NO GO MY IPR IS BAD AND MY STC FITTING IS BAD THEY FOUND THE STC WHEN THEY PULLED THE TURBO ASWELL AS MY DUMMY PLUGS. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,723.