2012 FORD F-350 SD Complaints

I AM EXPERIENCING WOBBLE AND SHAKING FROM THE FRONT END AFTER ANY VARIATION OF THE ROAD, TURNING WITHOUT ANY BUMPS IN THE ROAD, TURNING WITH BUMPS IS WORSE, STRAIGHT LINE WOBBLE AFTER SLIGHT BUMPS ETC. IT IS GETTING INCREASINGLY WORSE AND IS CUPPING THE FRONT TIRES CONSIDERABLY, ( WHEN I TOOK IT TO A FORD DEALERSHIP FOR ROTATION I WAS TOLD THAT THEY RECOMMEND THAT I PURCHASE A NEW SET OF TIRES INSTEAD OF ROTATION FOR A DUALLY) I HAVE HAD THE TIRES ROTATED ANYWAY. THE TRUCK HAS LOW MILEAGE, FAR TO LOW TO BE EXPERIENCING THIS SEVERE OF SHAKE. WHEN I TOOK IT RECENTLY ( 3/18/2014) TO THE DEALER HE SAID THEY FOUND NOTHING WORN. EITHER THEY HAVE A POORLY ENGINEERED DESIGN OR INFERIOR PARTS OR BOTH. I WILL BE USING THIS VEHICLE FOR TOWING A TRAILER IN THE FUTURE AND I AM UPSET TO THINK WHAT POSSIBLE SCENARIOS I MIGHT INCUR. ALSO I AM A DOT 1104 MECHANICAL/TECHNICAL INSPECTOR AS A PROFESSION AND I KNOW WHEN MACHINERY IS WORKING CORRECTLY AND WHEN IT IS NOT, FORD IS IN DENIAL THAT THERE IS ISSUES WITH WHICH I DESCRIBED, AND I KNOW WHEN I AM GETTING A SMOKE SCREEN TO PUT IT POLITELY. *TR

TL* THE CONTACT OWNS A 2012 FORD F-350 SD. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE EXHAUST GAS TEMPERATURE EGT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 31,538. UPDATED 04/17/14 MA *TR

DRIVING STRAIGHT ON A HIGHWAY AT 70 MPH, HIT A SMALL BUMP ON THE DRIVER SIDE ONLY. THE STEERING WHEEL STARTED SHAKING VIOLENTLY, THE FRONT END AND QUICKLY THE ENTIRE TRUCK FELT AS THOUGH IT WAS SHAKING APART AND WAS SWINGING BACK AND FORTH, I SLAMMED ON THE BRAKES AND THE SHAKING GOT WORSE UNTIL ABOUT 15 MPH, IT THEN STOPPED. I THEN GOT UP TO 60 MPH AND WHEN I HIT A BUMP THE SAME THING HAPPENED. THEN GOT UP TO 50 MPH AND THE SAME THING HAPPENED. THEN GOT UP TO 40 MPH AND IT DID NOT HAPPEN AGAIN AT THAT SPEED. I DROVE 100 MILES HOME AT 40 MPH ON A MAIN HIGHWAY. TODAY I AM BRINGING MY TRUCK TO THE DEALERSHIP TO HAVE IT FIXED UNDER WARRANTY, I WILL DO 40 MPH ALL THE WAY THERE. I WILL NOT TOW MY HORSES TRAILER WITH THIS VEHICLE, IT WOULD HAVE CAUSED AN ACCIDENT AND KILLED MY HORSES. *TR

THIS IS PROBABLY ABOUT THE 30TH TIME MY FORD F-350 HAS HAD A DEATH WOBBLE. THIS TIME I WAS DRIVING ON HIGHWAY 69 BETWEEN PRESCOTT VALLEY AND PRESCOTT WHEN IT STARTED. IT WAS SHAKING SO BAD THAT I ALMOST LOST CONTROL AND HIT THE MEDIAN. THE OTHER VEHICLES MUST HAVE NOTICED THE VEHICLE SHAKING BECAUSE ALL OF THE TRAFFIC AROUND ME BACKED WAY OFF. ONCE AGAIN I REPORTED IT TO FORD AND TOOK IT IN RIGHT AWAY. THEY TOLD ME AGAIN THAT IF IT DID NOT DO IT FOR THEM THERE WAS NOTHING THEY COULD DO FOR ME AND SENT ME HOME WITH MY VEHICLE. THIS SEEMS TO BE A PROBLEM WITH THE FORD F-350 BUT FORD REFUSES TO RECALL OR FIX IT. I FOUND TONS OF INFORMATION ONLINE ABOUT THE ISSUE AS WELL AS YOUTUBE VIDEOS TAKEN OF THE EVENTS HAPPENING. *TR

MOON ROOF SHATTERED WHILE TRAVELING ON A PAVED HIGHWAY ON A CLEAR DAY AT APPROXIMATELY 45 MILES PER HOUR. I HEARD A LOUD NOISE SIMILAR TO A GUN SHOT AND I FIRST THOUGHT A LARGE ROCK HAD HIT THE VEHICLE BUT I COULD NOT SEE ANY DAMAGE. I WAS APPROXIMATELY 200 YARDS BEHIND A TRACTOR TRAILER RIG WHICH WAS NOT A GRAVEL TRUCK OR AN OFF ROAD TYPE RIG. THE NEXT DAY I NOTICED A PIECE OF TINTED GLASS IN THE BED OF THE TRUCK AND CLIMBED INTO THE BED AND NOTICED THE MOON ROOF HAD SHATTERED IN AN OUTWARD DIRECTION. A LARGE QUANTITY OF BROKEN GLASS HAD FALLEN DOWN AND WERE LAYING ON THE MOON ROOF INSIDE COVER. IF I HAD NOT HAD THE COVER CLOSED AT THE TIME OF THE BREAKAGE, I COULD HAVE BEEN COVER IN SMALL PIECES OF BROKEN GLASS WITH POTENTIALLY A DIFFERENT OUTCOME. THIS IS THE SECOND INCIDENT I HAVE HAD THIS YEAR WITH A SHATTERED MOON ROOF. IN MID OCTOBER, I WAS DRIVING A 2014 LEXUS ES300H AND THE MOON ROOF EXPLODED WITH A TREMENDOUS NOISE, ALSO IN AN OUTWARD DIRECTION. I WAS GOING 70 MILES PER HOUR AND WAS NOT IN A CONSTRUCTION ZONE NOR WAS I IN ANY TRAFFIC. AGAIN I DID NOT HAVE THE COVER OPEN AND NO GLASS CAME INTO THE VEHICLE. I WILL ALSO ADD THIS COMPLAINT TO THE DATABASE AS A SEPARATE COMPLAINT. *TR

DUE TO EGT SENSOR READING HIGH EG TEMPS TRUCK SHUT OFF WITH NO WARNING. LEFT ME STRANDED IN THE MIDDLE OF A BUSY STREET UNTIL A GOOD SAMARITAN PULLED ME TO THE CURB. TRUCK WAS FULLY LOADED, BUT NOT OVER LOADED. *TR

WHEN CROSSING OVER SOME MINOR PAVEMENT IRREGULARITY, BRIDGE EXPANSION JOINT ETC - THE FRONT END OF THE TRUCK SHAKES VIOLENTLY. I MUST HIT THE BRAKES AND SLOW DOWN TO TRY AND KEEP FROM LOSING CONTROL. IT IS WIDELY KNOWN ON THE FORD TRUCK FORUMS AS "THE DEATH WOBBLE" HERE IS A UTUBE VIDEO OF IT HAPPENING HTTP://WWW.YOUTUBE.COM/WATCH?V=8EUQ6F8RGT4 CONSIDERING THE AMOUNT OF FOLKS ON THE FORD TRUCK FORUM THAT HAVE EXPERIENCED IT - AND THE FACT THAT MOST SUPER DUTY OWNERS ARE NOT EVEN ON THIS FORUM THIS IS A WIDESPREAD AND EXTREMELY DANGEROUS SITUATION. IT APPEARS FROM WHAT I CAN SEE IT THAT IT SEEMS TO BE LIMITED TO 4X4 SUPER DUTY TRUCKS. HELP!! *TR

TL* THE CONTACT OWNS A 2012 FORD F-350 SD. THE CONTACT STATED THAT WHILE TRAVELING 50 MPH, THE VEHICLE TRAVELED OVER A ROAD BUMP AND THE FRONT END SHOOK VIOLENTLY. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A LOCAL DEALER FOR A DIAGNOSTIC TEST. THE DEALER STATED THAT THE VEHICLE NEEDED THE UPPER BALL JOINTS REPLACED. THE CONTACT THEN TOOK THE VEHICLE TO A LOCAL MECHANIC FOR A SECOND OPINION. THE MECHANIC STATED THAT THE NEW TRACK BAR AND STEERING DAMPER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 35,000. UPDATED 1/7/14*CN THE CONSUMER STATED HE TOOK THE VEHICLE TO THE DEALER, BECAUSE HE WAS EXPERIENCING A VIOLENT SHAKE IN THE STEERING AND THERE WAS A NOISE COMING FROM THE STEERING LINKAGE. THE DEALER EXPLAINED TO THE CONSUMER, THE FRONT SUSPENSION HAD BEEN MODIFIED AND THE SHAKE WAS DUE TO A 2 INCH LIFT, WHICH HAD GIVEN THE TRUCK TOO MUCH NEGATIVE CASTER, AND IF HE WANTED IT CORRECTED, TWO NEW BALL JOINTS ADJUSTER WOULD NEED TO BE INSTALLED A T A COST OF 4500. THE CONSUMER DECLINED THE REPAIRS, AS HE DID NOT BELIEVED THAT CASTERS CAUSED VIOLENT SHAKES.UPDATED 01/15/14

WHILE DRIVING AN ALARM SOUNDED AND THE DRIVER DISPLAY STATED " STOP SAFELY NOW" AND LOST ALL THROTTLE RESPONSE. WHEN THE VEHICLE STOPPED, THE ENGINE SHUT OFF AND IT WOULD NOT CRANK OR RESTART. IT HAD TO BE TOWED FROM A BUSY INTERSECTION. THE FAULT TURNED OUT TO BE A FAILED EGT EXHAUST TEMPERATURE SENSOR. IT WAS NOT EVEN A ENGINE COMPONENT. IT IS PROGRAMMING ALONE THAT PREVENTED MOVING THE TRUCK TO A SAFE LOCATION. WHAT IF THIS WAS A RAILROAD GRADE CROSSING? OR HAD KIDS IN THE TRUCK? I CAN'T LET MY WIFE DRIVE IT NOW IT HAS 4 OF THESE SENSORS AND ONLY THE 1 FAILED ONE WAS CHANGED. FORD HAS A TSB 13-13-3 ON THIS. IT IS IN ITS 3RD REVISION. THEY KNOW OF THE PROBLEM. *TR