2005 FORD FIVE HUNDRED Complaints

CARS ENTERS INTO FAILSAFE MODE AND ENGINE CUTS OUT. I HAVE BEEN ALMOST REAR- ENDED THREE TIMES SINCE FIRST OCCURRENCE AND ONE TIME ALMOST T-BONED. SLUGGISH ACCELERATION WHEN TAKING OFF MAY OCCUR ALSO. I HAVE NOTICED THIS HAS BEEN A COMMON PROBLEM WITH THIS MODEL AND THE FAULTY THROTTLE BODY HAS SINCE BEEN REDESIGNED BY FORD. THEY SHOULD RECALL THIS AS IT IS A SAFETY HAZARD. I KNOW THAT I WAS LUCKY TO HAVE NOT BEEN INJURED IN AN ACCIDENT DUE TO THIS FAULTY PART, BUT I AM SURE SOME HAVE NOT BEEN SO LUCKY. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE LIGHTS ON THE INSTRUMENT FAILED AND ALL OF THE GAUGES WERE INOPERABLE. IN ADDITION, THE REAR BACK UP SENSORS WERE BUZZING HAPHAZARDLY. THE CONTACT CHECKED ALL OF THE FUSES AND WAS UNABLE TO LOCATE A CAUSE FOR THE FAILURE. THE VEHICLE WAS NOT INSPECTED BY THE DEALER OR A MECHANIC. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 1/27/12 *CN UPDATED 02/01/12

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE HARNESS FOR THE FRONT PASSENGER SIDE HEADLIGHT HAD TO BE REPLACED BECAUSE IT MELTED. AN AUTHORIZED DEALER STATED THAT THE FAILURE MAY HAVE BEEN CAUSED BY EXCESS MOISTURE, BUT THE CONTACT STATED THAT THE HEADLIGHT BECAME BRITTLE AND FRACTURED. THE DEALER ALSO STATED THAT THE TOP MOTOR MOUNT HAD WORN. THE CONTACT FELT THAT THESE WERE MANUFACTURERS DEFECTS. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 89,700.

SIMILAR ISSUE AS IN PE07058. INSTRUMENT CLUSTER FAILS FOR EXTENDED PERIODS. IN THIS TIME I HAVE NO INSTRUMENTATION AVAILABLE, SPEED, RPM, FUEL, ETC. MULTIPLE WARNING LIGHTS ILLUMINATE, INCLUDING AIRBAG. ALL INTERIOR LIGHTING DIMS SIGNIFICANTLY. REVERSE LIGHTS ILLUMINATE EVEN WHILE IN PARK, OR DRIVING FORWARD. *TR

2005 FORD FIVE HUNDRED SEL 3.0L V6 AUTOMATIC 6 SPEED TRANSMISSION ACCELERATING ON INTERSTATE CAR SEVERELY HARD SHIFTED AND THEN RPMS FLARED LET OFF GAS AND CAR SLAMMED INTO A LOWER GEAR NOW CAR HARD SHIFTS IN DOWN GEARS AND RPMS GO UP CAR DOESN'T MOVE SOMETIMES WHILE ACCELERATING VERY SPORADIC AND DANGEROUS. *TR

THE THROTTLE BODY IS DEFECTIVE AND NEEDS TO BE REPLACED. THE SYMPTOMS ARE VERY DANGEROUS: THE CAR GOES INTO FAIL SAFE MODE AND CANNOT ACCELERATE. ON ONE OCCASION THIS HAPPENED IN THE MIDDLE OF THE ROAD; FORTUNATELY IT WAS A QUIET STREET AND I WAS ABLE TO COAST TO THE SIDE OF THE STREET. IF THIS HAD HAPPENED ON A BUSY STREET IT COULD HAVE CAUSED INJURY OR DEATH. SEVERAL MECHANICS DID DIFFERENT KINDS OF REPAIRS, BUT THE PROBLEM KEPT RECURRING. WE ARE NOW GETTING THE THROTTLE BODY REPLACED AND HOPE THIS IS THE FINAL REPAIR THAT REMOVES THE PROBLEM. NUMEROUS OTHER FORD FIVE HUNDRED OWNERS HAVE EXPERIENCED THIS (PER INTERNET RESEARCH). FORD NEEDS TO RECALL THE FIVE HUNDRED AND REPLACE THE THROTTLE BODY TO PREVENT INJURY OR DEATH. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHT FAILED. THE CONTACT WAS UNABLE TO SEE THE MILES DRIVEN OR ANY OF THE OTHER COMPONENTS ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE INSTRUMENT PANEL DIGITAL SYSTEM. THE VEHICLE WAS REPAIRED. THE DEALER REPLACED THE ELECTRICAL INSTRUMENT PANEL DIGITAL SYSTEM. THE FAILURE AND THE CURRENT MILEAGE WAS 59,090.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHETHER REVERSING OR AT A STOP, THE VEHICLE WOULD SUDDENLY ACCELERATE ABNORMALLY. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSED THAT LOCATED THE FAILURE AT THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 59,000 AND THE CURRENT MILEAGE WAS 95,000.

TSB 10-2-13. I HAVE INNER REAR TIRE WEAR, ESPECIALLY ON THE RIGHT (THIS LIKELY EXISTED WHEN PURCHASED NEW). THERE IS A TSB THAT TALKS ABOUT SOME CARS WITH RR NEGATIVE CAMBER, (WHICH MY CAR DOES HAVE), AND ALSO TALKS ABOUT HOW TO MODIFY THE REAR CONTROL ARM TO REMEDY THE PROBLEM. THE DANGER IN THIS DEFECT IS A BLOWOUT OF A TIRE OR TIRES WHILE DRIVING. CAR IS IMMACULATE. I BOUGHT IT NEW AND TAKE GREAT CARE OF IT. THIS IS OBVIOUSLY A DEFECT GIVEN HOW MANY OTHER OWNERS ARE COMMENTING IT ON-LINE VIA FORUMS. ALSO, THERE IS A TSB ON IT, SO FORD IS AWARE OF IT. EVEN THOUGH THEY SHOULD TAKE CARE OF IT SINCE IT IS A DEFECT, THEY WON'T. FORD, EVEN WITH ALL THEIR HYPE ON QUALITY AND SAFETY AS JOB ONE, ARE JUST A BUNCH OF HYPOCRITES. THEY ACT ONLY WHEN FORCED TO DO SO BY YOU FOLKS AT THE FEDERAL LEVEL. I'M OLD SCHOOL. IT'S ALL ABOUT INTEGRITY FOR ME. WHY DO YOU THINK FORD STILL LIVES UP TO THEIR REPUTATION AS FIX OR REPAIR DAILY. HAD A SIMILAR ISSUE WITH THE REAR BRAKES SEVERAL YEARS AGO ON THIS VEHICLE. I TOOK IT FOR FORD AND THEY WOULD NOT OWN UP TO IT UNTIL I COMPLAINED TO YOU FOLKS LIKE MANY OTHER DID AND THEY FINALLY REIMBURSED US BECAUSE OF YOUR INTERVENTION. AGAIN, THEY ALWAYS HAVE TO BE FORCED TO DO THE RIGHT THING! JUST A BUNCH OF THUGS. WHERE IS ELLIOT NESS WHEN YOU NEED HIM! 02/15/10. SUSPENSION - REAR TIRE INNER EDGE WEAR FORD: 2005-2007 FIVE HUNDRED, FREESTYLE, 2008-2009 TAURUS X, TAURUS. *KB

NOT SURE THE EXACT TIME BUT WITHIN THE PAST YEAR OR SO MY 2005 FORD FIVE HUNDRED ( PURCHASED NEW) IS GOING INTO FAILSAFE MODE LIMITED THROTTLE POWER, VERY SPORADIC AT FIRST BUT NOW HAPPENING QUITE OFTEN. IF YOU PULL OVER AND SHUT THE CAR OFF AND RESTART IT CLEARS AND DRIVES NORMAL. MY DAUGHTER WAS DRIVING IT YESTERDAY AND IT HAPPENED 7 TIMES FROM MALL TO THE HOUSE (ABOUT 20 MILES). ONCE WHILE SHE WAS IN HEAVY TRAFFIC DRIVING ABOUT 55 MPH. CAR JERKED THEN STARTED SLOWING DOWN. THIS IS A SAFETY ISSUE THAT NEEDS TO BE LOOKED AT. VERY DANGEROUS. MY MECHANIC IS TROUBLE SHOOTING PROBLEM, LOOKING LIKE THROTTLE BODY OR GAS PEDAL. I BELIEVE FORD CAME OUT WITH A NEW THROTTLE BODY IN 2010 TO CORRECT THE PROBLEM (TSB 05-25-13)BUT WILL ONLY REPLACE IT AT THEIR COST IF STILL UNDER WARRANTY, OTHERWISE THE COST IS ON US THE CONSUMER. (ABOUT A THOUSAND DOLLARS). *TR