2012 FORD F-350 SD Complaints

The contact owns a 2012 Ford F-350 SD. The contact stated while driving 55 MPH, the vehicle went into LIMP Mode and lost motive power. The message "Stop Vehicle Safely Now" was displayed. The contact was able to pull to the side of the road. The contact stated that the vehicle failed to restart after several attempts and the message remained displayed. The contact stated that the vehicle started up after an hour and half. The vehicle was taken to a local Pep Boys, where it was diagnosed that the failure was related to the exhaust gas temperature sensor. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that Ford Campaign Numbers: 15N01 and 15N02 had expired unless the vehicle was an ambulance. The failure mileage was approximately 196,475. The contact stated that they purchased one EGTS and installed the part themselves. The dealer recommended to replace all four sensors as well as the EGR valve. After the installation of the new EGTS, the vehicle seems to run okay.

High speed wobble in front end Goes away of You slow down Getting worse Very scary, pulls steering wheel out of my grasp Wife refusing to ride in the truck

DEATH WOBBLE AT SPEEDS STARTING ANYWHERE FROM 40 MPH UP. VERY DIFFICULT TO CONTROL ESPECIALLY WHEN YOU ARE ON A HIGHWAY OR OVERPASS AND THERE'S NOWHERE TO SLOW DOWN OR TRY TO STEER TO. EXTREMELY SCARY. HAVE HAD THE PROBLEM 'TRY' TO BE FIXED GREATER THAN 5 TIMES. THE LAST FIX WAS ABOUT 4 MONTHS AGO AND HAS LASTED SO FAR BUT I'M STARTING TO FEEL VIBRATION AGAIN. THE FIXES AREN'T CHEAP EITHER. ALWAYS GREATER THAN $1000 WITH PARTS AND LABOR. I LOVE MY TRUCK BUT THIS IS GETTING OUT OF HAND.

THIS TRUCK WHILE DRIVING DOWNTOWN THE INTERSTATE AFTER CROSSING A BRIDGE DID A VIOLENT SHAKING OF THE STEERING WHEEL AND NEARLY CAUSE ME TO HIT ANOTHER CAR AND WRECK. I HAD TO SLOW DOWN ALMOST TO A COMPLETE STOP TO GET IT TO STOP. I HAVE SINCE TAKEN IT TO DIFFERENT FORD DEALERSHIPS AND ALSO FAMILY OWNED SHOPS TO FIX THE PROBLEM AND NOBODY CAN FIX IT.

MULTIPLE TIMES WHILE DRIVING AT 50 - 60MPH TOWING MY 12,000 LB 5TH WHEEL TRAILER, OFTEN IF I DRIVE OVER A BUMP IN THE ROAD, MY 2012 FORD F350 WILL START TO VIOLENTLY SHAKE FROM THE FRONT STEERING. I HAVE HAD PARTS REPLACED, ALIGNMENT DONE, NEW TIRES, NEW SHOCKS, BUT NOTHING STOPS THIS PROBLEM. I CAN'T TOW MY TRAILER ANYMORE. THIS PROBLEM HAS ALSO HAPPENED WHEN NOT TOWING. THERE NEEDS TO BE A RECALL FOR THIS TO BE SAFE. THE DEALER CANNOT FIGURE OUT THE SOLUTION. FORD SEEMS TO IGNORE IT. PLEASE HELP

MY TRUCK HAS 32,000 MILES ON IT. 6.7 DIESEL. UPON STARTING THE TRUCK ( STATIONARY IN MY DRIVEWAY ) #3 FUEL INJECTOR POPPED OUT OF THE ENGINE, CAUSING A MISFIRE AND SPRAYING DIESEL FUEL ALL OVER THE ENGINE. IT WAS FOUND THAT THE #3 INJECTOR HOLD DOWN CLAMP HAD BROKEN CAUSED BY A CRACK IN IT. . FORD IS WELL AWARE OF THIS DEFECT.. THIS COULD HAVE RESULTED IN A FIRE AND POSSIBLE LOSS OF LIFE IF IT HAD HAPPENED ON THE HIGHWAY. FORD AGREED TO REPLACE HALF OF THE DEFECTIVE INJECTOR CLAMPS. (4) THIS LEAVES THE OTHER 4 PRONE TO FAIL AT ANY TIME. I WAS CHARGED $897.67. FOR THE" HALF REPAIR". FORD SHOULD BE FORCED TO RECALL THESE VEHICLES AS IT IS A WELL KNOWN FAILURE AND DOCUMENTED ON NUMEROUS INTERNET WEBSITES. THERE IS A TSB FROM FORD TO THEIR DEALERS ON IT. IT ALSO FILLED THE CRANKCASE WITH DIESEL FUEL WHICH DID NOT DO IT ANY GOOD. THIS TRUCK HAS ONLY 32 K MILES AND HAS BEEN METICULOUSLY MAINTAINED SINCE NEW. THE FORD DEALER REPAIR ORDER STATES:"FOUND VEHICLE LEAKING FUEL.FOUND INJECTORS # 1 & # 3 BLEW OUT BREAKING HOLD DOWN CLAMPS. ALSO FOUND OTHER CLAMPS CRACKED AND RETURN LINE BROKE AS WELL AND LEAKING FUEL.ORDERED PARTS ON BACK ORDER PACO # 5934349 CONTACT FORD CASE # CAS-15233762-Q2P6TO. FORD AGREED TO ASSIST $ 1500. . FORD SHOULD PAY FOR THE WHOLE REPAIR BECAUSE IT IS A DEFECTIVE PART THAT CAUSED THIS DANGEROUS FAILURE AND THEY ARE AWARE OF IT. PLEASE FORCE THEM TO INITIATE A RECALL ON THESE DEFECTIVE FUEL INJECTOR CLAMPS ON THEIR 6.7 DIESEL ENGINES BEFORE THERE IS A CATASTROPHIC FAILURE RESULTING IN VEHICLE FIRES. THE ENGINE WILL MOST LIKELY SHUT DOWN IF THE VEHICLE IS DRIVEN WITH THE INJECTOR OUT OF THE ENGINE. IF SOMEONE WAS TOWING A TRAILER THIS COULD BE LIFE THREATENING. LUCKILY MINE FAILED IN THE DRIVEWAY WITH THE ENGINE AT IDLE..

JUNE 23 2017, I WAS TRAVELING DOWN THE ROAD WHEN A MESSAGE THE READ STOP WHEN SAFE POPPED ONTO THE TRUCK INSTRUMENT DISPLAY. I ATTEMPTED TO GET TO A SAFE AREA TO PULL THE TRUCK OVER BUT WAS UNABLE DUE TO A LOSS IN MOMENTUM THAT I LATER FOUND OUT WAS A MANUFACTURER SAFETY PRECAUTION DUE TO A FAULTY EGT SENSOR. I WAS NOW CURRENTLY IN THE MIDDLE OF THE ROAD AND UNABLE TO RESTART THE TRUCK. AFTER 20 MINUTES WAVING DOWN VEHICLES SO THAT A SERIOUS ACCIDENT DID NOT HAPPEN THE TRUCK RESTARTED. I SENT BACK DOWN THE ROAD TO ATTEMPT TO GET INTO A SAFER LOCATION INSTEAD OF BLOCKING 1 LANE OF THE ROAD. I WAS ABLE TO PROCEED .9 MILES BEFORE THE TRUCK SHUT OFF AGAIN ON A BLIND HILL. THE TOW TRUCK WAS ARRIVED AND WE WERE THEN ABLE TO REMOVE IT FROM THE ROADWAY. FORD HAS COME OUT WITH A RECALL FOR THERE 6.7L POWER STROKE AMBULANCES TO NOT HAVE THIS ISSUE BUT AS CIVILIANS WE ARE STUCK WITH A VERY DANGEROUS AND POSSIBLY LIFE THREATENING SHUT DOWN OF THE TRUCK OVER A 57 DOLLAR PART. THIS IS NOT A SMALL INSTANCE ON THIS HAPPENING JUST A QUICK ONLINE SEARCH WILL SHOW COUNTLESS OTHERS WITH THE SAME PROBLEM. FORTUNATELY NO ONE WAS HURT BECAUSE OF THE MEASURES TAKEN OF THE PEOPLE OR THE ROAD. THIS IS NOT RIGHT AND FORD NEEDS TO MAKE A CHANGE. IF YOU LOOK INTO THE BACKGROUND OF THIS TRUCK YOU WILL SEE THIS IS NOT THE FIRST TIME OF SUCH THINGS HAPPENING.

DRIVING 70 MPH ON EXPRESSWAY WHEN TREAD COMPLETELY SEPARATED FROM BELTS ON TIRE DAMAGING THE RIGHT REAR WHEEL WELL, BODY, TRIM AND BUMPER. TIRE WAS A FACTORY INSTALLED (BOUGHT THE 2012 F350 NEW) GENERAL GRABBER HTS SIZE 245/75 R 17 WITH 54,000 MILES ON THEM. DOT # IS A343 47DB

REAR BRAKE LIGHTS AND TURN SIGNAL FAILURE. MY REAR BRAKE LIGHTS AND TURN SIGNALS INTERMITTENTLY STOP WORKING WITH OUT NOTICE. I HAVE REPLACED THE BULBS MANY TIMES ONLY TO FIND OUT THAT THEY ARE NOT BAD. THEY WILL STOP WORKING ONE SIDE AT A TIME AND SOME TIMES BOTH STOP WORKING AT THE SAME TIME. THIS LEAVES YOU NO INDICATION THAT YOU HAVE NO BRAKE LIGHTS OR TURN SIGNALS WORKING. I HAVE NOTICED THAT SOME TIMES WHEN I TURN ON MY TURN SIGNALS, ONE SIDE WILL FLASH FAST THAN THE OTHER, AT ABOUT TWICE THE RATE AS NORMAL. I WAS IN A LEFT TURN LANE WAITING TO TURN WITH TURN SIGNAL ON AND STARTED TO SMELL ELECTRICAL BURNING SMELL OR ELECTRICAL SMOKE. THIS IS WHEN I DECIDED TO LOOK FURTHER INTO THIS MATTER. I HAVE DISCOVERED OTHER COMPLAINTS WITH 2011 F350 HAVING THE SAME TROUBLE AND THEY HAVE GOTTEN A RECALL TO REPLACE THE BODY CONTROL MODULE SO IT DOESN'T SHORT OUT AND CAUSE ELECTRICAL FIRES. BUT MY 2012 F350 THERE IS NO RECALL FOR THE EXACT SAME SYMPTOMS. I HAVE CALLED THE DEALERSHIP MANY TIMES TO COMPLAIN WITH NO SOLUTION. MY TRUCK WAS BUILD IN 10/11 AND ONLY HAS 37000 MILES. I HAVE BEEN HAVING THIS ISSUE FOR AT LEAST 7-8000 MILES. I GUESS ITS GOING TO TAKE AN ACCIDENT OR FIRE TO GET FORD TO CORRECT THIS DEFECT. *TR

FORD SUPER DUTY TRUCK DEVELOPED A SEVERE VIBRATION AT 70MPH ON INTERSTATE HIGHWAY. IT WAS A DANGEROUS SITUATION THAT CAUSED THE VEHICLE TO SWERVE TO THE LEFT INSTANTLY. I WAS IN HEAVY TRAFFIC, I HAD TO SLOW THE VEHICLE DRASTICALLY WHICH CAUSED OTHER TRAFFIC TO HAVE TO AVOID ME. INVESTIGATED ONLINE, THEY EVEN HAVE A NICK NAME "DEATH WABBLE" I FOUND HUNDREDS AND HUNDREDS OF CASES IN 15 MINUTES, WHAT ARE YOU DOING THERE? THIS HAS TO BE A RECALL OR SOMETHING, I'M AFRAID TO DRIVE MY TRUCK. HELP US