2005 FORD F-350 SD Complaints

JULY 1, 2006 AT APPROXIMATELY 10:30 AM, I WAS TRAVELING ON I-81 AT 65 MPH TOWING A 9,000 LB. TRAILER AND THE TRUCK STALLED WITHOUT WARNING. NO CHECK ENGINE LIGHT AND NO HESITATION. IT SIMPLY DIED. WITHOUT POWER BRAKES OR STEERING, THE TRUCK WAS COMPLETELY UNCONTROLLABLE. LUCKILY, WE WERE ON A SECTION OF HIGHWAY WITH WIDE SHOULDERS AND LIGHT TRAFFIC. THE TRUCK DIED SO SUDDENLY THAT I COULDN'T EVEN PULL TO THE SHOULDER. THE TRUCK CAME TO A COMPLETE STOP IN THE LEFT LANE AND WOULD NOT RESTART. DRIVERS BEHIND ME SWERVED TO THE SHOULD TO AVOID A COLLISION. THE DEALER DID NOT FIND A PROBLEM AND DID NOTHING TO PREVENT THIS SITUATION FROM OCCURRING AGAIN. AFTER THE TRUCK SAT AT THE DEALER FOR 2 DAYS (OVER THE WEEKEND), IT STARTED FOR THE TECHNICIAN ON THE FOLLOWING MONDAY. THE DEALER INFORMED ME THAT NHTSA #05V270000 DOES NOT APPLY TO MY TRUCK, ALTHOUGH THIS CAMPAIGN NUMBER DESCRIBES THE EXACT SITUATION THAT OCCURRED WITH MY TRUCK. THE TRUCK AND TRAILER COMBINED WEIGH APPROXIMATELY 19,000 LBS. 19,000 LBS TRAVELING AT 65 MPH AND SUDDENLY LOOSING BRAKES AND STEERING IS A DEATH WAITING TO HAPPEN. PLEASE HELP BEFORE AN INNOCENT MOTORIST(S) GET KILLED BY THIS TRUCK. *JB

2005 FORD F350 CREWCAB VIBRATION WHILE PULLING A LOAD, TURBO UNIT HAS BEEN REPLACED TWICE, DASH CLUSTER ONCE, EXHAUST LEAK. *KB ***NAR*** THE TEMPERATURE GAUGE WAS ACTING ERRATIC. THERE WAS A STEERING NOISE WHEN MAKING TURNS. THE CONSUMER WAS TOLD THE VIBRATION THAT HE WAS EXPERIENCING WAS BEING INVESTIGATED. *JB

REAR AXLE SUSPENSION FAILURE ON 2005 FORD F-350 SUPER DUTY TRUCK CAUSING A CRASH WITH PROPERTY DAMAGE. *JB

DT*: THE CONTACT STATED THE ENGINE STALLED SUDDENLY WITHOUT WARNING A TOTAL OF FOUR TIMES. THE VEHICLE WAS TOWED ON EACH INCIDENT. THE DEALERSHIP REPLACED A MODULE ON THE WIRING HARNESS AND VARIOUS OTHER UNKNOWN PARTS, BUT THE PROBLEM STILL PERSISTS. ON ONE OCCASION WHILE ATTEMPTING TO DEPRESS THE BRAKE, THE PEDAL WOULD NOT DEPRESS. AFTER PLACING THE VEHICLE IN NEUTRAL, THE BRAKES WORKED PROPERLY. TWO MONTHS AGO THE SHOCK ON THE PASSENGER SIDE FRACTURED. A WELDING SHOP DETERMINED THE PROBLEM WAS A BAD WELD JOINT.

THE VEHICLE IN QUESTION, A FORD F-350 PICK UP, IS NORMALLY USED TO PULL A GOOSENECK TRAILER. TO CONNECT THE TRAILER, THE TAIL GATE OF THE TRUCK MUST BE OPENED, THE TRUCK BACKED UP PART WAY, THE TAIL ATE THEN CLOSED, AND THE TRAILER CONNECTED. THE TAIL GATE IS NOT OPENED AGAIN UNTIL THE TRAILER IS BEING DISCONNECTED. I FOLLOWED THIS PROCEDURE, HAULED THE TRAILER ABOUT 40 MILES ON INTERSTATE HIGHWAY TO ITS DESTINATION AND UNLOADED THE TRAILER. I THEN WAS PROCEEDING TO PARK THE TRAILER BEFORE UNLOADING THE BED OF THE TRUCK. DURING A LOW SPEED U TURN OVER SLIGHTLY ROUGH GROUND, THE TAIL GATE OF THE FORD F-350 (WHICH WAS STILL TOWING THE GOOSE NECK TRAILER) POPPED OPEN AND FELL AGAINST THE TRAILER. BEFORE I COULD GET THE VEHICLE STOPPED, THE TAIL GATE WAS BENT BY THE TRAILER. DAMAGE TO THE TAILGATE AND TRUCK IS COSTING $1750 TO REPAIR. *JB

DT*: THE CONTACT STATED WHILE TRAVELING AT VARIOUS SPEEDS, THE VEHICLE LOSSES POWER. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND THE INJECTOR WAS REPLACED.

DT*: THE CONTACT STATED WHILE DRIVING ON THE INTERSTATE AT 65 MPH AND PULLING A TRAILER THE VEHICLE STALLED AND WOULD NOT RESTART. THE VEHICLE WAS MANEUVERED OFF THE INTERSTATE WITHOUT INCIDENT. THE VEHICLE WAS TOWED TO THE DEALERSHIP, WHO DETERMINED THE HIGH PRESSURE OIL PUMP FAILED AND WAS REPLACED. SINCE THE REPLACEMENT OF THE HIGH PRESSURE OIL PUMP THERE HAVE BEEN NO ADDITIONAL PROBLEMS. UPDATEDN 06/09/2006. *AK

VEHICLE HAD JUST RETURNED HOME AFTER BEING DRIVEN A CONSIDERABLE DISTANCE. VEHICLE SHUT OFF FOR A FEW MINUTES WHEN FIRE STARTED UNDER THE HOOD AND MOVED INTO CAB. INSURANCE COMPANY HIRED A FIRE ORIGIN AND CAUSE ANALYST AND IT WAS DETERMINED THAT FIRE WAS CAUSED WHEN FUEL LEAKED FROM THE BANJO FITTING ON THE FUEL FILTER ONTO THE HOT SURFACE OF THE ENGINE. THE BANJO FITTING ON THE LOWER PORTION OF THE FUEL FILTER WAS COVERED WITH A HEAVY LAYER OF FUEL VARNISH. THE BOLT IN THE BANJO FITTING WAS CHECKED AND FOUND TO BE EXTREMELY LOOSE. THIS OCCURRED ON 6.0L DIESEL ENGINE. THERE LOOKS TO HAVE BEEN SIMILAR PROBLEM ON GASOLINE ENGINES WHICH HAD A RECALL DATE OF 6/7/05 AND NHTSA ID NUMBER OF 05V266000. WOULD LIKE TO KNOW IF FORD HAS SEEN PROBLEM ON DIESEL ENGINES?*JB

TRAILER BRAKE CONTROLLER ONLY ALLOWS MINIMAL ELECTRIC CURRENT TO TRAILER UNDER 15 MPH. I AM TOLD, DOT KNOWS OF THIS PROBLEM IN FORD F 350 TRUCKS MFRD. PRIOR TO 03/05. COVERED BY FORD BULLETIN. FORD REFUSES TO UPDATE OR REPAIR. NOT ENOUGH BRAKES UNDER 15 MPH TO STOP TRAILER OR TO TEST FOR TRAILER BRAKES. *NM

MAKING A LEFT HAND TURN THE STEERING FAILED CAUSING THE TRUCK TO RUN INTO A POLE. THE TRUCK IS BEING REPAIRED USING A MUCH STRONGER STEERING BOX BY MY FORD DEALER. THIS IS BEING PAID FOR BY MY INSURANCE CO. EVEN THOW THE TRUCK HAS ONLY 26000 MILES ON IT AND IS UNDER FACTORY WARRENTY. I WILL GET THE UNDERSIZE BROKEN STEERING BOX. THE TRUCK HAS THE ORIGINAL SUSPENSION,WHEELS,AND TIRES IT CAME WITH. THANKS FORD. *NM