2020 FORD F-350 SD Complaints

The contact owns a 2020 Ford F-350. The contact stated that when the front passenger’s side door was locked, the door could not be opened from outside the vehicle. The contact state that the door could only be unlocked by using the interior door lock mechanism. The vehicle was taken to the local dealer who was unable to duplicate the failure. After retrieving the vehicle, the failure continued to occur. The contact was later informed by the dealer that the door actuator was likely the cause of the failure and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 34,000.

The contact owns a fleet of 2020 Ford F-250. The contact's employees had informed him that while driving at various speeds and shifting between gears, the vehicles were jerking as the check engine warning light was illuminated. The failure recurred on various occasions, and the contact's employee also stated that while driving at an undisclosed speed, the brakes were applied and failed to respond so the gear was shifted into neutral(N) and he had to depress the brake pedal with excessive force in order for them to respond and avoid almost hitting another vehicle. The contact called various local dealers and made them aware of the failure; however, there was no availability or capacity for the fleet vehicles. The vehicles were not yet diagnosed or repaired by an independent mechanic or local dealer. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,000.

Door locks. The electric door locks have stopped working on both front doors. I had the drivers repaired under warranty, and now the passenger door I paid for - about $300. This is a major safety concern especially for a 2020 that cost over $80k. If I forget to manually lock the door, someone can could get in my car without me knowing. I also can't lock the door in the event someone is approaching me. I know prior years were recalled, please add MY2020.

The contact owns a 2020 Ford F-350. The contact stated that while driving at various speeds, the vehicle would hesitate and enter into Limp Mode upon depression of the accelerator pedal. The contact stated the wrench warning light had appeared on the instrument panel. The contact called the dealer and was informed that his vehicle was not under recall. The manufacturer was notified of the failure and was given a case number. The vehicle was not diagnosed or repaired. The failure mileage was approximately 130,000.

The contact owns a 2020 Ford F-350, The contact stated that after the vehicle had been turned off for an extended period, after restarting the vehicle, the vehicle would not immediately drive forward or in reverse; however, the vehicle would roll if on an inclined surface. The vehicle was taken to the dealer who diagnosed that the condition was caused by transmission fluid draining back from the torque converter. The contact was informed that manufacturer was aware of the condition and had advised that no service be performed to resolve the issue; but owners should be advised in order to prevent the condition from occurring, to allow the engine to run for a while before attempting to drive. The manufacturer was contacted and advised the contact that no service would be performed to correct the condition. The contact was concerned that in an emergency situation the vehicle could not immediately be moved or the roll away condition would create a safety hazard. The failure mileage was 10.

My truck starting shaking really bad while driving after 45 miles per hour. I went to the repair shop today and they told me it was the death wobble. Could have lost control of truck as it was very terrifying.

The contact owns a 2020 Ford F-350. The contact stated while driving 5 MPH and while going up a hill, the vehicle started to jerk, and the contact felt the vehicle would lose steering. The vehicle was towed to the dealer and they stated that the steering columns needed to be replaced. The manufacturer was not contacted. The failure milage was 146,000.

On 7/17/2022, while driving, the tailgate unexpectedly released. The tailgate was damaged by the trailer that was being towed at the time. The tailgate was damaged by the trailer tongue jack. The tailgate was confirmed closed prior to driving. No warning messages were displayed from the vehicle. The vehicle has not yet been inspected by the dealer but I have an appointment on 7/27. Ford Customer Service was contacted, case #CAS-37657604 was provided. Prior to the incident there had been several occasions where the vehicle would display a warning that the tailgate was open but inspection confirmed it was secured.

The contact owns a 2020 Ford F-350. The contact stated while driving 30 MPH, the accelerator pedal was depressed; however, the vehicle failed to exceed 30 MPH. There was no warning light illuminated. The contact was able to continue driving. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The manufacturer was notified of the failure and a case was opened. The manufacturer then followed up with the dealer and was informed that the failure was not associated with NHTSA Campaign Number: 22V256000 (Power Train) even though the VIN was included. The manufacturer closed the case and referred the contact to the NHTSA. The dealer informed the contact that she would be responsible for the cost of the repair. The vehicle was not repaired. The failure mileage was approximately 130,000.

Twice today I had the truck explode into a death wobble, the first one was so severe on highway 255 outside St Louis that I had to do an emergency stop pulling of to the side of the road, the death wobble would not stop till I came to a complete stop. It was so volatile I thought I lost a tire and rim completely off the vehicle. The second was as near violent and didn't cease till I was down to 15 miles per hour. I will be contacting a Ford dealership tomorrow as today is a Sunday.